BBCRD - KILLMASTER

Product Identification

Product ID:KILLMASTER
MSDS Date:01/01/1987
FSC:6840
NIIN:00D000427
MSDS Number: BBCRD

Responsible Party
POSITIVE FORMULATORS,INC.

Emergency Phone: 602-323-2322

Cage: 2V531

Contractor
POSITIVE FORMULATORS,INC.

Cage: 2V531

Ingredients

CHLORPYRIFOS (SARA III)

CAS: 2921-88-2

RTECS: TF6300000

Fraction By Weight: 1.0%

OSHA PEL S, 0.2 MG/M3

ACGIH TLV: S, 0.2 MG/M3; 9192

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB


AROMATIC SOLVENT (SHELL TS-28B SOLVENT)

Fraction By Weight: >73%

ACGIH TLV: 35PPM


UNIDENTIFIED COMPONENTS

Fraction By Weight: <25%

Hazards

Effects of Overexposure:MAY CAUSE
ANESTHESIA,HEADACHES,NAUSEA,DIZZ,ETC.LIQ MILDLY IRRIT TO SKIN.MAY
FATAL IF SWALLOWED.

First Aid

First Aid:EYES:FLUSH W WATER,GET MED ATTN IF IRRIT. PERSISTS.SKIN:WASH
W SOAP & WATER.INHAL:REMOVE TO FRESH AIR.GIVE CPR/OXYGEN IF
NEEDED.,GET MED ATTN.INGEST:DO NOT INDUCE VOMITING.GUARD AGAINST
ASPIRATION INT O LUMGS.GET MED ATTN.ANTIDOTE:ATROPINE.

Fire Fighting

Flash Point Method:TCC
Flash Point:=43.9C, 111.F
Lower Limits:1.0
Upper Limits:7.0
Extinguishing Media:CO*2, FOAM, DRY CHEM & H*2O FOG.
Fire Fighting Procedures:WEAR SELF-CNTD BRTHG,APP H*20 SPRAY TO COOL
CONTR.
Unusual Fire/Explosion Hazard:CONTAINERS EXPOSED TO HEAT OR FIRE MAY
EXPLODE BECAUSE OF PRESSURE BUILT IN.

Accidental Release

Spill Release Procedures:SMALL SPILL:ABOSRB ON ABSORBENT MATL.& PLACE
IN CONTAINER LARGE SPILL:ELIM SOURCE OF IGNITION,WEAR PROTECTIVE
EQUIP;STOP SPILL AT SOURCE.DIKE SPILL AREA;PUMP LIQ INTO SALVAGE
TANK.ABOSRB REMAINING LIQ ON ABSORBENT MATL & SHOVEL TO
CONTAINERS.

Handling

Handling and Storage Precautions:STORE IN COOL DRY OLACE.USE REASONABLE
CARE.DO NOT STORE NEAR SOURCE OF HEAT,IGNITION,SPARK.
Other Precautions:AVOID FREQUENT SKIN CONTACT.AVOID OPEN FLAMES & SPARK
SOURCES.PROVIDE ADEQUATE VENTLN.OBSERVE ALL HAZ PRECAUSTIONS FOR
EMPTY CNTNRS OF PRODUCT BECAUSE EMPTY CONTNR MAY HAVE RESIDUAL
PROD.

Exposure Controls

Respiratory Protection:NORMALLY NOT NEEDED.IF DESIRED USE A APPROVED
AIR-PURIFYING RESPIRTR
Ventilation:LOCAL EXHAUST RECOMMENDED.
Protective Gloves:RUBBER
Eye Protection:CHEM SPLASH GOGG/SAFETYGL
Other Protective Equipment:IMPERVIOUS CLOTHES/BOOTS TO AVOID PROLONGED
SKIN CONTACT.
Supplemental Safety and Health
MSDS FROM POSITIVE FORMULATORS INC.,DATED:10/29/86;PRODUCT CONTAINS
1.0% OF CHLORPYRIFOS AVAILABLE IN 1 GAL CAN.

Chemical Properties

HCC:F4
Boiling Pt:=154.4C, 310.F
B.P. Text:310-362F
Vapor Pres:<5
Vapor Density:9.2
Spec Gravity:0.873
Evaporation Rate & Reference:<1.0(BU-ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT GOLD COLOR W AROMATIC ODOR
Percent Volatiles by Volume:96.9

Stability

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, IGNITION SOURCES
Hazardous Decomposition Products:CO,CO*2,OXIDES OF PHOSPHORUS MAY BE
FORMED DURING COMBSTN.

Disposal

Waste Disposal Methods:DESTROY LIQ BY LIQ INCINERATION IAW LOCAL,STATE
& FED REG.MATL COLLECTED ON ABSORBENT MATL SHOULD BE SHIPPED FOR
BURIAL TO A LANDFILL IAW LOCAL,STATE & FED REGS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.