Product ID:M-BOND 600 ADHESIVE
MSDS Date:05/30/1991
FSC:8040
NIIN:00N008549
MSDS Number: CCNBJ

MEASUREMENTS GROUP INC

RALEIGH, NC 27611
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 919-365-3800

Cage: 88952

MEASUREMENTS GROUP INC

WENDELL, NC 27591 US

Telephone: 919-365-3800

Cage: 88952

FURAN, TETRAHYDRO-; (TETRAHYDROFURAN) (CERCLA)

CAS: 109-99-9

RTECS: LU5950000

Fraction By Weight: 50.3%

OSHA PEL 200 PPM

ACGIH TLV: 200 PPM;250 STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

PHENOL, POLYMER WITH FORMALDEHYDE, GLYCIDYL ETHER; (EPOXY

CAS: 28064-14-4

Fraction By Weight: 36.2%

OSHA PEL N/K

ACGIH TLV: N/K

2-BUTANONE; (METHYL ETHYL KETONE) (MEK) (SARA 313)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 13.5%

OSHA PEL 200 PPM

ACGIH TLV: 200 PPM;300 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

598 G/L.

RTECS: 9999999VO

LD50 LC50 Mixture:SEE INGREDIENT 3.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHALATION:HEADACHE, NAUSEA,
VOMITING, DIZZINESS, NARCOSIS, RESPIRATORY FAILURE, LOW BLOOD
PRESSURE, CENTRAL NERVOUS SYSTEM DEPRESSION, COUGHING, DIFFICULT
BREATHING. SKIN/EYE CONTACT:SEVERE IRR ITATION OR BURNS. SKIN
ABSORPTION:DERMATITIS. INGESTION:HEADACHE, NAUSEA, VOMITING,
DIZZINESS, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:GASTROINTESTINAL IRRITATION.
CHRONIC:OVEREXPOSURE MAY RESULT IN KIDNEY AND/OR LIVER DAMAGE.
Medical Cond Aggravated by Exposure:SKIN DISORDERS, RESPIRATORY SYSTEM
DISEASE.

First Aid:INGEST:CALL MD. IF SWALLOWED, DO NOT INDUCE VOMITING. IF
CONSCIOUS, GIVE LARGE AMOUNTS OF WATER. INHAL:REMOVE TO FRESH AIR.
IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF BREATHING IS
DIFFICULT, GI VE OXYGEN. SKIN:FLUSH W/WATER. EYES:IMMEDIATELY FLUSH
W/PLENTY OF WATER FOR AT LEAST 15 MINUTES.

Flash Point Method:PMCC
Flash Point:6F,-14C
Lower Limits:1.8%
Upper Limits:11.8%
Extinguishing Media:ALCOHOL FOAM, DRY CHEMICAL, CARBON DIOXIDE. WATER
MAY BE INEFFECTIVE.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . MOVE CNTNRS FROM FIRE AREA IF IT CAN BE DONE W/OUT
RISK. USE WATER TO KEEP FIRE-EXPOS CNTNRS COOL.
Unusual Fire/Explosion Hazard:VAPS MAY FLOW ALONG SURFS TO DIST IGNIT
SOURCE & FLASH BACK. CLSD CNTNRS EXPOS TO HEAT MAY EXPLODE. CONT
W/STRONG OXIDIZERS MAY CAUSE FIRE. MAY FORM (SUPP DATA)

Spill Release Procedures:WEAR NIOSH APPRVD SCBA & FULL PROT CLTHG. SHUT
OFF IGNIT SOURCES; NO FLARES, SMOKING/FLAMES IN AREA. STOP LEAK IF
YOU CAN DO SO W/OUT RISK. USE WATER SPRAY TO REDUCE VAPS. TAKE UP
W/SAND OR OTHER NON- COMBUST ABSORB MATL & PLACE INTO CNTNR
FOR(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP CONTAINERS TIGHTLY CLOSED. STORE
IN A COOL, DRY, WELL-VENTILATED, FLAMMABLE LIQUID STORAGE AREA.
KEEP PRODUCT OUT OF LIGHT.
Other Precautions:FLAMMABLE LIQUID. KEEP CONTAINERS TIGHTLY SEALED.
AVOID PROLONGED EXPOSURE TO VAPORS AND SKIN CONTACT.

Respiratory Protection:NIOSH APPROVED RESPIRATORY PROTECTION REQUIRED
IF AIRBORNE CONC EXCEEDS TLV. AT CONCS UP TO 1000 PPM, A NIOSH
APPROVED CHEMICAL CARTRIDGE RESP W/ORGANIC VAPOR CARTRIDGE IS REC.
ABOVE THIS LEVEL, A NIO SH APPROVED SCBA IS RECOMMENDED.
Ventilation:LOCAL EXHAUST &/OR MECHANICAL (GENERAL): KEEP BELOW TLV.
Protective Gloves:NEOPRENE GLOVES.
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS(SUPDAT)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . IMPERVIOUS OVER CLOTHING AS NEEDED.
Work Hygienic Practices:WASH THOROUGHLY AFTER USING.
Supplemental Safety and Health
EXPLO HAZ:EXPLOSIVE PEROXIDES, ESPECIALLY WHEN HEATED. SPILL PROC:LATER
DISPOSAL. FLUSH AREA W/WATER. EYE PROT:& FULL LENGTH FACESHIELD .

Boiling Pt:B.P. Text:151F,66C
Vapor Pres:145 @ 59F
Vapor Density:2.5
Spec Gravity:0.9 (H*2O=1)
Evaporation Rate & Reference:14.5 (BUTYL ACETATE=1)
Solubility in Water:APPRECIABLE (>50%)
Appearance and Odor:COLORLESS LIQUID; ETHER-LIKE ODOR.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG BASES, STRONG REDUCING AGENTS.
Stability Condition to Avoid:HEAT, FLAME, OTHER SOURCES OF IGNITION,
LIGHT, AIR.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.

Waste Disposal Methods:DISPOSE OF I/A/W LOCAL, STATE & FEDERAL
ENVIRONMENTAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.