Product ID:AEROSHELL GREASE 17,70017
MSDS Date:03/06/1991
FSC:9150
NIIN:00-754-2595
MSDS Number: BFNMC

SHELL OIL COMPANY

HEALTH, SAFETY AND ENVIRONMENT
HOUSTON, TX 77210
US

Emergency Phone: 713-473-9461/800-424-9300(CHEMTREC)

Info Phone: 713-241-4819/4141/2252 FAX -6511

Preparer: J.C. WILLETT

Cage: 54527

SHELL OIL COMPANY

HOUSTON, TX 77210 US

Telephone: 800-231-6950

Cage: 54527

AZELAIC ACID, BIS(2-ETHYLHEXYL) ESTER/SYNTHETIC ESTER

CAS: 103-24-2

RTECS: CM2000000

BENTONITE/INORGANIC CLAY

CAS: 1302-78-9

RTECS: CT9450000

OSHA PEL 5 MG/M3 (DUST)

ACGIH TLV: 5 MG/M3 (DUST)

MOLYBDENUM DISULFIDE

CAS: 1317-33-5

RTECS: QA4697000

OSHA PEL 10 MG MO/M3

ACGIH TLV: 10 MG MO/M3

FATTY ACID AMIDES

CAS: 68910-93-0

OTHER COMPONENTS

LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:NO Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE-MAY BE IRRITATING TO THE EYS.
SKIN-PROLONGED OR REPEATED CONTACT MAY CAUSE VARIOUS SKIN DISORDERS
SUCH AS DERMATITIS, FOLLICULITIES OR OIL ACNE. RELEASE DURING HIGH
PRESSURE USAGE MAY RESULT IN IN JECTION OF GREASE INTO THE SKIN
CAUSINGLOCAL NECROSIS.
Explanation of Carcinogenicity:THIS PRODUCT AND ITS COMPONENTS ARE NOT
CLASSIFIED AS CARCINOGENIC BY IARC, NTP OR OSHA. THIS SPECIFIC
PRODUCT HAS NOT BEEN TESTED IN LONG-TERM, CHRONIC EXPOSURE TESTS.
Effects of Overexposure:IRRITATION AS NOTED ABOVE. LOCAL NECROSIS IS
EVIDENCED BY DELAYED ONSET OF PAIN AND TISSUE DAMAGE A FEW HOURS
FOLLOWING INJECTION.
Medical Cond Aggravated by Exposure:PREEXISTING SKIN DISORDERS MAY BE
AGGRAVTED BY EXPOSURE TO THIS PRODUCT.

First Aid:EYE-FLUSH WITH WATER FOR 15 MIN. HOLD EYELIDS OPEN. GET
MEDICAL ATTENTION. SKIN-REMOVE CONTAMINATED CLOTHES & WIPE EXCESS
OFF. WASH WITH SOAP & WATER OR A WATERLESS HAND CLEANER FOLLOWED BY
SOAP AND W ATER. IF IRRITATION PERSISTS, GET EMDICAL ATTENTION.. IF
MATERIAL IS INJECTED UNDER THE SKIN, GET MEDICAL ATTENTION PROMPTLY
TO PREVENT SERIOUS DAMAGE; DO NOT WAIT FOR SYMPTOMS TO DEVELOP.
INHALATION- REMOVE VICTIM TO FRESH AIR & PROVIDE OXYGEN IF
BREATHING IS DIFFICULT. GET MEDICAL ATTENTION. INGESTION-DO NOT
INDUCE VOMITING. IN GENERAL, NO TREATMENT IS NEDDED UNLESS LARGE
QUANTITIES ARE INGESTED. HOWEVER, GET MEDICAL ADVICE.

