Product ID:ROYCO 46
MSDS Date:07/18/1995
FSC:9150
NIIN:00-889-3522
MSDS Number: BSCXT

Emergency Phone: 201-887-7411

Info Phone: 201-887-7410

Preparer: NOT PROVIDED

Cage: 07950

Telephone: 973-887-7411/7410

Cage: 07950

SYNTHETIC ESTER

CAS: 122-62-3

RTECS: VS1000000

BARIUM DINONYLNAPHTHALENE SULFONATE

CAS: 25619-56-1

DIISOPROPYL HYDROGEN PHOSPHITE

CAS: 1809-20-7

RTECS: SZ6600000

OTHER COMPONENTS

LD50 LC50 Mixture:NOT PROVIDED
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE CONTACT: BASED ON THE PRESENCE OF
COMPONENTS 2 AND 3, PRODUCT IS PRESUMED TO BE IRRITATING TO THE
EYES. SKIN CONTACT: PROLONGED OR RELEATED CONTACT MAY CAUSE VARIOUS
SKIN DISORDERS SUCH AS DERMITI TIS, FOLLICULITIS OR OIL ACNE.
RELEASE DURING HIGH PRESSURE USAGE MAY RESULT IN INJECTION OF OIL
INTO THE SKIN CAUSING LOCAL NECROSIS. INHALATION: NOT EXPECTED TO
BE A RELEVANT ROUTE OF EXPOSURE, HOWE VER, UNDER HIGH TEMPERATURE
CONDITIONS, VAPORS IRRITATING TO THE NOSE, THROAT AND UPPER
RESPIRATORY TRACT MAY BE PRODUCED. INGESTION: NO SPECIFIC
INFORMATION IDENTIFIED.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION AS NOTED ABOVE. LOCAL NECROSIS IS
EVIDENCED BY DELAYED ONSET OF PAIN AND TISSUE DAMAGE A FEW HOURS
FOLLOWING INJECTION.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.

First Aid:EYE: FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING EYELIDS
OPEN. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING AND
WIPE EXCESS OFF. WASH WITH SOAP AND WATER/WATERLESS HAND CLEANER
FOLLOWED BY SOAP AND WATER. IF IRRITATION PERSISTS, GET MEDICAL
ATTENTION. IF MATERIAL IS INJECTED UNDER SKIN, GET MEDICAL
ATTENTION PROMPTLY TO PREVENT SERIOUS DAMAGE: DO NOT WAIT FOR
SYMPTOMS TO DEVELOP. IN HALATION: REMOVE VICTIM TO FRESH AIR.
PROVIDE OXYGEN IF BREATHING IS DIFFICULT. GET MEDIAL ATTENTION.
INGESTION: DO NOT INDUCE VOMITING. IN GENERAL NO TREATMENT IS
NECESSARY UNLESS LARGE QUANTITIES AR E INGESTED. HOWEVER, GET
MEDICAL ADVICE

Flash Point:>93.3C, 200.F
EST
Extinguishing Media:WATER FOG, DRY CHEMICAL/CARBON DIOXIDE. DON'T USE
DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE REIGNITED ON
SURFACE OF WATER.
Fire Fighting Procedures:DO NOT ENTER ANY ENCLOSED OR CONFINED AREA
WITHOUT PROPER PROTECTIVE EQUIPMENT AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED CONTAINERS
SURROUNDING EQUIPMENT AND STRUCTURES WITH WATER.
Unusual Fire/Explosion Hazard:NOT PROVIDED

Spill Release Procedures:SCOOP UP EXCESS GREASE. CLEAN AREA WITH
APPROPRIATE CLEANER.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE IN COOL, DRY PLACE, WITH
ADEQUATE VENTILATION. KEEP AWAY FROM OPEN FLAMES AND HIGH
TEMPERATURES. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:MINIMIZE SKIN CONTACT. WASH WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
LAUNDER CONTAMINATED CLOTHING BEFORE REUSE. PROPERLY DISPOSE OF
CONTAMINATED LEATHER ARTICL ES, INCLUDING SHOES, THAT CANNOT BE
DECONTAMINATED.

Respiratory Protection:NOT ORDINARILY REQUIRED.
Ventilation:NOT PROVIDED
Protective Gloves:OIL RESISTANT GLOVES
Eye Protection:CHEMICAL GOGGLES IF THERE IS LIKELYHOOD OF CONTACT WITH
EYES
Other Protective Equipment:USE OIL RESISTANT CLOTHING AS NEEDED TO
MINIMIZE SKIN CONTACT.
Work Hygienic Practices:NOT PROVIDED
Supplemental Safety and Health
NOTE TO PHYSICIAN: IN GENERAL, EMESIS INDUCTION IS UNNECESSARY IN HIGH
VISCOSITY, LOW VOLATILITY PRODUCTS, I.E., MOST OILS AND GREASES.
ABBREVIATION: N/A=NOT APPLICABLE OR NOT AVAILABLE. N/K=UNKNOWN.
N/P=NOT PROVIDED. N/R=NOT RELEVANT. N/D=NOT DETERMINED. N/E=NOT
ESTABLISHED.

HCC:V6
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:NOT AVAILABLE
Melt/Freeze Pt:M.P/F.P Text:NOT AVAILABLE
Decomp Temp:Decomp Text:NOT PROVIDED
Vapor Pres:NOT AVAILABLE
Spec Gravity:NOT AVAILABLE
Viscosity:NOT PROVIDED
Evaporation Rate & Reference:NOT AVAILABLE
Solubility in Water:INSOLUBLE
Appearance and Odor:TAN SEMI-FLUID, SLIGHT ODOR
Corrosion Rate:NOT PROVIDED

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:OPEN FLAMES, HEAT
Hazardous Decomposition Products:A COMPLEX MIXTURE OF AIRBORNE SOLID,
LIQUID PARTICULATES AND GASES EVOLVE WHEN MATERIAL UNDERGOES
PYROLYSIS/COMBUSTION. CARBON MONOXIDE AND UNIDENTIFIED ORGANIC
COMPOUNDS MAY BE FORMED UPON COMBUSTION.

Waste Disposal Methods:CONTAINS BARIUM AT > 100 MG/L. UNDER EPA-RCRA
(40 CFR 261.24), A WASTE CONTAING BARIUM IS HAZARDOUS (WASTE NUMBER
D005), IF IT EXHIBITS THE CHARACTERISTIC OF TOXICITY BASED ON THE
EXTRACTED CONCENTRAT ION OF BARIUM AS SHOWN BY TOXICITY
CHARACTERISTIC LEACHING PROCEDURE (TCLP). MATERIAL MAY BE RECYCLE
D. CHECK LOCAL AND STATE REGULATIONS.

Toxicological Information:BASED UPON DATA AVAILABLE TO ROYAL, COMPONENT
4 IN THIS PRODUCT IS NOT HAZARDOUS UNDER OSHA HAZARD COMMUNICATION
(29 CFR 1910.1200).

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:NOT PROVIDED

Transport Information:DEPARTMENT OF TRANSPORATION CLASSIFICATION: NOT
HAZARDOUS BY D.O.T. REGULATIONS.

SARA Title III Information:NOT PROVIDED
Federal Regulatory Information:THE COMPONENTS OF THIS PRODUCT ARE
LISTED ON THE EPA/TSCA INVENTORY OF CHEMICAL SUBSTANCES.
State Regulatory Information:NOT PROVIDED