Product ID:ROYCO 363 B
MSDS Date:04/02/1991
FSC:9150
NIIN:00-273-2397
MSDS Number: BSCVD

ROYAL LUBRICANTS CO INC

MERRY LANE
EAST HANOVER, NJ 07936
US

Emergency Phone: 201-887-7411/800-424-9300(CHEMTREC)

Info Phone: 201-887-7410

Cage: 6V632

ROYAL LUBRICANTS CO INC (REPLACED BY CAGE CODE 07950)

518 EAST HANOVER, NJ 07936 US

Telephone: 201-887-7410

Cage: 6V632

MINERAL OIL/SEVERELY HYDROTREATED LIGHT NAPHTHENIC DIST.

CAS: 64742-53-6

RTECS: PY8036000

Fraction By Weight: 80 - 90%

OSHA PEL 5 MG/M3 OIL MIST.

ACGIH TLV: 5 MG/M3 OIL MIST.

DISTILLATES, SOLVENT-REFINED LIGHT NAPHTHENIC

CAS: 64741-97-5

RTECS: PY8041000

OSHA PEL NOT ESTABLISHED.

ACGIH TLV: NOT ESTABLISHED.

ADDITIVE CONTAINING BARIUM

Fraction By Weight: 2%

MINOR ADDITIVES

Fraction By Weight: <1%

LD50 LC50 Mixture:TLV FOR OIL MIST IS 5 MG/M3.
Routes of Entry: Inhalation:NO Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE- MAY CAUSE MILD EYE & SKIN
IRRITATION. PROLONGED/REPEATED SKIN CONTACT MAY CAUSE VARIOUS SKIN
DISORDERS SUCH AS DERMATITIS, OIL ACNE/FOLLICULITIS. INHALATION OF
VAPORS/MIST MAY CAUSE MILD UPPER RESPIRATORY TRACT IRRITATION.
ASPIRATION HAZARD IF SWALLOWED. CHRONIC- UNKNOWN. TARGET
ORGANS:EYES, SKIN, LUNGS.
Effects of Overexposure:SLIGHT EYE, SKIN AND RESPIRATORY TRACT
IRRITATION
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS OR IMPAIRED RESPIRATORY FUNCTION MAY BE MORE SUSCEPTIBLE
TO THE EFFECTS OF THIS PRODUCT.

First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. SKIN:REMOVE
EXCESS. WASH SKIN WITH SOAP & WATER. EYE:FLUSH WITH WATER FOR 15
MINUTES, HOLDING EYELIDS OPEN. INHALED:REMOVE TO FRESH AIR &
PROVIDE OXYGEN/CPR IF NEEDED. ORAL:DO NOT INDUCE VOMITING.IF
VOMITING OCCURS SPONTANEOUSLY, KEEP HEAD BELOW HIPS TO PREVENT
ASPIRATION OF LIQUID INTO THE LUNGS. GET MEDICAL ATTENTION.

Flash Point Method:COC
Flash Point:250F,121C
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL. DO NOT USE A DIRECT STREAM OF WATER. PRODUCT WILL FLOAT &
REIGNITE
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND
NIOSH-APPROVED SELF CONTAINED BREATHING APPARATUS. COOL FIRE
EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:TOXIC SULFUR OXIDES, HYDROGEN SULFIDE

Spill Release Procedures:DIKE AND CONTAIN SPILL. DO NOT ALLOW MATERIAL
TO ENTER DRAINS, SEWERS OR WATERWAYS. RECOVER MATERIAL IF POSSIBLE.
ABSORB SPILL WITH NON-FLAMMABLE ABSORBANT AND PLACE INTO PROPER
CONTAINERS FOR DISPOSA L. REMOVE LARGE SPILLS WITH VACUUM TRUCKS OR
PUMP.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE IN COOL, DRY PLACE AWAY FROM
HEAT, FLAME & STRONG OXIDANTS. KEEP CONTAINERS CLOSED WHEN NOT IN
USE.
Other Precautions:WASH THOROUGHLY AFTER HANDLING AND BEFORE EATING OR
DRINKING. DO NOT WELD, HEAT OR DRILL CONTAINER. RESIDUE MAY IGNITE.

Respiratory Protection:NO SPECIAL RESPIRATORY PROTECTION IS NORMALLY
REQUIRED. HOWEVER, IF WORKING IN A CONFINED AREA OR MISTING IS
OCCURING, USE A NIOSH-APPROVED RESPIRATOR TO PREVENT OVEREXPOSURE.
Ventilation:USE ADEQUATE VENTILATION TO KEEP OIL MISTS OF THIS MATERIAL
BELOW APPLICABLE STANDARD(S).
Protective Gloves:RUBBER, LATEX TO MINIMIZE SKIN CONTACT
Eye Protection:SAFETY GLASSES, FACE SHIELD
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
NOTE TO PHYSICIAN: IF MORE THAN 2 ML PER KG HAS BEEN INGESTED AND
VOMITING HAS NOT OCCURED, EMESIS SHOULD BE INDUCED WITH
SUPERVISION. IF SYMPTOMS SUCH AS CONVULSION OR UNCONSCIOUSNESS
OCCUR BEFORE EM ESIS, GASTRIC LAVAGE USING A CUFFED ENDOTRACHEAL
TUBE SHOULD BE CONSIDERED.

HCC:V6
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text: 450F,232C
Vapor Pres:NOT KNOWN
Spec Gravity:0.88
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR LIQUID - STRONG PETROLEUM ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXCESSIVE HEAT, OPEN FLAME
Hazardous Decomposition Products:SULFUR OXIDESS, HYDROGEN SULFIDE,
CARBON MONOXIDE, CARBON DIOXIDE MAY BE FORMED.

Waste Disposal Methods:DISPOSE OF WASTE IN COMPLIANCE WITH ALL
APPLICABLE LOCAL, STATE AND FEDERAL LAWS AND REGULATIONS. RCRA
EMERGENCY NUMBER: 800-424-9346.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.