Flash Point Method:PMCC
Flash Point:>204.C, 399.2F
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL/CARBON DIOXIDE. DON'T
USE DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE REIGNITED
ON SURFACE OF WATER.
Fire Fighting Procedures:DO NOT ENTER ANY ENCLOSED OR CONFINED AREA
WITHOUT PROPER PROTECTIVE EQUIPMENT AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED CONTAINERS
SURROUNDING EQUIPMENT AND STRUCTURE W ITH WATER.
Unusual Fire/Explosion Hazard:NONE

Spill Release Procedures:SCOOP UP EXCESS GREASE. CLEAN AREA WITH
APPROPIATE CLEANER.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADQUATE VENTILATION. KEEP AWAY FROM OPEN FLAMES AND HIGH
TEMPERATURES.
Other Precautions:DO NOT GET IN EYES. MINIMIZE SKIN CONTACT. WASH
THOROUGHLY AFTER HANDLING. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. PROPERLY DISPOSE OF CONTAMINATED LEATHER ARTICLES INCLUDING
SHOES THAT CANNOT BE DECONTAMINATED.

Respiratory Protection:NOT ORDINARILY REQUIRED.
Ventilation:.
Protective Gloves:OIL RESISTANT GLOVES.
Eye Protection:.
Other Protective Equipment:USE OIL RESISTANT GLOVES AND OTHER CLOTHING
AS NEEDED TO MINIMIZE SKIN CONTACT.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
NOTE TO PHYSICIAN: IN GENERAL, EMESIS INDUCTION IS UNNECESSARY IN HIGH
VISCOSITY, LOW VOLATILITY PRODUCTS, I.E. MOST OILS AND GREASES.

HCC:V6
NRC/State Lic Num:NOT RELEVANT
Solubility in Water:INSOLUBLE
Appearance and Odor:DARK GREY, SMOOTH GREASE - SLIGHT ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXCESSIVE HEAT, OPEN FLAME
Hazardous Decomposition Products:A COMPLEX MIXTURE OF AIRBORNE SOLID,
LIQUID, PARTICULATES & GASES WILL EVOVLE. CARBON MONOXIDE & OTHER
UNIDENTIFIED ORGANIC COMPOUNDS MAY BE FORMED UPON COMBUSTION.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
AND FEDERAL REGULATIONS. THIS PRODUCT HAS BEEN EVALUATED FOR RCRA
CHARACTERISTICS AND DOES NOT MEET THE CRITERIA OF A HAZARDOUS WASTE
IF DISCARDED IN ITS PURCHASED FORM. THIS PRODUCT IS CONSIDERED AN
OIL

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Transport Information:NOT HAZARDOUS BY D.O.T. REGULATIONS.

SARA Title III Information:IN ACCORDANCE WITH SARA TITLE 111, SECTION
313, THE ENVIRONMENTAL DATA SHEET (EDS) SHOULD ALWAYS BE COPIED AND
SENT WITH THE MSDS. THE COMPONENTS OF THIS PRODUCT ARE LISTED ON
THE EPA/TSCA INVENTORY O F CHEMICALS SUBSTANCE. PROTECTION OF
STRATOSPHERIC OZONE: THIS PRODUCT DOES NOT CONTAIN NOR WAS IT
DIRECTLY MANUFACTURERED WITH ANY CLASS I OR CLASS II OZONE
DEPLETING SUBSTANCES.
Federal Regulatory Information:EPA-CLEAN WATER ACT (CWA). THIS PRODUCT
IS CLASSIFIED AS AN OIL UNDER SECTION 311 OF THE CLEAN WATER ACT.
SPILLS ENTERING (A) SURFACE WATERS OR (B) ANY WATERCOURSES OR
SEWERS ENTERING/LEAVING TO SURF ACE WATERS THAT CAUSE A SHEEN MUST
BE REPORTED TO THE NATIONAL RESPONSE CENTER, 800-424-8802.
State Regulatory Information:THE FOLLOWING CHEMICALS ARE SPECIFICALLY
LISTED BY INDIVIDUAL STAES: OTHER SPECIFIC HEALTH AND SAFETY DATA
IN OTHER SECTIONS OF THE MSDS MAY ALSO BE APPLCABLE FOR STATE
REQUIREMENTS. FOR DETAILS ON YO UR REGULATORY REQUIREMENTS YOU
SHOULD CONTACT THE APPROPIATE AGENCY IN YOUR STATE. MOLYBDENUM
DISULFIDE IS LISTED ON CALIFORNIA'S HAZARDOUS SUBSTANCE LIST.