Product ID:SPLICE WASH SW-100
MSDS Date:03/15/1991
FSC:6810
NIIN:00N045201
MSDS Number: BSDNL

FIRESTONE BUILDING PRODUCTS

525 CONGRESSIONAL BLVD
CARMEL, IN 46032
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 216-379-6409

Cage: FIRES

FIRESTONE BUILDING PRODUCTS CO

CARMEL, IN 46032-5000 US

Telephone: 615-231-3911

Cage: FIRES

VM&P NAPTHA; (SOLVENT, NAPHTHA (LIGHT ALIPHATIC SOLVENT))

CAS: 64742-89-8

Fraction By Weight: 100%

OSHA PEL N/K

ACGIH TLV: N/K

BENZENE (SARA III)

CAS: 71-43-2

RTECS: CY1400000

Fraction By Weight: 0.01%

OSHA PEL 1 PPM; 5 STEL

ACGIH TLV: 10 PPM

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

LD50 LC50 Mixture:ING 1: LD50 (ORAL, RAT): > 5 G/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: EYES:PROLONGED OR REPEATED
CONTACT MAY CAUSE SKIN IRRITATION, DERMATITIS. ABSORPTION THROUGH
INTACT SKIN MAY CONTRIBUTE TO OVERALL EXPOSURE. MAY REMOVE NATURAL
SKIN OILS (DEFATTING ACTION). INH ALATION:MAY CAUSE CNS DEPRESSION
(NARCOSIS) CHARACTERIZED BY HEADACHE, DIZZINESS, MUSCULAR WEAKNESS
& (EFTS OF OVEREXP)
Explanation of Carcinogenicity:BENZENE:IARC MONOGRAPHS, SUPPLEMENT, VOL
7, PG 120, 1987:GROUP 1. NTP 6TH ANNUAL REPORT ON CARCIN,
1991:KNOWN (SUPDAT)
Effects of Overexposure:HLTH HAZ:FATIGUE. MAY CAUSE UNCONSCIOUSNESS IF
EXPOS IS EXCESSIVE. INGESTION:CAUSES CHEMICAL PNEUMONITIS IF
ASPIRATED INTO LUNGS. MAY CAUSE UNCONSCIOUSNESS. CHRONIC: MAY CAUSE
LIVER AND KIDNEY DAMAGE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYES:HOLD EYELIDS OPEN & FLUSH IMMED W/GENTLE STREAM OF WATER
FOR @ LEAST 15 MIN, PREF @ EYEWASH FOUNTAIN. GET MED ATTN IF IRRIT
PERSISTS. SKIN:WASH AFFECTED AREA THORO W/SOAP & WATER WHEN TIME
PERMIT S. INHAL:REMOVE TO FRESH UNCONTAMD AIR.ADMIN OXYGEN IF BRTHG
LABORED. GIVE ARTF RESP IF BRTHG STOPPED. GET MED ATTN IMMED IF
OXYGEN/ARTF RESP ARE ADMIN. INGEST:CONTAINS PETRO DISTIL. IN CASE
(SUPDAT)

Flash Point:22.0F,-5.6C
Lower Limits:1.0%
Upper Limits:7.0%
Extinguishing Media:ALCOHOL FOAM, CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . COOL WITH WATER STREAM. TOXIC FUMES AND
VAPORS MAY BE EVOLVED.
Unusual Fire/Explosion Hazard:HEAT BUILDS UP PRESSURE IN CLOSED
CONTAINERS. HAZARDOUS COMBUSTION PRODUCTS:CARBON DIOXIDE & CARBON
MONOXIDE, ALDEHYDES, PARTIALLY BURNED CARBON.

Spill Release Procedures:ELIM ALL IGNIT SOURCES. CONTROL SOURCE OF
SPILL IF SAFE TO DO SO. VENT ENCLSD AREA TO PVNT VAP ACCUM.
RESTRICT ACCESS BY UNAUTH PERS. ABSORB SPILLED PROD
W/VERMICULITE/OTHER ABSORB MATL. SHOVEL/SCOOP INTO SEALABLE CNTNR
FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & OPEN
FLAMES. KEEP CONTAINERS CLOSED. STORE AT ROOM TEMPERATURE WITH GOOD
VENTILATION.
Other Precautions:VAPORS OF THIS MATL ARE HEAVIER THAN AIR & WILL
COLLECT IN LOW/CONFINED AREAS. GROUND DISPENSING EQUIPMENT TO AVOID
STATIC DISCHARGE. EMPTIED CNTNRS MAY RETAIN HAZARDOUS PROPERTIES.
DO NOT CUT OR WELD ON OR NEAR CONTAINER.

Respiratory Protection:USE NIOSH/MSHA APPROVED CHEMICAL CARTRIDGE
RESPIRATOR FOR ORGANIC VAPORS IF EXPOSURE MIGHT EXCEED THE TLV.
Ventilation:USE IN A WELL-VENTILATED LOCATION.
Protective Gloves:BUTYL GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:WASH HANDS & FACE THROROUGHLY WITH SOAP & WATER
BEFORE EATING, DRINKING OR SMOKING.
Supplemental Safety and Health
EXPLAN OF CARCIN:TO BE CARCIN. FEDERAL REGISTER, VOL 52, PG 34460,
1987:OSHA-CANCER HAZARD. FIRST AID PROC:OF ACCIDENTAL INGESTION, DO
NOT INDUCE VOMITING. GET MED ATTN & ADVISE MD OF THE NATURE OF TH E
MATERIAL.

HCC:F3
Boiling Pt:B.P. Text:185F,85C
Vapor Pres:38 @ 68F
Vapor Density:3.6
Spec Gravity:0.71 (H*2O=1)
Evaporation Rate & Reference:3.9 (BUTYL ACETATE =1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR LIQUID, GASOLINE ODOR.
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS AND OPEN FLAMES.
Hazardous Decomposition Products:NONE

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL ENVIRONMENTAL AND WASTE REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.