Product ID:FORMULA 84 H2-017
MSDS Date:05/01/1993
FSC:8010
NIIN:01-285-1328
MSDS Number: BXCHM

CRAWFORD LABORATORIES, INC.

4165 SOUTH EMERALD AVENUE
CHICAGO, IL 60609
US

Emergency Phone: 800-424-9300 CHEMTREC

Info Phone: 312-376-7132

Preparer: DAVID SCHMETTERER

Cage: DO165

CRAWFORD LABORATORIES, INC

CHICAGO, IL 60609 US

Telephone: 312-376-7132

Cage: 5V430

MINERAL SPIRITS/66 (VAPOR PRESSURE 3.4 MM HG)

CAS: 8032-32-4

RTECS: OI6180000

Fraction By Weight: 10%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM

ZINC MOLYBDATE

CAS: 22914-58-5

Fraction By Weight: 5.9%

OSHA PEL 10 MG/M3

ACGIH TLV: 10 MG/M3

ZINC OXIDE (SARA 313) (CERCLA)

CAS: 1314-13-2

RTECS: ZH4810000

Fraction By Weight: 15%

ACGIH TLV: 10 MG/M3

100 SOLVENT (VAPOR PRESSURE 9 MM HG)

CAS: 64742-95-6

Fraction By Weight: 11%

OSHA PEL 50 PPM

ACGIH TLV: 50 PPM

<340 GPL

RTECS: 9999999VO

Health Hazards Acute and Chronic:ACUTE TOXICITY, ERSULT IN HEADACHE,
DIZZINESS, NAUSEA, & LOSS OF CONSCIOUSNESS. SEVERE EYE IRRITATION
POSSIBLY RESULTING IN PERMANENT DAMAGE. IRRITATED MUCOUS MEMBRANES.
VOMITING DUE TO INGESTION. DEF ATTING & DRYING OF SKIN, WHICH MAY
RESULT IN IRRITATION & DERMATITIS. SENSITIZATION AFTER REPEATED
CONTACT.

First Aid:NEVER GIVE UNCONSIOUS LIQUID. EYE:FLUSH W/WATER 15 MIN
HOLDING EYELIDS OPEN.GET MED AID. INHAL:REMOVE TO FRESH AIR.GIVE
OXYGEN IF BREATHING DIFFICULT.GIVE ARTIF RESP IF NOT BREATHING.GET
MED AID.KEEP WARM & COMFORTABLE. INGEST:CALL DR IMMED.ONLY INDUCE
VOMIT ON DR'S INSTRUCTIONS.IF VOMITING OCCURS SPONTANEOUSLY,KEEP
HEAD BELOW HIPS TO PREVENT ASPIRATION. SKIN:FLUSH W/H2O WHILE
REMOVING CONTAM **

Flash Point:110F,43C
Lower Limits:0.9
Extinguishing Media:FOAM, CO2, OR DRY CHEMICAL
Fire Fighting Procedures:WATER MAY BE USED TO COOL EXPOSED CONTAINER, &
TO KEEP FLAMMABLE STRUCTURES WET. DON'T ENTER FIRE AREA WITHOUT
PROTECTION BECAUSE DECOMP PRODUCT MAY BE PRESENT.
Unusual Fire/Explosion Hazard:WATER PRESSURE MAY SPREAD A FLAMMABLE
LIQUID FIRE. SEALED CONTAINERS MAY EXPLODE IF OVERHEATED.

Spill Release Procedures:WARNING - FLAMMABLE. ELIMINATE ALL IGNITIOIN
SOURCES. HANDLING EQUIPMENT MUST BE GROUNDED TO PREVENT SPARKING.
SOAK UP WITH AN ABSORBENT AND PLACE IN NON-LEAKING CONTAINERS. SEAL
TIGHTLY FOR PROPER DI SPOSAL.
Neutralizing Agent:N/K ** CLOTHES & SHOES. FOLLOW BY WASHING W/SOAP &
H2O. DON'T REUSE CLOTHES ***

Handling and Storage Precautions:COMBUSTBL.STORE IN COOL,DRY PLACE IN
BLDG FOR COMBUST STORAGE.WARNING:HOT ORGANIC CHEM VAPOR/MIST
SUSCEPTIBLE TO SPONTANEOUS COMBUSTN WHEN MIXED W/AIR
Other Precautions:IGNIT MAY OCCUR AT TEMP BELOW AUTOIGNIT/IGNIT
TEMPS.IGNIT TEMPS DECREASE W/INCREASING VAPOR VOLUME & VAPOR/AIR
CONTACT TIME & INFLUENCED BY PRESSR CHANGE.IGNIT MAY OCCUR AT
ELEVATED TEMP,ESPECIALLY IN VACUUM IF SUDDEN INGRESS AIR OR #

Respiratory Protection:USE NIOSH APPROVED ORGANIC VAPOR RESPIRATORS
WHERE VENTILATION IS INADEQUATE.
Ventilation:MUST PROVIDE ADEQUATE VENTILATION.
Protective Gloves:USE RUBBER GLOVES.
Eye Protection:WEAR APPROVED SAFETY GOGGLES
Other Protective Equipment:HAVE EYE BATH AND SAFETY SHOWER AVAILABLE.
Supplemental Safety and Health
# OTHER PRECAUTIONS CONT'D: OUTSIDE PROCESS EQUIPMENT OPERATING UNDER
ELEVATED PRESSURE IF SUDDEN ESCAPE OF VAPOR OR MIST TO THE
ATMOSPHERE OCCURS. ANY PROPOSED USE SHOULD BE THOROUGHLY EVALUATED
TO A SSURE THAT SAFE OPERATING CONDITIONS ARE ESTABLISHED AND
MAINTAINED.

Boiling Pt:B.P. Text:308 TO 396F
Vapor Density:> AIR
Spec Gravity:1.56
Viscosity:90 KU
Evaporation Rate & Reference:0.13 X N-BUTYL ACETATE
Solubility in Water:SLIGHT
Appearance and Odor:YELLOW LIQUID / SOLVENT ODOR
Percent Volatiles by Volume:40.5
Corrosion Rate:NOT CORR

Stability Indicator/Materials to Avoid:YES
MAY BE INCOMPATIBLE WITH OXIDIZING AGENTS AND STRONG ALKALIES.
Stability Condition to Avoid:AVOID HEAT, SPARKS, OPEN FLAMES, &
INCOMPATIBILITIES. ALSO AIRCRAFT TRANSPORT MUST BE IN STRICK
ACCORDANCE W/REGULATIONS
Hazardous Decomposition Products:INCOMPLETE COMBUSTION FOR PRODUCTS
LIKE THIS MAY GENERATE HIGHLY POISONOUS CARBON MONOXIDE AND OTHER
TOXIC GASES.

Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH CURRENT
LOCAL, STATE, AND FEDERAL REGULATIONS. CONTACT AN APPROVED DISPOSAL
FACILITY. EPA HAZARDOUS WASTE CODE: D001, IGNITABLE.
*** OR SHOES UNTIL C LEANED. IF IRRITATION PERSISTS, GET MEDICAL
AID.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.