Product ID:SOLVENT MX-4MX
MSDS Date:08/04/1989
FSC:6850
NIIN:00N045368
MSDS Number: BSCPZ

FINE ORGANICS CORP

205 MAIN ST
LODI, NJ 07644
US

Emergency Phone: 800-526-7480;800-424-9300(CHEMTREC)

Info Phone: 201-472-6800

Cage: 05867

FINE ORGANICS CORP

2277 CLIFTON, NJ 07015 US

Telephone: 973-478 1000

Cage: 05867

HYDROTREATED HEAVY NAPHTHA (PETROLEUM); (PETROLEUM

CAS: 64742-48-9

Fraction By Weight: 24%

OSHA PEL N/K

ACGIH TLV: N/K

METHANE, DICHLORO-; (METHYLENE CHLORIDE) (SARA III)

CAS: 75-09-2

RTECS: PA8050000

Fraction By Weight: 47%

OSHA PEL 500 PPM;1000 PPM, C

ACGIH TLV: 50 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ETHANE, 1,1,1-TRICHLORO-; (METHYL CLOROFORM) (SARA III)

CAS: 71-55-6

RTECS: KJ2975000

Fraction By Weight: 29%

OSHA PEL 350 PPM;450 PPM STEL

ACGIH TLV: 350 PPM;450 PPM STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:HIGH VAP CONCS ARE IRRIT TO
EYES, NOSE & RESP TRACT & MAY CAUSE POSS HDCHS, DIZZ & NAUS; MAY
CAUSE UNCON IN CONFINED AREAS. WILL CAUSE IRRIT TO EYES IF
CONTACTED. RPTD CONT W/SKIN MAY CAUSE IRRI T. ACCIDENTAL ASPIR INTO
LUNGS IF INGESTED MAY CAUSE PULM INJURY. CHRONIC:OVEREXP AT
ELEVATED CONCS MAY(EFTS OF OVEREXP)
Explanation of Carcinogenicity:METHYLENE CHLORIDE:IARC MONOGRAPHS SUPP,
VOL 7, PG 194, 1987:GRP 2B. NTP 6TH ANNUAL RPT ON CARCINS,
1991:ANTIC (SUPDAT)
Effects of Overexposure:HLTH HAZ:EFT HEART, LIVER & KIDNEYS.
CHLOROCARBON MATLS HAVE PRDCD SENSIT OF MYOCARDIUM TO EPINEPHRINE
IN LAB ANIMALS & COULD HAVE SIMILAR EFT IN HUMANS. ADRENOMIMETICS
(E.G., EPINEPHRINE) MAY BE CONT RAINDICATED EXCEPT FOR
LIFE-SUSTAINING USES IN HUMANS ACUTELY/CHRONICALLY EXPOS TO
CHLOROCARBONS .
Medical Cond Aggravated by Exposure:PRE-EXISTING LIVER & KIDNEY
DISEASE, CARDIAC ABNORMALITIES.

First Aid:INHAL:REMOVE TO FRESH AIR. ADMINISTER ARTIFICIAL RESPIRATION
IF BREATHING HAS STOPPED. EYES:FLUSH THOROUGHLY W/ PLENTY OF WATER
FOR AT LEAST 15 MINUTES WITHIN ONE MINUTE PERIOD OF CONTACT.
SKIN:REMOVE CONTAMINATED CLOTHES. WASH AREA W/WATER. INGEST:DO NOT
INDUCE VOMITING. GIVE WATER. SEEK MEDICAL ATTENTION WHERE
NECESSARY.

Flash Point Method:TCC
Flash Point:NONE TO BOIL
Lower Limits:1%
Upper Limits:6%
Extinguishing Media:CO2, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA &
FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:FIRE HAZARD IF EXPOSED TO HEAT OR FLAMES.
THERMAL DECOMPOSITION PRODUCTS MAY INCLUDE HCL & PHOSGENE .

Spill Release Procedures:REMOVE ALL IGNITION SOURCES. DIKE OR IMPOUND
SPILL. ADD SAND, EARTH OR SUITABLE ABSORBENT. SWEEP UP ABSORBENT &
FOLLOW WASTE DISPOSAL METHODS BELOW.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:REASONABLE CARE & PRECS WHEN HNDLG
THIS PROD ARE REC. AVOID CONTACT W/SKIN OR EYES. OBSERVE ALL
LABELED PRECS. USE ONLY W/ADEQ VENT.
Other Precautions:EMPTY CNTNRS MAY RETAIN HAZ PROD RESIDUES (VAP/LIQ).
NO SMOKING IN AREA OF USE. DO NOT USE IN GEN VICIN OF ARC WELDING,
OPEN FLAMES/HOT SURFS. HEAT &/OR UV RADIA MAY CAUSE FORM OF HCL
&/OR PHOSGENE (F P N).

Respiratory Protection:NIOSH/MSHA APPROVED CARTRIDGE TYPE ADEQUATE TO
REDUCE LEVELS OF CONCENTRATIONS OF HAZARDOUS COMPONENTS BELOW
TLV'S.
Ventilation:MECHANICAL (GENERAL) SUFFICIENT TO MAINTAIN LEVELS BELOW 50
PPM.
Protective Gloves:NEOPRENE GLOVES.
Eye Protection:FACE SHIELD/SAFETY GOGGLES.
Other Protective Equipment:WEAR PROTECTIVE CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLAN OF CARCIN:TO BE CARCINOGEN. ANIMAL: LUNG, LIVER, SALIVARY,
MAMMARY GLAND (TUMORS).

HCC:T4
Boiling Pt:B.P. Text:>104F,>40C
Vapor Pres:228.5 @20C
Spec Gravity:1.128 (H2O=1)
Evaporation Rate & Reference:5 (SLOWER) (CCL4=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WATER WHITE LIQUID; MILDLY SWEET ODOR.
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
COAL TAR INSULATION.
Stability Condition to Avoid:OPEN SPARKS & FLAMES.
Hazardous Decomposition Products:CO, CO2, COCL2. HCL, PHOSGENE .

Waste Disposal Methods:DISPOSE OF I/A/W ANY LOCAL, STATE & FEDERAL
REGULATIONS. DISPOSAL RECOMMENDATIONS APPLY TO THE ORIGINAL
MATERIAL & ITS CONTAINER; NOT ANY MATERIALS WHICH ARE A WASTE
BY-PRODUCT OF THE USER'S OPERATION .

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.