Product ID:4283 HEAT RESISTANT TOPCOATS
MSDS Date:11/04/1985
FSC:8040
NIIN:00F003770
MSDS Number: BBNSR

RUST-OLEUM CORP

11 HAWTHORN PKWY
VERNON HILLS, IL 60061-1583
US

Emergency Phone: 708-367-7700

Info Phone: 708-367-7700

Cage: 08882

RUST-OLEUM CORP

VERNON HILLS, IL 60061-1583 US

Telephone: 847-367-7700

Cage: 08882

BENZIN, NAPHTHA, MINERAL SPIRITS, PETROLEUM NAPHTHA

CAS: 8030-30-6

RTECS: DE3030000

Fraction By Weight: 35-40%

OSHA PEL 500 PPM

ACGIH TLV: 300 PPM

9.5-11.1

RTECS: 9999999WG

Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALALTION: ANESTHETIC, IRRITION OF
RESPIRATORY TRACT OR ACUTE NERVOUS SYSTEM DEPRESSION CHARACTERIZED
BY HEADACHE, DIZZINESS, STAGGERING, CONFUSION, UNCONSCIOUSNESS OR
COMA. EYES & SKIN: IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:INHALATION: PERMANENT BRAIN & NERVOUS SYSTEM
DAMAGE.

First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. EYES:
FLUSH IMMEDIATELY W/LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINS.
SKIN: WASH AFFECTED AREA W/SOAP & WATER. OBTAIN MEDICAL ATTENTION
IN ALL CASE S.

Flash Point Method:TCC
Flash Point:104F
Extinguishing Media:CO2, DRY CHEMICAL OR FOAM
Fire Fighting Procedures:FULL PROTECTIVE CLOTHING INCLUDING SCBA. WATER
SPRAY MAY BE INEFFECTIVE, BUT MAY BE USED TO COOL CLOSED
CONTAINERS. IF WATER IS USED, FOG NOZZLES ARE PREFERRED.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY BUILD-UP PRESSURE,
AUTOIGNITE, OR EXPLODE WHEN EXPOSED TO EXTREME HEAT. COMBUSTIBLE
LIQUID.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION, VENTILATE AREA
AND REMOVE WITH INERT ABSORBENT AND NON-SPARKING TOOLS.

Handling and Storage Precautions:DON'T STORE ABOVE 120F. STORE LARGE
QUANTITIES IN BUILDINGS DESIGNED & PROTECTED FOR STORAGE OF NFPA
CLASS II FLAMMABLE LIQUIDS.
Other Precautions:CONTAINERS SHOULD BE GROUNDED WHEN POURING. DON'T
TAKE INTERNALLY. EMPTY CONTAINERS MAY BE HAZARDOUS. AVOID CONTACT
W/SKIN & EYES. KEEP CONTAINERS TIGHTLY CLOSED.

Respiratory Protection:USE A BUREAU OF MINES APPROVED MECHANICAL FILTER
RESPIRATOR TO REMOVE SOLID AIRBORNE PARTICLES OF OVERSPRAY DURING
SPRAY APPLICATION. IN CONFINED AREAS, USE BUREAU OF MINES APPROVED
AIR LINE TYPE RESP IRATORS OR HOODS.
Ventilation:GENERAL DILUTION OR LOCAL EXHAUST: IN VOLUME & PATTERN TO
KEEP TLV BELOW ACCEPTABLE LIMIT.
Protective Gloves:REQUIRED.
Eye Protection:SPLASH-PROOF SAFETY GLASSES
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health

Boiling Pt:B.P. Text:307-389F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:57-66%

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, ELECTRICAL EQUIPMENT, SPARKS, OPEN
FLAMES, OR HOT SURFACES, TEMPS >120F, & OTHER SOURCES OF IGNITION
Hazardous Decomposition Products:CO AND CO2

Waste Disposal Methods:DISPOSE OF ACCORDING TO LOCAL, STATE AND FEDERAL
REGULATIONS. DON'T INCINERATE CLOSED CONTAINERS. COMBUSTIBLE
LIQUID.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.