Product ID:MS-171/CO2 CONNECTOR PLUS
MSDS Date:08/01/1992
FSC:6850
NIIN:01-120-9514
MSDS Number: BSBCW

MILLER-STEPHENSON CHEMICAL CO

GEORGE WASHINGTON HIGHWAY
DANBURY, CT 06810
US

Emergency Phone: 203-797-2212,800-424-9300(CHEMTREC)

Info Phone: 203-743-4447

Preparer: JANET STEPHENS

Cage: 18598

MILLER-STEPHENSON CHEMICAL CO INC

950 DANBURY, CT 06810 US

Telephone: 203-743-4447

Cage: 18598

METHYL CHLOROFORM (1,1,1-TRICHLOROETHANE) (SARA III)

CAS: 71-55-6

RTECS: KJ2975000

Fraction By Weight: 96.0%

OSHA PEL 350 PPM

ACGIH TLV: 350 PPM/450STEL;9394

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

CARBON DIOXIDE

CAS: 124-38-9

RTECS: FF6400000

Fraction By Weight: 3 - 5%

OSHA PEL 5000 PPM

ACGIH TLV: 5000PPM/30000STEL;93

POLYPHENYL ETHER

CAS: 3705-62-2

Fraction By Weight: 1%

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: EXTREME IRRITATION. SKIN:
PROLONGED CONTACT CAN CAUSE IRRITATION AND DERMATITIS. INHALATION:
DIZZINESS, HEADACHE, NARCOSIS, ANESTHESIA, SUFFOCATION, CIRCULATORY
DEPRESSION, CNS DAMAGE, AND DEATH IN CONFINED AREAS. INGESTION:
IRRITATION OF MOUTH AND GI TRACT AND THE EFFECTS LISTED FOR
INHALATION.
Effects of Overexposure:EYES: IRRITATION. SKIN: IRRITATION, DERMATITIS.
INHALATION: DIZZINESS, HEADACHE, NARCOSIS, ANESTHESIA, SUFFOCATION,
CIRCULATORY DEPRESSION, CNS DAMAGE, AND DEATH IN CONFINED AREAS.
INGESTION: IRRITATI ON OF MOUTH AND GI TRACT AND THE EFFECTSLISTED
FOR INHALATION.
Medical Cond Aggravated by Exposure:PERSON WITH PRE-EXISTING DISEASE
INVOLVING THE EYES, SKIN, RESPIRATORY TRACT, OR CARDIOVASCULAR
DISEASE MAY BE AT INCREASED RISK FROM EXPOSURE TO THIS PRODUCT.

First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER. IF IRRITATION
PERSISTS, GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED
CLOTHING. WASH AREA WITH SOAP AND WATER. IF IRRITATION OCCURS, GET
MEDICAL ATTENTION. INHALATION: MOVE TO FRESH AIR. IF NECESSARY
GIVE CPR OR OXYGEN. GET MEDICAL ATTENTION. INGESTION: IF CONSCIOUS,
DRINK LARGE AMOUNTS OF WATER. DO NOT INDUCE VOMITING. GET MEDICAL
ATTENTION.

Flash Point Method:TOC
Flash Point:NONE
Lower Limits:8%
Upper Limits:15%
Extinguishing Media:WATER, DRY CHEMICALS, OR CARBON DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
FOR POSSIBLE EXPOSURE TO HYDROGEN CHLORIDE AND POSSIBLE TRACES OF
PHOSGENE.
Unusual Fire/Explosion Hazard:AT ELEVATED TEMPERATURES AEROSOL
CONTAINERS MAY VENT, BURST, GENERATING FLYING DEBRIS. INTENSE HEAT
MAY CAUSE DECOMPOSITION WITH EMISSION OF HALOGEN ACIDS.

Spill Release Procedures:VENTILATE AREA. REMOVE IGNITION SOURCES. DIKE
SPILL. COLLECT ON ABSORBENT MATERIAL. TRANSFER TO STEEL DRUMS FOR
RECOVERY OR DISPOSAL. IF SPILL IS SMALL ALLOW TO EVAPORATE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DO NOT STORE NEAR SOURCES OF HEAT,
DIRECT SUNLIGHT, OR WHERE TEMPERATURES EXCEED 49C/120F. ROTATE
STOCK TO SHELF LIFE OF ONE YEAR.
Other Precautions:DO NOT PUNCTURE OR DAMAGE CONTAINERS. DO NOT SPRAY
LIQUID ON HANDS OR DIRECT SPRAY TO EYES. DO NOT USE IN POORLY
VENTILATED OR CONFINED AREAS WITHOUT PROPER RESPIRATORY PROTECTION.
VAPORS ARE HEAVIER THAN AIR AND WILL COLLECT IN LOW AREAS.

Respiratory Protection:UNDER NORMAL MANUFACTURING CONDITIONS NO
RESPIRATORY PROTECTION IS REQUIRED, BUT ADEQUATE VENTILATION IS
REQUIRED TO CONTROL EXPOSURE BELOW PERMISSIBLE LIMITS.
Ventilation:ADEQUATE VENTILATION IS REQUIRED TO CONTROL EXPOSURES BELOW
PERMISSIBLE LIMITS.
Protective Gloves:NEOPRENE, VITON, OR POLYETHYLENE GLOVES.
Eye Protection:CHEMICAL SPLASH GOGGLES.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health

HCC:V2
Boiling Pt:B.P. Text:165F,74C
Vapor Pres:120 @ 68F
Vapor Density:4.54 @ 68F
Spec Gravity:1.31
pH:6-7.5
Evaporation Rate & Reference:0.13 (CCL4=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR,COLORLESS LIQUID. ETHEREAL ODOR.
Percent Volatiles by Volume:99

Stability Indicator/Materials to Avoid:YES
FINELY DIVIDED REACTIVE METALS AND STRONG CAUSTICS.
Stability Condition to Avoid:AVOID SPRAYING NEAR OPEN FLAMES OR RED HOT
SURFACES. DO NOT HEAT AEROSOL CNTNRS ABOVE 49C/120F.
Hazardous Decomposition Products:CAN BE DECOMPOSED BY HIGH TEMPERATURES
(OPEN FLAMES, GLOWING SURFACES, ETC.) FORMING HALOGEN ACIDS AND
PHOSGENE .
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL, STATE
AND FEDERAL REGULATIONS. DO NOT PUNCTURE OR INCINERATE AEROSOL
CANS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.