Product ID:IGEPAL CO-630 SURFACTANT
MSDS Date:06/01/1986
FSC:6850
NIIN:00N010136
MSDS Number: BCTPF

GAF CHEMICAL

1361 ALPS ROAD
WAYNE, NJ 07470

Emergency Phone: (201)628-3869,(201)862-3993

Info Phone: (201)628-3869,(201)862-3993

Cage: HO537

GAF CHEMICALS CORP, SUB OF GAF CORP

WAYNE, NJ 07470 US

Telephone: 201-628-3341

Cage: 46575

ETHYLENE OXIDE (SARA III)

CAS: 75-21-8

RTECS: KX2450000

Fraction By Weight: <0.0002%

OSHA PEL 1 PPM; SEE 1910.1047

ACGIH TLV: 1 PPM, A2; 9192

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

IGEPAL CO-630 SURFACTANT

CAS: 9016-45-9

RTECS: MD0900000

Fraction By Weight: Fraction by Wt

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:RAT LD50:3000 MG/KG,RBT LD50: (SUP DAT)
Routes of Entry: Inhalation:NO Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:INHAL:RAT,EXPOSURE:8 HRS TO
CONCENTRATED VAPOR, AMBIENT TEMPERATURE,NO MORTALITY. SKIN:HUMAN-NO
IRRITATION. EYE:RABBIT,SEVERE IRRITATION W/AND W/OUT
WASHOUT.ETHYLENE OXIDE (EO),A CANCER & REPRODUCTIVE HAZARD,MAY BE
PRESENT IN THIS PRODUCT.
Explanation of Carcinogenicity:ETHYLENE OXIDE:NTP-MAY REASNBLY BE
ANTICPATD TO BE CARC,IARC-PROBABLE HMN CARC(GROUP 2B),OSHA-CANCER
HAZARD & (SUP DAT)
Effects of Overexposure:INGES:NO EFFECTS OF EXPOSURE EXPECTED. INHAL:IF
MISTED,CAUS IRRI OF MUCOUS MEMBRANES,NOSE,EYES &
THROAT,COUGHING,DIFFICULTY IN BREATHING. SKIN:NO EFFECT OF EXPO
EXPECT DUE TO CNTCT.MAY POSS CAUS IRRI/ DERMATITIS IN SOME INDIVDLS
UPON PRLNG CNTCT.EYE:CAUS PAINFL STING/BURN OF EYE&LID,WATERNG OF
EYES,CONJUNCTVTIS(SUP DAT)
Medical Cond Aggravated by Exposure:NO DATA FOUND.

First Aid:EYE:IMME FLUSH W/LGE AMTS OF WTR FOR AT LEAST 15 MIN.CALL
PHYSICIAN.INGES:GEN PRCAUT MEASURES SUGGEST INDUC VOMIT IMME BY GIV
2 GLAS OF WTR & STICKNG FINGER DOWN THROAT.NEVER GIV ANYTHNG BY
MOUTH TO A N UNCONSCIOUS PERSON.CALL PHYS.INHAL:RMOV TO FRESH
AIR.SUPPORT BREATHNG(GIVE O*2/ARTIFICIAL RESPIRATION). SKIN:FOR ALL
FOREIGN MATERIALS, WASH AFTER EXPOSURE.

Flash Point Method:PMCC
Flash Point:200F/93.3C
Lower Limits:N/DATA FOUND
Upper Limits:N/DATA FOUND
Extinguishing Media:USE MEDIA PROPER TO PRIMARY CAUSE OF FIRE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.

Spill Release Procedures:ABSORB W/EARTH, SAND/SIMILAR INERT MATERIAL &
DISPOSE OF W/SOLID WASTE ACCORDING TO FEDERAL,STATE & LOCAL
REGULATIONS. FLUSH SPILL AREA W/WTR.
Neutralizing Agent:N/K

Handling and Storage Precautions:DO NOT GET IN EYES.WASH THORO AFTER
HANDLNG.AVOID BREATHNG MIST.USE W/ADEQUATE VENT FOR MISTNG
OPERATION.EO,A CANCER & REPRODCTVE HAZARD,MAY (SUP DAT)
Other Precautions:WASH EQPT THORO W/STREAM/WARM WTR UNTIL CLEAN.CHECK
FOR FLAMMBLE W/EXPLO METER & ALSO CHECK THE OXYGEN LEVEL W/AN
OXYGEN METER.IN ALL CASES,FOLLOW GOOD INDUSTRIAL SAFETY PRACTICES
BEFORE ENTERING EQUI PMENT.

Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR, IF ADEQUATE
VENTILATION CANNOT BE PROVIDED AT ANY TIME, OR IF THERE IS A
POSSIBILITY OF EXCESSIVE CONTACT WITH HEADSPACE ABOVE THE DRUM OR
TANKWAGON.
Ventilation:USE W/ADEQUATE VENTILATION, ESPECIALLY WHERE
DRUMS/TANKWAGONS ARE BEING OPENED.
Protective Gloves:NONE REQUIRED.
Eye Protection:CHEMICAL WORKER GOGGLES.
Other Protective Equipment:N/K .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
LD50-LC50 MIX:2830 MG/KG.SGN&SYM OVEXPSR:OPAQUENESS OF CORNEA,POSS LEAD
TO LOSS OF SIGHT.HNDLNG/STOR PRCAU:BE PRESENT IN PRODUCT.RPEAT
EXPOS MAY BE HARMFUL.IF CONTRL PROCEDURES ARE FOLLOWD,AIR SPACE C
ONCEN SHLD BE BELOW OSHA ESTAB ACTION LEVEL.CARC:REPROD
HAZARD,ACGIH-SUSPECT HMN CARC.

Boiling Pt:B.P. Text:392F/200C
Melt/Freeze Pt:M.P/F.P Text:N/DATA FND
Decomp Temp:Decomp Text:N/K
Vapor Pres:N/VOLATILE
Vapor Density:N/VOLATILE
Spec Gravity:1.06
pH:6-8
Evaporation Rate & Reference:NOT VOLATILE
Solubility in Water:SOLUBLE
Appearance and Odor:FREE FLOWING, SLIGHTLY VISCOUS LIQUID, AROMATIC
ODOR.
Percent Volatiles by Volume:0.20%
Corrosion Rate:

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING OR REDUCING AGENTS.
Stability Condition to Avoid:NONE KNOWN
Hazardous Decomposition Products:ACRID SMOKE & FUMES EMITTED WHEN
HEATED TO DECOMPOSITION.

Waste Disposal Methods:DISPOSE OF WITH LIQUID WASTE ACCORDING TO
FEDERAL, STATE & LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.