Product ID:SMOKEMASTER FLUID, 1C1-001-786
MSDS Date:02/21/1992
FSC:1365
NIIN:01-367-5695
MSDS Number: BSDCN

SYMTRON SYSTEMS INC

17-01 POLLITT DR
FAIR LAWN, NJ 07410
US

Emergency Phone: 800-424-9300(CHEMTREC)

Info Phone: 201-794-0200; 201-569-6708

Cage: IO571

SYMTRON SYSTEMS INC

FAIR LAWN, NJ 07410 US

Telephone: 201-794-0200

Cage: IO571

ETHYLENE GLYCOL

CAS: 107-21-1

RTECS: KW2975000

Fraction By Weight: <1%

OSHA PEL N/K

ACGIH TLV: N/K

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

ETHYLENE OXIDE (SARA III)

CAS: 75-21-8

RTECS: KX2450000

Fraction By Weight: TRACE

OSHA PEL 1 PPM

ACGIH TLV: 1 PPM

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:EYES:MAY CAUSE SLIGHT TEMPORARY IRRIT.
SKIN: PRLNG EXPOS NOT LIKELY TO CAUSE SIGNIFICANT IRRIT. RPTD EXPOS
MAY CAUSE SLIGHT FLAKING, TENDERNESS & SOFTENING OF SKIN. MAY CAUSE
MORE SEVERE RESPONSE IF S KIN IS ABRADED (SCRATCHED/CUT). FLUID MAY
CAUSE SLIGHT IRRIT AFTER PRLNG CNTCT. (SINGLE PRLNG EXPOS NOT (EFTS
OF OVEREXP
Explanation of Carcinogenicity:ETHYLENE OXIDE:IARC MONOGRAPHS,
SUPPLEMENT, VOL 7, PG 205, 1987:GROUP 2A. NTP 6TH ANNUAL REPORT ON
CARCINOGENS, (SUPDAT)
Effects of Overexposure:HLTH HAZ:LIKELY TO RSLT IN MATL BEING ABSORBED
THRU SKIN IN HARMFUL AMTS.) INGEST:SINGLE DOSE ORAL TOX IS LOW. NO
HAZS ANTIC FROM INGEST INCIDENTAL TO INDUS EXPOS. INHAL:SINGLE
PRLNG (HRS) EXPOS NOT L IKELY TO CAUSE ADVERSE EFTS. MIST NOT
LIKELY TO BE HAZ. VAPS @ ROOM TEMP UNLIKELY DUE TO PHYSICAL
PROPERTIES.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INGEST: CALL MD IMMEDIATELY . INHAL: REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE OXYGEN/ARTIFICIAL RESPIRATION) . EYES:
IRRIGATE IMMEDIATELY WITH WATER FOR AT LEAST 15 MINUTES. IF IRRITAT
ION PERSISTS, CONTACT MD. SKIN: WASH OFF IN FLOWING WATER OR
SHOWER. NOTE TO MD: NO SPECIFIC ANTIDOTE. SUPPORTIVE CARE.
TREATMENT BASED ON JUDGMENT OF THE MD IN RESPONSE TO REACTIONS OF
THE PATIENT.

Flash Point:244F,118C
Extinguishing Media:WATER FOG, ALCOHOL FOAM, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.

Spill Release Procedures:SMALL SPILLS:COVER WITH ABSORBENT MATERIAL,
SOAK UP AND SWEEP INTO A DRUM. LARGE SPILLS: DIKE AROUND SPILL AND
PUMP INTO SUITABLE CONTAINERS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:EXERCISE REASONABLE CARE & CAUTION.
PROD MAY DECOMP @ ELEVATED TEMPS, GENERATING VAPS WHICH COULD BE
IRRIT. FOR USES @ ELEVATED TEMPS, VENT/EXHST REC.
Other Precautions:TRACE QTYS OF ETHYLENE OXIDE (EO) MAY BE PRESENT IN
PROD. WHILE THESE TRACE QTYS ACCUM IN HEADSPACE AREAS OF STOR &
TRANSPORT VESSELS, NOT EXPECTED TO CREATE CNDTN WHICH WILL RSLT IN
EO CONC > 0.5PPM (8 HR TWA) IN BRTHG ZONE OF (SUPDAT)

Respiratory Protection:WHEN AIRBORNE EXPOSURE GUIDELINES &/OR COMFORT
LEVELS MAY BE EXCEEDED, USE A NIOSH/MSHA APPROVED AIR-PURIFYING
RESPIRATOR. ORGANIC VAPOR RESPIRATORS WITH PARTICULATE FILTERS CAN
BE USED TO DECREASE EX POSURE.
Ventilation:GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT FOR MOST
CONDITIONS.
Protective Gloves:IMPERVIOUS GLOVES.
Eye Protection:CHEMICAL SAFETY GOGGLES.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
CNDTNS TO AVOID:OCCURS RAPIDLY AT TEMP APPROACHING THE FLASH POINT.
EXPLAN OF CARCIN:1991:ANTIC TO BE CARCIN. OSHA REGULATED . OTHER
PREC:WORKPLACE FOR APPROP APPLICATNS, OSHA HAS ESTABLISHED A
PERMISSIBLE EXPOS LIMIT OF 1.0 PPM 8 HRTWA FOR EO (CFR PART
1910.1047 OF TITLE 29).

HCC:N1
Boiling Pt:B.P. Text:379F,193C
Vapor Pres:14.33 @20C
Spec Gravity:APPROX 1.0446
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS/VISCOUS LIQUID; LOW ODOR.

Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS.
Stability Condition to Avoid:STABLE UNDER NORM STOR CNDTNS. PROD
DEGRADES WHEN STORED @ ELEVATED TEMP IN PRESENCE OF AIR.
DEGRADATION (SUPDAT)
Hazardous Decomposition Products:PROPLONALDEHYDE, CARBON MONOXIDE IN
PRESENCE OF LIMITED OXYGEN IN A FIRE SITUATION.

Waste Disposal Methods:REPROCESS OR BURN IN AN APPROVED INCINERATOR IN
ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REQUIREMENTS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.