Product ID:FASTENER PANEL & FOAM ADHESIVE, 76-879
MSDS Date:04/07/1987
FSC:8040
NIIN:00N045406
MSDS Number: BSCQZ

CONTECH BRANDS

7711 COMPUTER AVE
MINNEAPOLIS, MN 55435
US

Emergency Phone: 612-835-3434;800-424-9300(CHEMTREC)

Info Phone: 612-835-3434

Cage: CNTEC

SONNEBORN BUILDING PRODUCTS REXNORD CHEM PROD

MINNEAPOLIS, MN 55435 US

Telephone: 612-835-3434;800-424-9300(CHEMTREC)

Cage: 63472

2%.

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: 0.3%

OSHA PEL 400 PPM;500 PPM STEL

ACGIH TLV: 400 PPM;500 PPM STEL

1%.

CAS: 110-54-3

RTECS: MN9275000

Fraction By Weight: 39.61%

OSHA PEL 50 PPM

ACGIH TLV: 50 PPM

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

BELOW HIPS TO AVOID ASPIRATION OF VOMITUS

RTECS: 9999999ZZ

UNTIL DISPOSAL. WASH SPILL AREA W/SOAP & WATER.

RTECS: 9999999ZZ

LD50 LC50 Mixture:SEE INGREDIENT 1.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYES:MODERATE IRRITANT. MAY
CAUSE REVERSIBLE CORNEAL INJURY. SKIN:MODERATE IRRITANT. MAY CAUSE
DERMATITIS & ALLERGIC RESPONSES. INHAL:RESPIRATORY IRRITANT &
INTOXICANT. OVEREXPOSURE SHOWN BY HEA DACHE, DIZZINESS & CONFUSION
TO COMA. MATERIAL ASPIRATED INTO LUNGS MAY CAUSE CHEMICAL
PNEUMONITIS. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:INGEST:MAY CAUSE IRRITATION OF MOUTH,
THROAT & STOMACH. SYMPTOMS INCLUDE NAUSEA, ABDOMINAL PAIN &
POSSIBLE COLLAPSE. CHRONIC:THIS MATERIAL CONTAINS N-HEXANE WHICH
HAS BEEN SHOWN TO PRODUCE PE RIPHERAL POLYNEUROPATHY IN INDIVIDUALS
EXPOSED REPEATEDLY TO CONCENTRATIONS IN THE 1000-1500 PPM RANGE.
Medical Cond Aggravated by Exposure:PREEXISTING PULMONARY &
DERMATOLOGICAL DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO HAZARDOUS
COMPONENTS.

First Aid:EYES:FLUSH W/PLENTY OF WATER FOR AT LST 15 MINS. OBTAIN IMMED
MED ATTN. SKIN:REMOVE CONTAM CLTHG. WASH AFFECTED AREA(S) THORO
W/SOAP & WATER. CONSULT MD. INHAL:REMOVE TO FRESH AIR. IF BRTHG IS
DFCLT, GIVE OXYGEN. ADMIN ARTF RESP IF NOT BRTHG. OBTAIN MED ATTN.
INGEST:DO NOT INDUCE VOMIT. GIVE WATER/MILK IF VICTIM IS CONSCIOUS
& NOT DROWSY. SHOULD VOMIT OCCUR, BE SURE TO KEEP VICTIM'S HEAD
(ING 3)

Flash Point Method:TCC
Flash Point:<0F,<-18C
Lower Limits:1.1% & INGS
Upper Limits:12%
Extinguishing Media:FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
USE WATER TO COOL EXPOS CNTNRS. WATER STREAM DIRECTED INTO FIRE MAY
CAUSE FROTHING W/SUBSEQUENT (SUPDAT)
Unusual Fire/Explosion Hazard:IRRIT &/OR TOX GASES/FUMES MAY BE
GENERATED BY THERMAL DECOMP/COMBUST. CLSD CNTNRS MAY
RUPTURE/EXPLODE (DUE TO PRESS BUILD-UP) WHEN EXPOS TO EXTREME
(SUPDAT)

Spill Release Procedures:VENTILATE AREA. WEAR APPROP PROT EQUIP DURING
CLEANUP. ELIM SOURCES OF IGNIT. SHUT OFF SOURCE OF LEAK IF SAFE TO
DO SO. DIKE/CONTAIN SPILL. ABSORB W/INERT MATL. SWEEP/SHOVEL INTO
CNTNRS W/ LIDS. COVER LOOSELY & STORE IN WELL-VENTILATED AREA (ING
4)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:FOR PROFESSIONAL USE ONLY. DO NOT TAKE
INTERNALLY. AVOID CONTACT W/EYES, SKIN & CLOTHING. AVOID BREATHING
VAPOR, DUST OR MIST.
Other Precautions:TIGHTLY RESEAL ALL PARTIALLY USED CNTNRS. USE ONLY W/
ADEQ VENT. STORE AWAY FROM SOURCES OF IGNIT. THIS CNTNR HAZ WHEN
EMPTY. DO NOT REUSE EMPTY CNTNR W/OUT COMMERCIAL CLEAN/RECONDITION.
STORE EMPTY C NTNR AWAY FROM HEAT & FLAME.

Respiratory Protection:IF THE TLV IS EXCEEDED, IF USE IS PERFORMED IN A
POORLY VENTILATED CONFINED SPACE OR AREA W/LIMITED VENTILATION, USE
NIOSH/ MSHA APPROVED RESPIRATOR I/A/W 29 CFR 1910.134.
Ventilation:LOCAL EXHAUST AS NEEDED TO CONTROL VAPOR/DUST LEVELS TO
BELOW RECOMMENDED LIMITS.
Protective Gloves:IMPERVIOUS RUBBER GLOVES.
Eye Protection:CHEMICAL SAFETY GOGGLES.
Other Protective Equipment:ACCESSIBLE EYE WASH & SAFETY SHOWER. CLEAN
PROTECTIVE CLOTHING. RUBBER APRON.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
EVAP RATE:TO N-BUTYL ACETATE). FIRE FIGHT PROC:SPREAD OF FIRE. EXPLO
HAZ:HEAT. VAP IS HVR/AIR & MAY TRAVEL ALONG GROUND TO BE REIGNITED
AT LOCATIONS DIST FROM SOURCE; FLASHBACK OF FLAME MAY OCCUR. EMP TY
CNTNRS MAY CONTAIN EXPLO VAPS/DANGEROUS RESIDUE. DO NOT CUT,
PUNCTURE/WELD ON/NEAR CNTNR.

HCC:F3
Boiling Pt:B.P. Text:148F,64C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.02
Evaporation Rate & Reference:FASTER (RELATIVE (SUPDAT)
Solubility in Water:NEGLIGIBLE (<0.1%)
Appearance and Odor:VISCOUS LIQUID W/STRONG SOLVENT ODOR.
Percent Volatiles by Volume:59.2

Stability Indicator/Materials to Avoid:YES
STRONG BASES OR OXIDANTS. STRONG LEWIS OR MINERAL ACIDS.
Stability Condition to Avoid:SOURCES OF IGNITION.
Hazardous Decomposition Products:ACRID SMOKE. OXIDES OF CARBON.

Waste Disposal Methods:REVIEW ALL LOCAL, STATE & FEDERAL REGULATIONS
CONCERNING HEALTH & POLLUTION FOR APPROPRIATE DISPOSAL PROCEDURES.
EPA RCRA NUMBER:D001 (IGNITABLE).

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.