Product ID:TR-68C, CYAN TONER REPLENISHER, 20272-0025
MSDS Date:03/25/1994
FSC:6850
NIIN:01-388-5062
MSDS Number: BXDQM

CALCOMP

2411 WEST LA PALMA AVE
ANAHEIM, CA 92803
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 714-821-2556

Cage: IO122

CALIFORNIA COMPUTER PRODUCTS SUB OF SANDERS ASSOC

3250 ANAHEIM, CA 92803 US

Telephone: 714-821-2290

Cage: 14668

MINERAL SPIRITS;(ISOPAR G)

CAS: 64475-85-0

RTECS: PY8240000

Fraction By Weight: 84-92%

OSHA PEL N/K

ACGIH TLV: N/K

DISCOMFORT WHEN EXPOSED TO CONCS BELOW THE

RTECS: 9999999ZZ

SPACES. CLEAN-UP ABSORB MATL & DISPOSE OF

RTECS: 9999999ZZ

VAPS FROM ABSORBED MATL. PVNT LIQUID FROM ENTERING

RTECS: 9999999ZZ

W/SORBANT MATL. DO NOT USE COMBUST MATL SUCH AS

RTECS: 9999999ZZ

EXPLOSION PROOF PUMP) OR WITH SUITABLE ABSORBANT.

RTECS: 9999999ZZ

ENSURE CONFORMITY TO LOCAL & FEDERAL DISPOSAL

RTECS: 9999999ZZ

OR WITH SUITABLE ABSORBS. CONSULT AN EXPERT ON DISP

RTECS: 9999999ZZ

REPORT THE SPILL TO THE PROPER FEDERAL, STATE OR

RTECS: 9999999ZZ

USE PROER GROUNDING PROC DUE TO ELECTROSTATIC

RTECS: 9999999ZZ

HEAT WILL PRODUCE VAPORS. CLOSE CNTNRS WHEN NOT IN

RTECS: 9999999ZZ

EXPOSE SUCH CNTNRS TO HEAT, FLAME, SPARKS,

RTECS: 9999999ZZ

EXPLODE & CAUSE INJURY OR DEATH. EMPTY DRUMS SHOULD

RTECS: 9999999ZZ

RETURN TO A DRUM RECONDITIONER, OR PROPERLY

RTECS: 9999999ZZ

HYDROCARBONS POSE POTNTL HUMAN HLTH RISKS WHICH MAY

RTECS: 9999999ZZ

EXPOS TO LIQUIDS, VAPS, MISTS/FUMES SHOULD BE

RTECS: 9999999ZZ

300 PPM TOTAL HYDROCARBON BASED ON COMPOSITION.

RTECS: 9999999ZZ

SOCIETY OF HEATING, AIR CONDITIONING & REFRIGERATING

RTECS: 9999999ZZ

UNDER SOME CDNTNS OF USE/COMBINATIONS OF EQUIP,

RTECS: 9999999ZZ

VENT IS RECOMM WHENEVER PROD IS USED IN CONFINED

RTECS: 9999999ZZ

SHOULD ASSURE THAT VENTILATION IS SUFFICIENT TO

RTECS: 9999999ZZ

CONSULT A QUALIFIED VENTILATION ENGINEER

RTECS: 9999999ZZ

PRLGD/RPTD SKIN CONTACT. WHENEVER HNDLG

RTECS: 9999999ZZ

SUCH AS WASHING YOUR HANDS AFTER USING PRODUCT.

RTECS: 9999999ZZ

SOLVS & PETRO BASED OILS. CONT LICENSED HAZ

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHAL: HIGH VAP CONCS (>1000 PPM) ARE
IRRIT TO EYES & RESP TRACT, MAY CAUSE HDCH, DIZZ, ANESTHESIA,
DROWS, UNCON & OTHER CNS EFTS INCLG DEATH. SKIN: LOW ORDER OF
TOXICITY. FREQUENT/PLNGD CONTACT MAY I RRIT & CAUSE DERM. SKIN CONT
MAY AGGRAVATE AN EXISTING CNDTN. EYE: SLIGHTLY IRRIT BUT DOES NOT
INJURE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: EYE TISSUE. INGEST: SMALL AMTS OF
THIS PRODUCT ASPIRATED INTO THE RESP SYTSEM DURING INGEST/VOMITING
MAY CAUSE MILD TO SEV PULM INJURY, POSS PROGRESSING TO DEATH.
MINIMAL TOXICITY. DEATH IS POSSIBLE IF EXPOSED TO VERY HIGH CONCS
FOR PRLNGD PERIODS. PERS SENSITIVE TO HYDROCARBON EXPOS MAY
EXPERIENCE(ING 2)
Medical Cond Aggravated by Exposure:PERSONNEL W/PRE-EXISTING HEALTH
CNDTNS OF DERMATITIS & RESPIRATORY AILMENTS WILL NOTICE PHYSICAL
REACTIONS WHEN EXPOSED TO SMALL AMOUNTS OF PRODUCT/VAPOR.

