Product ID:CLEAR FINISH PREMIUM VARNISH SATIN SHEEN, 16056 PT
MSDS Date:05/12/1988
FSC:8010
NIIN:00N059100
MSDS Number: BXGMG

ZYNOLYTE PRODUCTS CO

2320 E DOMINGUEZ ST
CARSON, CA 90749-6244
US

Emergency Phone: 213-542-7701;800-424-9300(CHEMTREC)

Info Phone: 213-513-0700

Cage: 25461

ZYNOLYTE PRODUCTS CO

6244 CARSON, CA 90749 US

Telephone: 310-513-0700

Cage: 25461

SILICA GEL; (AMORPHOUS SILICA)

CAS: 112945-52-5

RTECS: VV7310000

OSHA PEL 6 MG/M3

ACGIH TLV: 10 MG/M3

SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC; (MEDIUM

CAS: 64742-88-7

OSHA PEL N/K

ACGIH TLV: N/K

BUTYL ALCOHOL; (N-BUTYL ALCOHOL) (SARA 313) (CERCLA).

CAS: 71-36-3

RTECS: EO1400000

OSHA PEL 100 PPM

ACGIH TLV: 50 PPM, S, C

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

NON-HAZARDOUS POLYMER (TYPE NOT SPECIFIED)

OSHA PEL N/K

ACGIH TLV: N/K

POLYAMIDE POLYMER

OSHA PEL N/K

ACGIH TLV: N/K

25 @ 20C.

CAS: 1330-20-7

RTECS: ZE2100000

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM;150 STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ETHANE, 1,1,1-TRICHLORO-; (1,1,1-TRICHLOROETHANE) (SARA

CAS: 71-55-6

RTECS: KJ2975000

OSHA PEL 350 PPM

ACGIH TLV: 350 PPM;450 STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

SENSIT OF MYOCARDIUM TO EPINEPHRINE IN LAB ANIMALS &

RTECS: 9999999ZZ

(E.G., EPINEPHRINE) MAY BE CONTRAINDICATED EXCEPT FOR

RTECS: 9999999ZZ

CHRONICALLY EXPOSED TO CHLOROCARBONS .

RTECS: 9999999ZZ

CAUSE THE FORMATION OF HCL &/OR PHOSGENE .

RTECS: 9999999ZZ

MASK, NEG PRESS, VAP PARTICULATE RESP (TC-230)

RTECS: 9999999ZZ

NO CASE CAN THE HALF MASK RESP BE USED UNLESS WEARER

RTECS: 9999999ZZ

PAINTING, A NIOSH/MSHA APPRVD POS PRESS SUPPLIED AIR

RTECS: 9999999ZZ

WHILE SOLV ODOR IS RETAINED IN THEM. PROT

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHAL:MAY CAUSE NOSE & THROAT IRRIT.
MAY CAUSE NERV SYS DEPRESS CHARACT BY FOLLOWING PROGRESSIVE
STEPS:HDCH, DIZZ, NAUS, STAG GAIT, CONFUSN, UNCON. RPTS HAVE ASSOC
RPTD & PRLNG OVEREXP TO SOLV W/PERM BRAIN & NERV SYS DMG. SKIN/EYE
CONT:MAYCAUSE IRRIT/BURNING OF EYES. RPTD/PRLNG LIQ CONT MAY CAUSE
SKIN(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:IRRIT W/DISCOMFORT & DERM. INGEST:GI
DISTRESS. ING 2:LAB STUDIES W/RATS HAVE SHOWN THAT PETRO DISTILS
CAUSE KIDNEY DMG & KIDNEY/LIVER TUMORS. ING 3:LIQ SPLASHES IN EYE
MAY RSLT IN CHEM BURNS. MAY CAUSE ABNORMAL LIVER/KIDNEY FUNC. ING
6:HIGH CONCS HAVE CAUSED EMBRYOTOXIC EFTS IN LAB ANIMALS. RECURRENT
(SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHAL:REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTF RESP,
PREFERABLY MOUTH-TO-MOUTH. IF BREATHING DIFFICULTY PERSISTS OR
OCCURS LATER, CONSULT MD. EYE:IMMEDIATELY FLUSH W/PLENTY OF WATER
FOR AT LEA ST 15 MINUTES; CALL MD. SKIN:WASH W/SOAP & WATER. IF
IRRITATION OCCURS, CONTACT MD. INGEST:CALL MD IMMEDIATELY & HAVE
NAMES OF INGREDIENTS AVAILABLE.

