Product ID:PHOSPHORIC ACID 85 PCT,TECH GRADE
MSDS Date:11/22/1991
FSC:6810
NIIN:01-244-7686
MSDS Number: BSCZW

Emergency Phone: 803-554-1229/800-424-9300(CHEMTREC)

Info Phone: 803-554-1229

Cage: 0DPR6

Telephone: 504-733-6600

Cage: 0LNB7

NO INGREDIENT FOR THIS FORMULATION_INGREDIENT

LD50 LC50 Mixture:TLV IS 1 MG/M3.
Routes of Entry: Inhalation:NO Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE- CORROSIVE. TOXIC BY INHALATION.
CAN CAUSE BURNS ON CONTACT. CHRONIC- UNKNOWN. TARGET ORGANS:EYES,
SKIN, RESPIRATORY AND GASTROINTESTINAL TRACTS.
Effects of Overexposure:CORROSIVE. SEVERE EYES, SKIN, RESPIRATORY AND
DIGESTIVE TRACTS IRRITATION AND BURNS
Medical Cond Aggravated by Exposure:NOT KNOWN

First Aid:GET MEDICAL ATTENTION IMMEDIATELY. EYE/SKIN:IMMEDIATELY FLUSH
WITH WATER FOR AT LEAST 15 MINUTES. HOLD EYELIDS OPEN.
INHALED:REMOVE TO FRESH AIR & PROVIDE OXYGEN/CPR IF NEEDED. ORAL:DO
NOT INDUCE VOMI TING. IF CONSCIOUS, DRINK LARGE AMOUNT OF
WATER/MILK. CALL A PHYSICIAN IMMEDIATELY. NEVER GIVE ANYTHING BY
MOUTH TO AN UNCONSCIOUS PERSON.

Flash Point:NONE
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS.

Spill Release Procedures:WEAR FACE PROTECTION, RUBBER BOOTS, APRON AND
GLOVES. DIKE SPILL WITH SAND OR CLAY TO KEEP IT OUT OF SEWER
SYSTEM. NEUTRALIZE WITH SODA ASH. REQUIRES GOOD VENTILATION AS CO2
IS PRODUCED. PLACE NEUTRAL IZED SPILL IN DOT APPROVED DISPOSAL
CONTAINER
Neutralizing Agent:SODA ASH

Handling and Storage Precautions:STORE IN PLASTIC, RUBBER-LINED OR 316
STAINLESS STEEL TANKS DESINED FOR H3PO4. STORE DRUMS AWAY FROM HEAT
AND OUT OF DIRECT SUNLIGHT.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. DO NOT GET IN EYES, ON
SKIN OR ON CLOTHING. AVOID BREATHING MISTS OR VAPORS. WASH
THOROUGHLY AFTER HANDLING.

Respiratory Protection:IF LEVELS EXCEED THE RECOMMENDED HEALTH
STANDARDS, WEAR A NIOSH APPROVED RESPIRATOR FOR ACID. FOR EMERGENCY
USE, WEAR A NIOSH APPROVED POSITIVE-PRESSURE MODE, SELF-CONTAINED
BREATHING APPARATUS (SCBA) .
Ventilation:PROVIDE SUFFICIENT LOCAL EXHAUST VENTILATION TO CONTROL
INHALATION EXPOSURES BELOW OSHA'S PEL.
Protective Gloves:NEOPRENE OR RUBBER
Eye Protection:SAFETY GOGGLES & FACE SHIELD
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health

HCC:C1
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:316F,158C
Vapor Pres:2.2 @ 68F
Spec Gravity:1.69
pH:1.0
Evaporation Rate & Reference:NOT RELEVANT
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS, SYRUPY LIQUID - NO ODOR

Stability Indicator/Materials to Avoid:YES
ALUMINUM, ZINC, IRON, ETC.. (LIBERATES OXYGEN)
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:PHOSPHORUS OXIDES

Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS.
REPORTABLE QUANTITY (RQ) IS 5000 LBS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.