Product ID:JP 4 JET FUEL ADDITIVE
MSDS Date:12/22/1988
FSC:6850
NIIN:00-082-2522
MSDS Number: BCYBG

Emergency Phone: 800-274-5263

Info Phone: 614-889-3333

Cage: 5A188

Telephone: 909-864-2310

Cage: 60777

2-METHOXYETHANOL (EGME) (SARA III)

CAS: 109-86-4

RTECS: KL5775000

Fraction By Weight: 100%

OSHA PEL S, 25 PPM

ACGIH TLV: S, 5 PPM; 9192

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:SEE SIGNS & SYMPTOMS OF OVEREXPOSURE
Effects of Overexposure:EYES:MODERATE IRRITATION,REDNESS,TEARING;SKIN
CONTACT:MODERATE IRRITATION,DEFATTING,DERMATITIS;SKIN
ABSORPTION:CAN BE ABSORBED IN TOXIC AMOUNTS;INHALATION:NASAL &
RESPIRATORY IRRITATION,DIZZINESS,WEAK
NESS,FATIGUE,NAUSEA,HEADACHE,UNCONSCIOUSNESS,ASPHYXIATION;INGESTION
:GASTROINTESTINAL IRRITATION,NAUSEA,VOMIT,DIARRHEA.
Medical Cond Aggravated by Exposure:NONE NOTED.

First Aid:SKIN:THOROUGHLY WASH AREA W/SOAP & WATER. REMOVE CONT.
CLTHG.LAUNDER CONT.CLTHG BEFORE REUSE.EYES:FLUSH W/LARGE AMTS OF
WATER.INGEST:GIVE TWO GLASSES OF WATER,INDUCE VOMITING.CALL DR.
INHALED:REMOVE T O FRESH AIR.IF BREATHING DIFFICULT GIVECPR.

Flash Point Method:TCC
Flash Point:100F,38C
Lower Limits:1.8
Upper Limits:14.0
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR, MAY TRAVEL
AND BE IGNITEDEXPLOSIVELY. NEVER CUT OR WELD ON OR NEAR DRUM,
RESIDUE WILL IGNITE.

Spill Release Procedures:SMALL SPILL:ABSORB LIQUID ON
PAPER,VERMICULITE,FLOOR ABSORBENT,OR OTHER ABSORBENT MATERIAL &
TRANSFER TO HOOD.LARGE SPILL:ELIMINATE ALL IGNITION
SOURFCES.PERSONS NOT WEARING PROTECTIVE EQUIP.SHOULD BE EXCLUDED
FROM AREA OF SPILL UNTIL(SEE SUPPL DATA)

Handling and Storage Precautions:CONTAINERS OF THIS MATERIAL MAY BE
HAZARDOUS WHEN EMPTIED.SINCE EMPTIED CONTAINERS RETAIN PRODUCT
RESIDUES(VAPOR,LIQ,&/OR SOLID,ALL HAZ PRECAUTIONS GI
Other Precautions:NONE

Respiratory Protection:NIOSH/MSHA JOINTLY APPD AIR SUPPLIED RESPIRATORS
Ventilation:LOCAL EXHAUST IS RECOMMENDED TO MAINTAIN EXPOSURE < TLVS
Protective Gloves:PVA,NEOPRENE
Eye Protection:CHEMICAL SPLASH GOGGLES.
Other Protective Equipment:WEAR IMPERVIOUS CLOTHING & BOOTS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE &
LAUNDER CONTAMINATED CLOTHING.
Supplemental Safety and Health
LARGE SPILL(CONTD):CLEAN UP HAS BEEN COMPLETED.STOP SPILL AT
SOURCE,DIKE AREA OF SPILL,PUMP LIQUID TO SALVAGE TK,REMAINING
LIQ.TAKEN UP ON SAND,CLAY,EARTH,FLOOR ABSORBENT.OR OTHER ABS.INTO
CON

HCC:F4
Boiling Pt:B.P. Text:255F(124C)
Vapor Pres:9.5
Vapor Density:2.60
Spec Gravity:0.961
Evaporation Rate & Reference:1.0,BUTYL ACETATE
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID,MILD ODOR.
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:CO*2,CO,ETC.

Waste Disposal Methods:SMALL SPILL:ALLOW VOLATILE PORTION TO EVAPORATE
IN HOOD.ALLOW SUFFICIENT TIME FOR VAPORS TO COMPLETELY CLEAR HOOD
DUCT WORK.DESTROY REMAINING MATERIAL BY BURNING IN AN IRON
PAN.LARGE SPILL:DESTROY BY LIQUID INCINERATION,CONT.ABSORB
DEPOSITIAW FED RE

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.