Product ID:WATER-BLOCK SEAL S-20
MSDS Date:03/15/1991
FSC:8030
NIIN:00N045205
MSDS Number: BSDNQ

FIRESTONE BUILDING PRODUCTS

525 CONGRESSIONAL BLVD
CARMEL, IN 46032
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 216-379-6409

Cage: FIRES

FIRESTONE BUILDING PRODUCTS CO

CARMEL, IN 46032-5000 US

Telephone: 615-231-3911

Cage: FIRES

HEPTANE; (N-HEPTANE)

CAS: 142-82-5

RTECS: MI7700000

Fraction By Weight: 14%

OSHA PEL 400 PPM; 500 STEL

ACGIH TLV: 400 PPM; 500 STEL

CALCIUM CARBONATE

CAS: 1317-65-3

RTECS: EV9580000

Fraction By Weight: 32%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

KAOLIN

CAS: 1332-58-7

RTECS: GF1670500

Fraction By Weight: 22%

OSHA PEL 10 MG/M3 TDUST

ACGIH TLV: 2 MG/M3 TDUST

BENZENE (SARA III)

CAS: 71-43-2

RTECS: CY1400000

Fraction By Weight: <0.1%

OSHA PEL 1 PPM; 5 STEL

ACGIH TLV: 10 PPM

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: EYES:MAY CAUSE MODERATE
IRRITATION. SKIN:PROLONGED OR REPEATED CONTACT MAY CAUSE
DERMATITIS. ABSORPTION THROUGH INTACT SKIN MAY CONTRIBUTE TO
OVERALL EXPOSURE. MAY CAUSE DRYING. INHALATION:MAY CAUSE CENTRAL
NERVOUS SYSTEM DEPRESSION (NARCOSIS) CHARACTERIZED BY HEADACHE,
DIZZINESS, MUSCULAR (EFTS OF OVEREXP)
Explanation of Carcinogenicity:BENZENE:IARC MONOGRAPHS, SUPPLEMENT, VOL
7, PG 120, 1987:GROUP 1. NTP 6TH ANNUAL REPORT ON CARCINOGENS,
1991: (SUPDAT)
Effects of Overexposure:HLTH HAZ:WEAKNESS AND FATIGUE. MAY CAUSE
UNCONSCIOUSNESS IF EXPOSURE IS EXCESSIVE. INGESTION:CAUSES CHEMICAL
PNEUMONITIS IF ASPIRATED INTO LUNGS. MAY CAUSE CENTRAL NERVOUS
SYSTEM DEPRESSION (NARCOSIS) CHARACTERIZED BY HEADACHE, DIZZINESS,
MUSCULAR WEAKNESS & FATIGUE. CHRONIC: MAY CAUSE NEUROMUSCULAR
DAMAGE.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYES:HOLD EYELIDS OPEN & WASH W/GENTLE STREAM OF WATER FOR @
LEAST 15 MIN & UNTIL FOREIGN MATL REMOVED. GET MED ATTN IF IRRIT
PERSISTS. SKIN:REMOVE IMMED BY WASHING W/SOAP & WATER. REMOVE FROM
AFFECTE D AREA USING WATERLESS SKIN CLEANER. INHAL:MOVE TO FRESH
UNCONTAMD AIR. ADMIN OXYGEN IF BRTHG LABORED. GIVE ARTF RESP IF
BRTHG STOPPED. GET MED ATTN IMMED IF OXYGEN/ARTF RESP ARE ADMIN.
(SUPDAT)

Flash Point Method:TCC
Flash Point:14F,-10C
Lower Limits:1.0%
Upper Limits:7.0%
Extinguishing Media:WATER SPRAY, FOAM, CARBON DIOXIDE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . TOXIC FUMES MAY BE EVOLVED.
Unusual Fire/Explosion Hazard:HEAT BUILDS UP PRESSURE IN CLOSED
CONTAINERS. COOL WITH WATER STREAM. HAZARDOUS COMBUSTION
PRODUCTS:CARBON DIOXIDE & CARBON MONOXIDE, OXIDES OF NITROGEN.

Spill Release Procedures:REMOVE IGNITION SOURCES. SCRAPE UP WITH
NON-SPARKING TOOLS. PLACE IN SECURE CONTAINERS FOR PROPER DISPOSAL.
USE PERSONAL PROTECTIVE EQUIPMENT FOR ALL SPILLS/LEAKS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & OPEN
FLAMES. STORE IN COOL, DRY AREA. VAPORS OF THIS MATL ARE HEAVIER
THAN AIR & WILL COLLECT IN LOW OR CONFINED AREAS.
Other Precautions:FLAMMABLE. INHALATION OF VAPORS MAY CAUSE HEADACHES
AND DIZZINESS.

Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR FOR
PROTECTION AGAINST ORGANIC VAPORS, DUSTS AND MISTS IF EXPOSURE
MIGHT EXCEED THE TLV.
Ventilation:USE IN A WELL-VENTILATED LOCATION.
Protective Gloves:BUTYL GLOVES FOR DIRECT HANDLING.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:NONE REQUIRED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLAN OF CARCIN:KNOWN TO BE CARCINOGENIC. FEDERAL REGISTER, VOL 52, PG
34460, 1987:OSHA-CANCER HAZARD. FIRST AID PROC:INGEST:CONTAINS
PETROLEUM DISTILLATES. IN CASE OF ACCIDENTAL INGEST, DO NOT INDUC E
VOMIT. GET MED ATTN & ADVISE MD OF NATURE OF MATL.

HCC:F8
Boiling Pt:B.P. Text:200F,93C
Vapor Pres:45 @ 20C
Vapor Density:3.4
Spec Gravity:1.33 (H*2O=1)
Evaporation Rate & Reference:4.5 (BUTYL ACETATE =1)
Solubility in Water:< 0.1%
Appearance and Odor:GRAY PASTE WITH MILD ALIPHATIC ODOR.
Percent Volatiles by Volume:26

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS AND OPEN FLAMES.
Hazardous Decomposition Products:NONE

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.