Product ID:PVC SOLVENT CEMENT, LIGHT DUTY CLEAR
MSDS Date:04/01/1990
FSC:8040
NIIN:00N044963
MSDS Number: BSCLY

NIBCO INC

2929 WEST MAGAZINE ST
LOUISVILLE, KY 40211
US

Emergency Phone: 303-623-5716

Info Phone: 303-623-5716

Preparer: JACK HUNT

Cage: 61623

NIBCO INC

LOUISVILLE, KY 40211 US

Telephone: 303-623-5716

Cage: 61623

2-BUTANONE; (METHYL ETHYL KETONE) (MEK) (SARA III)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 38-48%

OSHA PEL 200 PPM;300 PPM STEL

ACGIH TLV: 200 PPM;300 PPM STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

FURAN, TETRAHYDRO-; (TETRAHYDROFURAN) (SARA III).

CAS: 109-99-9

RTECS: LU5950000

Fraction By Weight: 30-40%

OSHA PEL 200 PPM;250 PPM STEL

ACGIH TLV: 200 PPM;250 PPM STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ETHYLENE, CHLORO-, POLYMER; (PVC RESIN)

CAS: 9002-86-2

RTECS: KV0350000

Fraction By Weight: 10-14%

OSHA PEL N/K

ACGIH TLV: N/K

CYCLOHEXANONE (SARA III)

CAS: 108-94-1

RTECS: GW1050000

Fraction By Weight: 5-10%

OSHA PEL 25 PPM, S

ACGIH TLV: 25 PPM, S

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ACETONE (SARA III)

CAS: 67-64-1

RTECS: AL3150000

Fraction By Weight: <10%

OSHA PEL 750PPM;1000 PPM STEL

ACGIH TLV: 750PPM;1000 PPM STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

SILICA; (FUMED SILICA)

CAS: 7631-86-9

Fraction By Weight: 1-2%

OSHA PEL 6 MG/M3

ACGIH TLV: 10 MG/M3

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:SEV OVEREXP MAY RSLT IN
NAUS, DIZZ, HDCH. CAN CAUSE DROW, IRRIT OF EYES & NASAL PASSAGES.
HAS CAUSED CNS DEPRESS, LIVER & KIDNEY DMG IN ANIMALS, & HIGH CONC
HAVE CAUSED RETARDATION OF FETA L DEVEL IN RATS. SKIN:IRRITANT. LIQ
CONT MAY REMOVE NATRL OILS RESULTING IN IRRIT. DERM MAY OCCUR W/
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:PRLNG CONT. PRLNG/WIDESPREAD EXPOS MAY
RSLT IN ABSORPTION OF HARMFUL AMTS OF MATL. EYE:OVEREXP MAY RSLT IN
SEV INJURY W/CORNEAL OR CONJ INFLAMM ON CONT W/LIQ. VAPS SLIGHTLY
UNCOMFORTABLE. ING EST:MOD TOX. MAY CAUSE NAUS, VOMIT, DIARR. MAY
CAUSE MENTAL SLUGGISHNESS. REPRO TOXIN, NERV SYS TOXIN, (SUPP DATA)
Medical Cond Aggravated by Exposure:NONE CURRENTLY KNOWN.

First Aid:INHAL:REMOVE TO FRESH AIR & IF BRTHG STOPPED, GIVE ARTF RESP
- PREFERABLY MOUTH-TO-MOUTH. IF BRTHG IS DFCLT, GIVE OXYGEN. CALL
MD. EYE:FLUSH W/PLENTY OF WATER FOR AT LST 15 MINS & CALL MD.
SKIN:REMOVE CONTAM CLTHG & SHOES. WASH W/PLENTY OFSOAP & WATER FOR
AT LST 15 MINS. IF IRRIT DEVELOPS, GET MED ATTN. INGEST:GIVE 1-2
GLASSES OF WATER/MILK. DO NOT INDUCE VOMIT. CALL MD/POIS CTL CTR
IMMED.

Flash Point Method:TOC
Flash Point:SEE ING 2
Lower Limits:1.8%
Upper Limits:10%
Extinguishing Media:USE DRY CHEMICAL, CO*2, WATER OR FOAM EXTINGUISHER.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . FOR LARGE FIRES:EVACUATE AREA & CALL FIRE DEPARTMENT
IMMEDIATELY.
Unusual Fire/Explosion Hazard:FIRE HAZARD BECAUSE OF LOW FLASH POINT &
HIGH VOLATILITY. VAPORS ARE HEAVIER THAN AIR & MAY TRAVEL TO SOURCE
OF IGNITION.

Spill Release Procedures:VENTILATE AREA, STOP LEAK IF IT CAN BE DONE
W/OUT RISK. TAKE UP W/SAND, EARTH OR OTHER ABSORBING MATERIAL.
PREVENT LIQUID FROM ENTERING DRAINS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:IRRITANT. FLAMMABLE LIQUID.
Other Precautions:CONTAINERS, EVEN THOSE THAT HAVE BEEN EMPTIED, WILL
RETAIN RESIDUE & VAPORS. HANDLE EMPTY CONTAINERS AS IF THEY WERE
FULL.

Respiratory Protection:IN SITUATIONS WHERE VAPOR CONCENTRATIONS EXCEED
RECOMMENDED EXPOSURE LIMITS, A NIOSH/MSHA APPROVED ORGANIC VAPOR
CARTRIDGE RESPIRATOR W/FULL FACE-PIECE IS RECOMMENDED. USE ONLY
NIOSH/MSHA APPROVED SCB A FOR EMERGENCIES.
Ventilation:EXPLOSION-PROOF GENERAL MECHANICAL VENT OR LOCAL EXHAUST IS
REC TO MAINTAIN VAPOR CONCS BELOW REC LIMITS.
Protective Gloves:PVA COATED GLOVES.
Eye Protection:ANSI APPROVED CHEMICAL (SUPP DATA)
Other Protective Equipment:IMPERVIOUS APRON & A SOURCE OF RUNNING WATER
TO FLUSH OR WASH EYES & SKIN IN CASE OF CONTACT.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
% VOLAT:88 +/- 2%. EFTS OF OVEREXP:LUNG TOXIN, LIVER TOXIN, KIDNEY
TOXIN. CHRONIC:NONE CURRENTLY KNOWN. EYE PROTECTION: WORKERS
GOGGLES WITH FULL LENGTH FACESHIELD .

HCC:F3
Boiling Pt:B.P. Text:SEE ING 2
Vapor Pres:SEE ING 2
Vapor Density:2.5
Spec Gravity:0.94 +/- 0.01
Evaporation Rate & Reference:5.5-8 (BUTYL ACETATE=1)
Solubility in Water:SOLUBLE
Appearance and Odor:CLEAR LIQUID; ETHER-LIKE ODOR.
Percent Volatiles by Volume:SUPDAT

Stability Indicator/Materials to Avoid:YES
CAUSTICS, AMMONIA, INORGANIC ACIDS, CHLORINATED COMPOUNDS, STRONG
OXIDIZERS & ISOCYANATES.
Stability Condition to Avoid:KEEP AWAY FROM HEAT, SPKS, OPEN FLAME &
OTHER SOURCES OF IGNIT. ALL HNDLG EQUIP SHOULD BE ELECTRICALLY
GROUNDED.
Hazardous Decomposition Products:WHEN FORCED TO BURN, THIS PRODUCT
GIVES OUT CARBON MONOXIDE, CARBON DIOXIDE, HYDROGEN CHLORIDE &
SMOKE.

Waste Disposal Methods:DISPOSE OF ACCORDING TO LOCAL, STATE & FEDERAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.