BBGZL - POLYAMIDE 44GN008A, COMPONENT A

  • MSDS: BBGZL
  • Manufacturer: DEFT INC
  • Product Name: POLYAMIDE 44GN008A, COMPONENT A
  • National Stock Number: 8010-01-218-0857
Product Identification

Product ID:POLYAMIDE 44GN008A, COMPONENT A
MSDS Date:03/03/1989
FSC:8010
NIIN:01-218-0857
Kit Part:Y
MSDS Number: BBGZL

Responsible Party
DEFT, INC.
17451 VON KARMAN AVENUE
IRVINE, CA 92714
US

Emergency Phone: 714-474-0400

Info Phone: 714-474-0400

Cage: DO188

Contractor
DEFT, INC.
IRVINE, CA 92714 US

Telephone: 800-424-9300

Cage: DO188

Ingredients

2-BUTOXYETHANOL

CAS: 111-76-2

RTECS: KJ8575000

Fraction By Weight: 15%.

OSHA PEL S, 50 PPM

ACGIH TLV: S, 25 PPM; 9293


C9&10 AROMATIC HYDROCARBON (VP MM HG 3.)

CAS: 64742-95-6

Fraction By Weight: 15%.


BARIUM CHROMATE

CAS: 10294-40-3

RTECS: CQ8760000

Fraction By Weight: 25%.

OSHA PEL .05 MG/M3

ACGIH TLV: .1 MG/M3

Hazards

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: VAPORS ARE IRRITATING TO EYES,
NOSE, AND THROAT.INHALATION MAY CAUSE HEADACHE, DIFFICULT BREATHING
AND LOSS OF CONSCIOUSNESS. CHRONIC: PROLONGED CONTACT WILL CAUSE
DRYING AND CRACKING OF THE SK IN, DUE TO DEFATTING ACTION. SKIN
SENSITIZATION, ASTHMA OR OTHER ALLERGIC RESPONSES MAY DEVELOP.
Explanation of Carcinogenicity:BARIUM CHROMATE CAS #10294-40-3 IS A
CHEM KNOWN TO THE STAT OF CA TO CAUSE CANCER,BIRTH DEFECTS OR OTHER
REPRODUCT HARM.
Effects of Overexposure:OVEREXPOSURE MAY CAUSE IRRITATION OF
RESPIRATORY TRACT & ACUTE NERVOUS SYSTEM DEPRESSION,SKIN IRRITATION
SUCH AS SWELLING,REDNESS & RASH.TEARING,REDNESS AND SWELLING OF THE
EYES.MODERATE IRRITATION,DR YNESS & DEFATTING OF THE
SKIN.IRRITATION & POSSIBLE CORROSIVE ACTION IN THE MOUTH,STOMACH
TISSUE & DIGESTIVE TRACT.
Medical Cond Aggravated by Exposure:ASTHMA & ANY OTHER RESPIRATORY
DISORDERS. SKIN ALLERGIES, ECZEMA AND DERMATITIS.

First Aid

First Aid:INHALE-MOVE WHERE FREE FROM RISK OF FURTHER EXPOS.RESTORE
BREATH.ASTHMATIC TYPE SYMP MAY DEVELOP & MAY BE IMMED OR DELAY BY
SEV HRS.OBTAIN MED ATTN.SKIN-REMOVE CONTAM CLOTH.WASH AFFECTED
AREAS THOROUG HLY W/SOAP & WATER.WASH CONTAM CLOTH THOROUGHLY
BEFORE REUSE. EYES-FLUSH W/CLEAN LUKEWARM WATER(LOW PRESS)AT LEAST
15 MIN,OCCASION LIFT EYELID.OBTAIN MED ATTN.INGEST-DO NOT INDUCE
VOMIT.OBTAIN MED ATT

Fire Fighting

Flash Point Method:TCC
Flash Point:100F -38C
Lower Limits:1.%
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:EQUIP W/SELF CONTAIN BREATH APPARAT & FULL
PROTECT CLOTH SHLD BE WORN.WATER MAY BE USED TO COOL CLSD CONTAIN
TO PREVENT PRESS BUILD-UP,AUTO IGNITION OR EXPLOS.
Unusual Fire/Explosion Hazard:KEEP CONTAIN TIGHTLY CLSD.ISOLATE FROM
HEAT, SPARKS,ELEC EQUIP & OPEN FLAMES.CLSD CONTAIN MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT.OVEREX TO DECOMP PROD-HLTH HA

Accidental Release

Spill Release Procedures:EVACUATE ALL NON-ESSENTIAL PERSONNEL.REMOVE
ALL SOURCES OF IGNITION (FLAME,SPARK SOURCES,HOT
SURFACES).VENTILATE AREA. CONTAIN AND REMOVE WITH INERT ABSORBENT
AND NON-SPARKING TOOLS.

