Product ID:DENATURED ALCOHOL SOLVENT
MSDS Date:12/03/1996
FSC:6810
NIIN:00-205-6786
MSDS Number: BDJNX

SUNNYSIDE CORP

225 CARPENTER AVE
WHEELING, IL 60090-6009
US

Emergency Phone: 708-541-5700

Info Phone: 708-541-5700

Cage: 9J570

SUNNYSIDE CORP

WHEELING, IL 60090-6009 US

Telephone: 847-541-5700

Cage: 9J570

ETHYL ACETATE (SARA III)

CAS: 141-78-6

RTECS: AH5425000

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM; 9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ETHYL ALCOHOL (ETHANOL)

CAS: 64-17-5

RTECS: RQ6300000

OSHA PEL 1000 PPM

ACGIH TLV: 1000 PPM; 8990

N-HEPTANE

CAS: 142-82-5

RTECS: MI7700000

OSHA PEL 500 PPM/500 STEL

ACGIH TLV: 400 PPM/500STEL;9293

METHYL ISOBUTYL KETONE (SARA III)

CAS: 108-10-1

RTECS: SA9275000

OSHA PEL 100 PPM/75 STEL

ACGIH TLV: 50 PPM/75 STEL; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

METHYL ALCOHOL (METHANOL) (SARA III)

CAS: 67-56-1

RTECS: PC1400000

OSHA PEL S,200PPM/250STEL

ACGIH TLV: S,200PPM/250STEL; 93

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

LD50 LC50 Mixture:LD50 (ORAL RAT) IS 7060 MG/KG (ETHANOL)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION OF HIGH VAPOR
CONCENTRATIONS MAY CAUSE UPPER RESPIRATORY TRACT IRRITATION AND
NARCOSIS. EYE CONTACT WITH LIQUID OR VAPOR CAUSES IRRITATION. SKIN
CONTACT MAY CAUSE IRRITATION AND DEFATTING O F SKIN ON PROLONGED
CONTACT. INGESTION MAY CAUSE DEPRESSION OF CENTRAL NERVOUS SYSTEM,
NAUSEA, VOMITING, DIARRHEA.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT IS
LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:UPPER RESPIRATORY TRACT IRRITATION, SLEEPINESS,
DIZZINESS, EYE IRRITATION, SKIN IRRITATION, SKIN DEFATTING, CNS
DEPRESSION, NAUSEA, VOMITING, DIARRHEA, DEATH, BLINDNESS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INGESTION: IF CONSCIOUS, DRINK WATER OR MILK TO DILUTE. NEVER
GIVE ANYTHING BY MOUTH IF UNCONSCIOUS. CALL PHYSICIAN OR POISON
CONTROL ASAP. ONLY INDUCE VOMITING IF ADVISED BY PHYSICIAN. EYES:
IMMEDIAT ELY FLUSH WITH PLENTY OF WATER FOR 15 MINUTES. GET MEDICAL
ATTENTION. SKIN:REMOVE CONTAMINATED CLOTHING. FLUSH WITH WATER. IF
IRRITATION PERSISTS, GET MEDICAL ADVICE. INHALATION: REMOVE TO
FRESH AIR.

Flash Point Method:TCC
Flash Point:=5.C, 41.F
Lower Limits:3.5
Upper Limits:NOT GIVEN
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, "ALCOHOL" FOAM, OR
DRY CHEMICAL. WATER MAY BE INEFFECTIVE IN FIGHTING FIRE.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:FLAMMABLE LIQUID. VAPORS ARE HEAVIER THAN
AIR AND MAY TRAVEL CONSIDERABLE DISTANCE TO A SOURCE OF IGNITION
AND FLASH BACK.

Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. SMALL SPILLS
MAY BE COLLECTED WITH ABSORBENT MATERIALS. FOR LARGE SPILLS, FLUSH
AREA WITH WATER SPRAY, PREVENT RUN OFF FROM ENTERING DRAINS, SEWERS
OR STREAMS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN A FLAMMABLE LIQUID STORAGE
ROOM OR CABINET. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE.
PROTECT CONTAINERS FROM PHYSICAL DAMAGE.
Other Precautions:MAKE FREQUENT CAREFUL LEAKAGE INSPECTIONS. ISOLATE
FROM OXIDEZERS, CHEMICALS CAPABLE OF SPONTANEOUS HEATING, MATERIALS
REACTING WITH AIR OR MOISTURE TO LIBERATE HEAT, IGNITION SOURCES
AND EXPLOSIVES. KEEP OUT OF DIRECT SUN & AWAY FROM HEAT.

Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL(TLV), USE NIOSH/MSHA APPROVED RESPIRATORS.
RESPIRATORS SHOULD BE SELECTED BASED ON THE FORM AND CONCENTRATION
OF CONTAMINANT IN AIR & IN ACCORDANCE WITH OSHA (29 CFR 1910.134).
Ventilation:MECHANICAL (GENERAL) ROOM VENTILATION IS NORMALLY ADEQUATE.
LOCAL EXHAUST MAY BE REQUIRED IF WORK AREA NOT VENTED.
Protective Gloves:SOLVENT RESISTANT.
Eye Protection:SAFETY GOGGLES WITH OPTIONAL FACE SHIELD
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS. CAUTION: FOR MANUFACTURING,
PROCESSING, REPACKING OR INDUSTRIAL USE. NOT FOR HOUSHOLD USE.
CONTAINE R HAZARDOUS WHEN EMPTY. EMPTIED CONTAINERS RETAIN RESIDUAL
LIQUID AND VAPOR. FOLLOW PRECAUTIONS ON LABEL AND IN MSDS.

HCC:F5
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:=73.9C, 165.F
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:NOT GIVEN
Vapor Density:>1
Spec Gravity:0.81
Evaporation Rate & Reference:<1 (ETHER=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID; CHARACTERISTIC ALCOHOL
ODOR
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS MAY CAUSE VIGOROUS REACTION.
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:COMBUSTION WILL PRODUCE CARBON DIOXIDE
AND PROBABLY CARBON MONOXIDE.

Waste Disposal Methods:INCINERATE UNDER SAFE CONDITIONS, OBSERVE ALL
FEDERAL, STATE AND LOCAL LAWS CONCERNING HEALTH AND ENVIRONMENT.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.