Flash Point Method:CC
Flash Point:>20F,>-7C
Lower Limits:0.8%
Upper Limits:0.8%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA &
FULL PROTECTIVE EQUIPMENT . WATER FROM FOG NOZZLES MAY BE USED TO
PREVENT PRESSURE BUILD-UP.
Unusual Fire/Explosion Hazard:THERMAL DECOMP PRODS MAY INCL HCL &
PHOSGENE . WHEN HEATED ABOVE FLASH POINT, EMITS FLAMM VAPS WHICH,
WHEN MIXED W/AIR CAN BURN/BE EXPLO. FINE (SUPP DATA)

Spill Release Procedures:VENTILATE AREA. REMOVE SOURCES OF IGNITION.
PREVENT SKIN CONTACT & BREATHING OF VAPOR. CONFINE & REMOVE W/INERT
ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:COMBUSTIBLE LIQUID. OBSERVE LBL PRECS.
KEEP AWAY FROM HEAT, SPKS & FLAME. CLOSE CNTNR AFTER EACH USE.
GROUND CNTNRS WHEN POURING. DO NOT STORE >120F.
Other Precautions:DO NOT SAND, FLAME CUT, BRAZE/WELD DRY COATING W/OUT
NIOSH/MSHA APPRVD RESP/APPROP VENT. DO NOT BREATHE VAPS/MISTS. NO
SMOKING IN AREA OF USE. DO NOT USE IN GEN VICIN OF ARC WELDING,
OPEN FLAMES/HOT S URFS. HEAT &/OR UV RADIA MAY (ING 11)

Respiratory Protection:FOR MIXING & BRUSH/ROLL APPLICATION, NIOSH/MSHA
APPRVD POS PRESS SUPPLIED AIR RESP IS REC, UNLESS MONITORING DATA
CONFIRMS EXPOS TO SOLVS WILL BE BELOW 10 TIMES TLV. IF EXPOS ARE
BELOW OUTLINED LIMS, THEN NIOSH/MSHA APPRVD HALF (ING 12)
Ventilation:PROVIDE SUFFICIENT VENTILATION IN VOLUME & PATTERN TO KEEP
CONTAMINANTS BELOW APPLICABLE OSHA REQUIREMENTS.
Protective Gloves:IMPERMEABLE GLOVES (E.G., NEOPRENE).
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS .
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . WEAR COVERALLS. DO NOT REUSE COVERALLS(ING
15)
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE EATING
OR SMOKING.
Supplemental Safety and Health
% VOLAT:28.7-96.9. EXPLO HAZ:MISTS/SPRAYS MAY BE FLAMM AT TEMPS BELOW
FLASH POINT. EFTS OF OVEREXP:OVEREXP MAY RSLT IN LIVER & KIDNEY
INJURY. CAN BE ABSORBED THRU SKIN IN HARMFUL AMTS. ING 7:CAN BE AB
SORBED THRU SKIN IN HARMFUL AMTS. MAY CAUSE ABNORMAL KIDNEY/LIVER
FUNCTION. CHLOROCARBON MATLS HAVE PRODUCED (ING 8)

Boiling Pt:B.P. Text:>0F,>-18C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:0.81-1.72
Evaporation Rate & Reference:LESS THAN ETHER
Solubility in Water:MISCIBLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SUPDAT

Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:HCL, PHOSGENE . CO, CO*2, SMOKE,
OXIDES OF HEAVY METALS REPORTED IN HLTH HAZARD DATA.

Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. INCINERATE ABSORBED MATERIAL I/A/W FEDERAL, STATE &
LOCAL REQUIREMENTS. DO NOT INCINERATE IN CLOSED CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.