Handling

Handling and Storage Precautions:BLDGS DESIGNED TO COMPLY W/OSHA
1910.106. AVOD STORING NEAR HIGH TEMPS,FIRE,OPEN FLAMES & SPARK
SOURCES.STORE IN TIGHT CLOSED CONTAIN IN WELL VENT ARE
Other Precautions:KEEP CNTNR TIGHT & UPRIGHT TO PREVENT LEAK.PREVENT
PROLONG BREATH OF VAPORS OR SPRAY MISTS.AVOID CONTACT W/SKIN &
EYE.DO NOT TAKE INTERN.DO NOT HNDLE UNTIL MFR SAFETY PRECAUTS HAVE
BEEN READ & UNDRSTD .PROLONG OVEREXPOS MAY CAUSE ALLERG REAC

Exposure Controls

Respiratory Protection:RESPIR RECOMMEND OR APPROVED FOR USE IN AN
ORGANIC VAPOR ENVIRON (AIR PURIFYING OR FRESH AIR SUPPLIED)IS
NECESSARY.OBSERVE OSHA REGS FOR RESPIRATOR USE.VENTILATION SHOULD
BE PROVIDED TO KEEP EXPOSURE LEVELS BELOW THE OSHA PERMISSIBLE
LIMITS
Ventilation:EXHAUST VENT SUFFICIENT TO KEEP AIRBORNE CONCENTRATION OF
SOLVENT VAPORS & MISTS BELOW THEIR RESPECT TLVS MUST BE USED.
Protective Gloves:NEOPRENE, RUBBER, POLYETHYLENE GLOVES.
Eye Protection:SAFETY EYEWEAR INCLUDING SPLASH GUARDS.
Other Protective Equipment:LONG SLEEVE AND LONG LEG CLOTHING.
Work Hygienic Practices:WASH HANDS BEFORE EATING,SMOKING OR USING
WASHROOM.SMOKE IN SMOKING AREAS ONLY.
Supplemental Safety and Health
KEY1:F5. THIS ENTRY DESCRIBES PART A OF A TWO PART KIT. SEE THIS SAME
NSN, P/N IND B, FOR PART B DATA. (HEALTH HAZARDS) POTENTIAL FOR
KIDNEY & LIVER DAMAGE. REPEATED AND PROLONGED EXPOSURE MAY CAUSE D
ELAYED EFFECTS INVOLVING THE BLOOD, GASTROINTESTINAL, NERVOUS AND
REPRO SYSTEM.

Chemical Properties

HCC:F5
Boiling Pt:B.P. Text:308F - 340F
Vapor Density:>AIR
Evaporation Rate & Reference:0.0 X N-BUTYL ACETATE
Appearance and Odor:GREEN LIQUID WITH SOLVENT ODOR.
Percent Volatiles by Volume:44.3

Stability

Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS AND STRONG ACIDS.EPOXY RESINS UNDER UNCONTROLLED
CONDITIONS.
Stability Condition to Avoid:HIGH TEMPERATURES.EPOXY RESINS UNDER
UNCONTROLLED CONDITIONS.
Hazardous Decomposition Products:BY HIGH HEAT/TEMPERATURE: CARBON
MONOXIDE, CARBON DIOXIDE, AND OXIDES OF NITROGEN. CHROMIUM OXIDES
WHEN BURNED.
Conditions to Avoid Polymerization:HIGH TEMPERATURES. EPOXY RESINS
UNDER UNCONTROLLED CONDITIONS.

Disposal

Waste Disposal Methods:DISPOSE OF IAW FEDERAL,STATE AND LOCAL
ENVIRONMENTAL CONTROL REGULATIONS.EMPTY CONTAINERS MUST BE HANDLED
WITH CARE, DUE TO PRODUCT RESIDUE AND FLAMMABLE VAPOR.DO NOT
INCINERATE CLOSED CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.