Product ID:PRIMER FOR 72-00151
MSDS Date:07/01/1992
FSC:8030
NIIN:00N044903
MSDS Number: BSDJG

TECHNICAL WIRE PRODUCTS INC

129 DERMODY ST
CRANFORD, NJ 07016
US

Emergency Phone: 908-272-5500

Info Phone: 908-272-5500

Cage: 53217

TECHNICAL WIRE PRODUCTS INC, DBA. TECKNIT

CRANFORD, NJ 07016 US

Telephone: 908-272-5500

Cage: 07700

SOLVENT NAPHTHA (PETROLEUM), LIGHT ALIPHATIC; (NAPTHA,

CAS: 64742-89-8

Fraction By Weight: 65%

OSHA PEL N/K

ACGIH TLV: N/K

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 19%

OSHA PEL 100 PPM;150 PPM STEL

ACGIH TLV: 50 PPM, S

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

METHYL CELLOSOLVE ORTHOSILICATE; (TETRA(2-METHOXYETHOXY)

CAS: 2157-45-1

Fraction By Weight: 4%

OSHA PEL 25 PPM, S

ACGIH TLV: 5 PPM, S

TETRAPROPYL ORTHOSILICATE. PEL/TLV AS N-PROPYL ALCOHOL.

CAS: 682-01-9

Fraction By Weight: 4%

OSHA PEL 200 PPM;250 PPM STEL

ACGIH TLV: 200 PPM;250 PPM STEL

TITANIC ACID, TETRABUTYL ESTER; (TETRABUTYL TITANATE).

CAS: 5593-70-4

RTECS: XR1585000

Fraction By Weight: 4%

OSHA PEL 50 PPM, C, S

ACGIH TLV: 50 PPM, C, S

BUTYL ALCOHOL; (N-BUTYL ALCOHOL) (SARA III)

CAS: 71-36-3

RTECS: EO1400000

Fraction By Weight: 2%

OSHA PEL 50 PPM, S, C

ACGIH TLV: 50 PPM, S, C

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

VOLATILE ORGANIC COMPOUNDS

RTECS: 9999999VO

Fraction By Weight: 760% G/L

OSHA PEL N/K

ACGIH TLV: N/K

CONSULTATION FROM APPROP HLTH PROFESSIONALS

RTECS: 9999999ZZ

THORO FLUSH AFFECTED AREAS W/WATER. GOOD

RTECS: 9999999ZZ

SKIN AS SOON AS PRACTICAL ESPECIALLY BEFORE EATING OR

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:2-METHOXYETHANOL (METHYLCELLOSOLVE)
MAY FORM UPON HYDROLYSIS. ANIMAL REPRO STUDIES HAVE SHOWN
2-METHOXYETHANOL IS ABLE TO CAUSE ANIMAL BIRTH DEFECTS. EYES:DIRECT
CONT IRRITS. MAY BE SERIOUS W/REDNESS, SWELL & CORNEAL INJURY
LASTING SEVERALDAYS TO A WK. SKIN:SINGLE RELATIVELY SHORT EXPOS
CAUSES NO (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:KNOWN ADVERSE EFTS. RPTD PRLNG CONT
(24-48 HRS) MAY IRRIT MODERATELY. OVEREXP MAY INJURE INTERNALLY IF
ABSORBED. INHAL:SHORT VAP EXPOS MAY CAUSE DROW & IRRIT NOSE &
THROAT. VAPS MAY INJURE BL OOD, LUNGS, LIVER, KIDNEYS & NERV SYS.
DEGREE OF EFT DEPENDS ON CONC & LGTH OF EXPOS. INGEST:SM AMTS
TRANSFERRED(SUPDAT)
Medical Cond Aggravated by Exposure:MAY AGGRAVATE EXISTING EYE, SKIN &
RESPIRATORY DISORDERS.

First Aid:EYES:IMMED FLUSH W/WATER FOR AT LST 15 MINS. GET MED ATTN.
SKIN:IMMED WIPE OFF & FLUSH W/WATER FOR 15 MINS. GET MED ATTN IF
ILL EFFECTS DEVELOP. INHAL:REMOVE TO FRESH AIR. GET MED ATTN IF ILL
EFFECTS PERSIST. INGEST:GET MED ATTN, DO NOT INDUCE VOMIT.
INHALING LIQUID WHILE VOMITING CAN INJURE LUNGS SERIOUSLY. IF VOMIT
OCCURS KEEP HEAD LOWER THAN HIPS TO PREVENT ASPIRATION OF LIQUID
INTO LUNGS.

