Product ID:MERCURY
MSDS Date:10/10/1986
FSC:6810
NIIN:00-281-7452
MSDS Number: BDTCM

D.F.GOLDSMITH CHEMICAL & METAL CORP.

909 PITNER AVE.
EVANSTON, IL 60202
US

Emergency Phone: 312-869-7800

Info Phone: 312-869-7800

Cage: 27368

LABORATORY SUPPLY CORP.

GARDENA, CA 90248-4232 US

Telephone: 502-737-6757

Cage: 4W642

MERCURY (SARA III)

CAS: 7439-97-6

RTECS: OV4550000

Fraction By Weight: >99%

OSHA PEL S, C, 0.1 MG/M3

ACGIH TLV: S, 0.05 MG/M3; 9192

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: SKIN:IRRITATION. ABSORBED
THROUGH SKIN CAUSING ANURIA. EYE:IRRITATION, CORNEAL INJURY OR
BURNS. INGESTION:IMMEDIATE NECROSIS IN MOUTH, THROAT, ESOPHAGUS &
STOMACH. DEATH MAY OCCURE. INHALATION: DYSPNEA, COUGH, FEVER,
NAUSEA & VOMITING, DIARRHEA, STOMATITIS, SALIVATION & METALLIC
TASTE. CHRONIC: CNS DISTURBANCES.
Explanation of Carcinogenicity:DATA PER MSDS
Effects of Overexposure:TREMORS, CONVULSIONS & OTHER CNS DISTURBANCES,
PNEUMONITIS, CHEST PAINS, DYSPNEA, COUGHING, STOMATITIS, GINGIVITIS
AND LOOSENING OF TEETH, SALIVATION, LOSS OF MEMORY, METALLIC TASTE,
DIZZINESS, CLUMSI NESS, SLURRED SPEECH, DIARRHEA, PAIN & NUMBNESS
IN EXTREMITIES, NEPHRITIS, ANXIETY, HEADACHE, WEIGHT LOSS, AND
INSOMNIA.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF
ALCOHOLISM, CHRONIC KIDNEY DISEASE OR KNOWN ALLERGY TO MERCURY MAY
BE AT INCREASED RISK FROM EXPOSURE.

First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING GIVE
CPR/OXYGEN. GET MEDICAL ATTENTION. EYE: IMMEDIATELY FLUSH EYES WITH
PLENTY OF WATER FOR 15 MINUTES HOLDING EYELIDS OPEN. GET MEDICAL
ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING. WASHSKIN WITH
PLENTY OF SOAP & WATER. INGESTION: GET IMMEDIATE MEDICAL ATTENTION.
A 5% SOLUTION OF SODIUM FORMALDEHYDE SULFOXYLATE MAY BE USED TO
INDUCE VOMITING.

Flash Point:NONE
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:AVOID BREATHING THE CORROSIVE,POISONOUS
FUMES.

Spill Release Procedures:SMALL SPILL: PICK UP WITH VACUUM EQUIPMENT
SPECIFICALLY DESIGNED FOR MERCURY PICK UP OR USE MERCURY SPILL KIT.
LARGE SPILL: EVACUATE AND VENTILATE AREA. IF POSSIBLE, STOP LEAK.
DIKE TO RETAIN. VACUUM UP FREE LIQUID. DO NOT TOUCH SPILLED
MATERIAL.
Neutralizing Agent:NONE

Handling and Storage Precautions:STORE IN SEALED UNBREAKABLE
POLYETHYLENE CONTAINERS IN A COOL, DRY, WELL VENTILATED AREA AWAY
FROM HEAT. PROTECT CONTAINERS FROM PHYSICAL DAMAGE.
Other Precautions:THIS CHEMICAL IS SUBJECT TO SARA SECTION 313
REPORTING. PROVIDE PREPLACEMENT AND PERIODIC MEDICAL EXAMS FOR
THOSE REGULARLY EXPOSED TO MERCURY, WITH EMPHASIS ON CNS, SKIN,
LUNGS, LIVER, KIDNEYS AND G. I. TRACT.

Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL(TLV), USE NIOSH/MSHA APPROVED RESPIRATORS AS
PER CURRENT 29 CFR 1910.134, INSTRUCTIONS/WARNINGS AND
NIOSH-RESPIRATOR DECISION LOGIC-PUBL ICATION NUMBER 87.108.
Ventilation:PROVIDE SUFFICIENT GENERAL/LOCAL EXHAUST VENTILATION IN
PATTERN/VOLUME TO CONTROL INHALATION EXPOSURES BELOW OSHA'S PEL.
Protective Gloves:RUBBER
Eye Protection:CHEMICAL SAFETY GOGGLES
Other Protective Equipment:SEPARATE WORK AND STREET CLOTHING. STORE
WORK CLOTHING IN SPECIAL LOCKERS. SHOWER BEFORE CHANGING TO STREET
CLOTHES.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
DO NOT GET ON SKIN, IN EYES OR ON CLOTHING. DO NOT BREATHE VAPORS.

HCC:T6
Boiling Pt:=357.2C, 675.F
Melt/Freeze Pt:=-38.9C, -38.F
Vapor Pres:0.0012 MM
Vapor Density:7.0
Spec Gravity:13.6
Solubility in Water:INSOLUBLE
Appearance and Odor:HEAVY,SILVERY,LIQUID METAL
Percent Volatiles by Volume:UNKNON

Stability Indicator/Materials to Avoid:YES
ACETYLENICS,AMMONIA,BORON,DIIODOPHOSPHIDE,ETHYLENE OXIDE,METALS
ESPECIALLY REACTIVE ONES ,METHYL AZIDE,OXYGEN,OXIDANTS
Stability Condition to Avoid:HIGH TEMPERATURES
Hazardous Decomposition Products:THERMAL DECOMPOSITION PRODUCTS INCLUDE
TOXIC MERCURY VAPORS AND OXYGEN.

Waste Disposal Methods:DO NOT INCINERATE - RETURN TO RECLAMATION
CENTER.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.