Product ID:TT-E-527D NTP FLAT ALKYD, F-069P1001
MSDS Date:03/19/1992
FSC:8010
NIIN:00N045180
MSDS Number: BSDMY

SEAGRAVE COATINGS CORP

4030 SEAGUARD AVE
PORTSMOUTH, VA 23701
US

Emergency Phone: 800-424-9300(CHEMTREC)

Info Phone: 804-488-4411

Cage: 60163

SHERWIN-WILLIAMS, SEAGUARD

PORTSMOUTH, VA 23704 US

Telephone: 757-397-2223

Cage: 60163

TALC (POWDER), CONTAINING NO ASBESTOS FIBERS

CAS: 14807-96-6

RTECS: MW2710000

Fraction By Weight: <30%

OSHA PEL 2 MG/M3

ACGIH TLV: 2 MG/M3 RDUST

SILICA, CRYSTALLINE-QUARTZ; (SILICA-CRYSTALLINE)

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: <25%

OSHA PEL 0.1 MG/M3

ACGIH TLV: 0.1 MG/M3

STODDARD SOLVENT; (MINERAL SPIRITS (PETROLEUM SOLVENT)).

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: <15%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

NAPHTHA PETROLEUM, HEAVY ALKYLATE C9-C12; (ODORLESS MINERAL

CAS: 64741-65-7

Fraction By Weight: <1%

OSHA PEL N/K

ACGIH TLV: N/K

SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (AROMATIC

CAS: 64742-95-6

RTECS: WF3400000

Fraction By Weight: <5%

OSHA PEL N/K

ACGIH TLV: N/K

ACETIC ACID, 2-METHOXY-1-METHYLETHYL ESTER;

CAS: 108-65-6

RTECS: AI8925000

Fraction By Weight: <5%

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: IRRITATION TO
RESPIRATORY TRACT, HEADACHE, DIZZINESS AND NAUSEA. SKIN: PRIMARY
IRRITATION. EYE:PRIMARY IRRITATION.
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ: IARC
MONOGRAPHS, SUPPLEMENT. VOL 7, 341, 1987: GRP 2A. NTP 6TH ANNUAL
REPORT ON (SUPP DATA)
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PREEXISTING SENSITIVITY TO SOLVENTS
CAN CAUSE A HEIGHTENED REACTION TO EXPOSURE TO THIS PRODUCT.

First Aid:INHAL: REMOVE TO FRESH AIR, RESTORE BREATHING. CONSULT A
PHYSICIAN. SKIN:FLUSH W/WATER. EYE: FLUSH IMMED WITH LARGE AMOUNTS
OF WATER FOR AT LEAST 15 MINUTES. CONSULT A PHYSICIAN. INGEST: CALL
MD IMMED .

Flash Point:100F,38C
Lower Limits:0.5%
Upper Limits:13.1%
Extinguishing Media:FOAM, WATER FOG, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
WATER MAY BE USED TO COOL CLSD CONTRS TO PREVENT PRESS BUILD-UP &
POSS AUTOIGNIT WHEN EXPOSED TO EXTREME HEAT.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, SPARKS, AND OPEN FLAMES. CLOSED CONTAINERS MAY EXPLODE
WHEN EXPOSED TO EXTREME HEAT.

Spill Release Procedures:AVOID BREATHING SOLVENT VAPOR. ENSURE ADEQUATE
VENTILATION. AVOID SPARKS, FLAMES, AND ANYTHING WHICH COULD CAUSE
FIRE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN A COOL DRY AREA WITH
VENTILATION SUITABLE FOR STORING MATERIALS.
Other Precautions:PROVIDE RESPIRATORY PROTECTION AGAINST FUMES
GENERATED DURING BURNING.

Respiratory Protection:NIOSH/MSHA APPROVED RESP TYPE SUITABLE FOR
MATLS. NIOSH/MSHA APPRVD CHEM/MECH FILTERS RECOM WHEN VENT IS
RESTRICTED. NIOSH/MSHA APPRVD AIRLINE TYPE RESP/HOODS RECOMMENDED
IN CONFINED AREAS.
Ventilation:SUFFICIENT VENT, IN VOL & PATTERN, SHOULD BE PROVIDED TO
KEEP AIR CONTAM BELOW CURRENT APPLIC OSHA (SUPP DATA)
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:CHEM GOGG W/SIDESHIELDS/FACESHIELDS.
Other Protective Equipment:USE PROTECTIVE CREAMS WHERE SKIN CONTACT IS
LIKELY, REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR SMOKING. SMOKE IN
DESIGNATED AREAS ONLY.
Supplemental Safety and Health
EXPLAN OF CARCIN: CARCINS, 1991: ANTIC TO BE CARCIN. VENT: PERMISSIBLE
EXPOSURE LIMIT OR ACGHI'S TLV LIMIT.

HCC:F4
Boiling Pt:B.P. Text:>302F,>150C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:1.4
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:TRANSLUCENT, PETROLEUM ODOR
Percent Volatiles by Volume:43.5

Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:OXIDIZING MATERIALS CAN CAUSE A VIGOROUS
REACTION.
Hazardous Decomposition Products:AS W/ANY OTHER ORGANIC MATERIAL,
COMBUSTION WILL PRODUCE CARABON DIOXIDE AND PROBABLY CARBON
MONOXIDE.

Waste Disposal Methods:SOAK LIQUIDS WITH SAWDUST OR RAGS AND REMOVE.
FLUSH W/WATER IF POSSIBLE. AVOID SKIN CONTACT. DISPOSAL SHOULD BE
I/A/W LOCAL, STATE, AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.