Flash Point Method:CC
Flash Point:59.0F,15.0C
Extinguishing Media:WATER, WATER FOG, CO*2, DRY CHEMICAL, FOAM, OTHER.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:VAPS ARE HVR/AIR & CAN TRAVEL ALONG
GROUND TO REMOTE IGNIT SOURCES. STATIC ELEC MAY ACCUM & IGNITE
VAPS. PVNT POSS FIRE HAZ BY SUITABLE MEANS, SUCH AS, (SUPDAT)

Spill Release Procedures:USE ABSORBENT MATERIAL TO COLLECT & CONTAIN
FOR SALVAGE OR DISPOSAL. REMOVE ALL SOURCES OF IGNITION & WEAR
PROPER PROTECTIVE EQUIPMENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP CONTAINER CLOSED & AWAY FROM
HEAT, SPARKS & OPEN FLAMES. DO NOT EXPOSE TO MOISTURE OR HUMID AIR
UNTIL READY TO USE.
Other Precautions:ALL OF PRECS LISTED ARE FOR ROOM TEMP HNDLG. USE AT
ELEVATED TEMPS, OR AEROSOL/SPRAY APPLICATIONS MAY REQ ADDED PRECS.
AVOID EYE/SKIN CONTACT. DO NOT BREATHE VAPORS. USE ONLY W/ADEQ
VENT. DO NOT TAKE INTERNALLY.

Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATORY PROTECTION
UNLESS LOCAL EXHAUST VENTILATION IS ADEQUATE OR AIR SAMPLING DATA
SHOW EXPOSURES ARE W/IN TLV & PEL GUIDELINES. USE NIOSH/MSHA
APPROVED ORGANIC VAPOR TYP E RESPIRATOR.
Ventilation:LOCAL EXHAUST &/OR MECHANICAL (GENERAL) VENTILATION
RECOMMENDED.
Protective Gloves:RUBBER OR PLASTIC GLOVES.
Eye Protection:ANSI APRV CHEM WORK GOGG
Other Protective Equipment:PROTECTIVE CLOTHING TO PREVENT SKIN CONTACT
WOULD BE ADVISABLE.
Work Hygienic Practices:WASHING AT MEAL TIMES & END OF SHIFT IS ADEQ.
HOWEVER, IF SPLASH OCCURS, CHANGE CONTAM CLTHG AS SOON AS POSS &
(ING 9)
Supplemental Safety and Health
EXPLO HAZ:BONDING, GROUNDING, INERT GAS PURGE, VAP DILUTION & THE LIKE.
EFTS OF OVEREXP:TO MOUTH BY FINGERS DURING USE ETC, SHOULD NOT
INJURE. SWALLOWING LG AMTS MAY INJURE SERIOUSLY. INHALING LIQ WHI
LE VOMIT CAN INJURE LUNGS SERIOUSLY. NOTE:TOLUENE APPEARS ON NAVY
LISTING OF OCCUP CHEM REPRO HAZS. SEEK (ING 8)

HCC:F3
Vapor Pres:25
Vapor Density:3.8
Spec Gravity:0.8
Appearance and Odor:SOLVENT ODOR, LIQUID, LIGHT STRAW COLOR.
Percent Volatiles by Volume:95(WT)

Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS CAN CAUSE REACTION. MATERIAL WILL SLOWLY HYDROLYZE
IN PRESENCE OF MOISTURE OR HUMID AIR.
Stability Condition to Avoid:DO NOT EXPOSE MATERIAL TO MOISTURE OR
HUMID AIR UNTIL READY TO USE.
Hazardous Decomposition Products:TITANIUM DIOXIDE, SILICONE DIOXIDE,
CARBON DIOXIDE & TRACES OF INCOMPLETELY BURNED CARBON PRODUCTS.

Waste Disposal Methods:DISPOSE I/A/W LOCAL, STATE & FEDERAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.