First Aid:EYE: FLUSH W/LGE AMTS OF WATER FOR AT LEAST 15 MINS/UNTIL
IRRIT SUBSIDES. IF IRRIT PERSISTS, GET MED ATTN. SKIN: REMOVE
CONTAMD CLTHG. FLUSH W/LGE AMTS OF WATER. WASH SKIN THORO W/SOAP &
WATER. DO NOT REUSE CONTAMD CLTHG UNTIL SOLVS HAVE BEEN REMOVED.
INHAL: USING PROPER RESP PROT, IMMED REMOVE FROM EXPOSURE. CALL MD
IMMED. IF BRTHG IS IRREG/STOPPED, START RESUS IF TRAINED. ADMIN O*2
IF (SUPDAT)

Flash Point Method:TCC
Flash Point:100F,38C
Lower Limits:1.2%
Upper Limits:9.6%
Extinguishing Media:USE WATER SPRAY TO COOL FIRE EXPOSED SURFACES AND
TO PROTECT PERSONNEL. USE FOAM OR DRY CHEMICAL TO EXTINGUISH FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
AVOID SPRAYING WATER DIRECTLY INTO STORAGE CNTNRS DUE TO DANGER OF
BOILOVER. SHUT OFF "FUEL" (SUPDAT)
Unusual Fire/Explosion Hazard:NONE. COMBUSTIBLE LIQUID, CAN FORM
COMBUSTIBLE MIXTURES AT TEMPERATURES AT OR ABOVE THE FLASH POINT.
(AUTOIGNITION TEMP: 559F)

Spill Release Procedures:LAND SPILL: ELIM ALL SOURCES OF IGNIT. PVNT
ADDTNL DISCHARGE OF MATL, IF POSS TO DO SO W/OUT HAZ. RECOVER FREE
PROD BY ADDING SAND, EARTH/OTHER SUITABLE ABSORB TO SPILLED LIQUID.
KEEP NON-ESSENTIAL PE RS AWAY. AVOID BRTHG VAPS. VENT CONFINED(ING
3)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN COOL DRY PLACE & DO NOT
EXCESS OVER STACK TO PVNT CRUSHING OF CNTNRS. AVOID TEMP EXTREMES
FOR PLNGD PERIODS TO PVNT PROD DEGRADATION.(ING 10)
Other Precautions:STATIC DISCHARGE, MATL CAN ACCUMULATE STATIC CHARGES
WHICH CAN CAUSE AN INCENDIARY ELECTRICAL DISCHARGE. "EMPTY" CNTNRS
RETAIN PROD RESIDUE(LIQUID &/VAP) & CAN BE DANGEROUS. DO NOT PRESS,
CUT, WELD, B RAZE, SOLDER, DRILL, GRIND/(ING 12)

Respiratory Protection:NOT NEEDED WHEN USED AS INTENDED W/CALCOMP
PRODUCTS. IN CONCS, EXCEEDING RECOMM SAFE EXPOSURE LIMIT, SUCH AS
DURING A MAJOR SPILL, USE A CHEMICAL CARTRIDGE
RESPIRATOR(NIOSH/MSHA APPRVD) EFFECTIVE FOR ORGANIC VAPS.
Ventilation:NO SPECIAL VENT IS NEEDED WHEN USED AS INTENDED W/CALCOMP
PRODS. NORMAL OFFICE VENT CONFORMING TO AMERICAN (ING 18)
Protective Gloves:NITRILE/NEOPRENE GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGS.
Other Protective Equipment:WEAR CHEMICAL RESIST APRON WHEN CLEANING
MACHINES AS REPLENISHERS MAY STAIN CLTHG.
Work Hygienic Practices:KEEP CNTNRS CLSD WHEN NOT IN USE. DO NOT SMOKE
WHEN USING PRODUCT. MIN BRTHG VAP/MIST. USE W/ADEQ VENT. AVOID (ING
23)
Supplemental Safety and Health
SPEC GRAV: 0.75 - 0.82 @ 15.5C(H*2O=1). FIRE FIGHT PROC: TO FIRE. IF
LEAK/SPILL HAS NOT IGNIT, USE WATER SPRAY TO DISPERSE VAPS. FIRST
AID PROC: AVAIL. INGEST: DO NOT INDUCE VOMIT. DILUTE CONTENTS OF
STOMACH W/SEVERAL GLASSES OF WATER. CALL MD IMMED.

Boiling Pt:B.P. Text:>320F,>160C
Vapor Pres:2 @ 20C
Vapor Density:4.94
Spec Gravity:SUPDAT
Evaporation Rate & Reference:0.3 APPROXIMATE (NBUAC=1)
Solubility in Water:<0.01 @ 25C
Appearance and Odor:CYAN LIQUID WITH FAINT ISOPARAFFINIC HYDROCARBON
ODOR.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE.

Waste Disposal Methods:RCRA HAZ WASTE NO: D001. WASTE TONERS &
REPLENISHERS ARE HAZ WASTES AS DEFINED BY 40 CFR CHAPTER 1(FLAMM).
ASSURE CONFORMITY W/ALL APPLIC FED, STATE & LOC DISP REGS. WASTE
TONERS & REPLENISHERS ARE CO MPATIBLE FOR DISP W/MOST
NON-HALOGENATED(ING 25)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.