Product ID:G-3/6 LOW S CARBON RAISER, 9287
MSDS Date:01/01/1992
FSC:9620
NIIN:00N044759
MSDS Number: BSDHN

Emergency Phone: 814-834-2801

Info Phone: 814-834-2801

Cage: 78429

Telephone: 814-834-2801

Cage: 78429

GRAPHITE; (SYNETHETIC GRAPHITE)

CAS: 7782-42-5

RTECS: MD9659600

Fraction By Weight: >99%

OSHA PEL 10 MG/M3;5 RESP

ACGIH TLV: 2 MG/M3

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: AT HIGH DUST LEVEL,
MECHANICAL IRRITATION. INHAL: PROLONGD AND REPEATED OVER-EXPOSURE
MAY LEAD TO BENIGN PNEUMOCONIOSIS. INGEST/SKIN: NONE.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:INDIVIDUALS W/PRE-EXISTING CHRONIC
RESPIRATORY IMPAIRMENTS OR WITH SERUM ANTITRYPSIN DEFICIENCY MAY BE
@ INCREASED OF PNEUMOCONIOSIS.

First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. SKIN: FLUSH
WITH COPIOUS AMOUNTS OF WATER. CALL MD . INHAL: REMOVE TO FRESH
AIR. SUPPORT BRTHG (GIVE O*2/ARTF RESP) . INGEST: CALL MD IMMED .

Flash Point:NONE
Lower Limits:NONE
Upper Limits:NONE
Extinguishing Media:WATER, CARBON DIOXIDE, SAND.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
Unusual Fire/Explosion Hazard:GRAPHITE DUST IS NORMALLY NOT EXPLOS, BUT
IT MAY WEAKLY CONTRIBUTE IF EVENT IS INITIATED BY ANOTHER EXPLOS
DUST/GAS. GRAPHITE IS ELEC CONDUCTIVE; (SUPP DATA)

Spill Release Procedures:USE NORMAL HOUSEKEEPING PRACTICE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:NONE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

Respiratory Protection:USE NIOSH/MSHA APPROVED DUST RESPIRATOR IF
EXPOSURE EXCEEDS PEL LIMITS.
Ventilation:LOCAL VENTILATION RECOMMENDED IF DUST LEVEL EXCEEDS PEL
LIMIT.
Protective Gloves:NONE REQUIRED.
Eye Protection:ANSI APPRVD SFTY GLASSES (SUPDAT)
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
% VOLAT: <0.01(WT). SPEC GRAV: REAL DENSITY: 2.1 G/CC. BULK DENSITY: 50
LBS/FT3. VP: NEGLIGIBLE @ ROOM TEMP. VD: NEGLIGIBLE @ ROOM TEMP.
EXPLO HAZ: DUST ACCUMULATIONS MAY CAUSE ELEC SHORT CIRCUITS/OTH ER
ELECTRICAL MALFUNCTIONS. EYE PROT: IF AIRBORNE PARTICLES PRODUCED.

HCC:N1
Boiling Pt:B.P. Text:NONE
Melt/Freeze Pt:M.P/F.P Text:NONE
Vapor Pres:SUPP DATA
Vapor Density:SUPP DATA
Spec Gravity:SUPP DATA
Evaporation Rate & Reference:0
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK, GRANULAR, NO ODOR
Percent Volatiles by Volume:SUPDAT

Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:IN NORMAL COMBUSTION, CARBON DIOXIDE
AND CARBON MONOXIDE.

Waste Disposal Methods:BURY IN AN APPROVED LANDFILL. DISPOSAL MUST BE
IN COMPLIANCE WITH FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.