Product ID:BONDMASTER (R) M777A
MSDS Date:07/31/1987
FSC:8040
NIIN:01-006-9439
Kit Part:Y
MSDS Number: BGCVH

NATIONAL STARCH AND CHEMICAL CORPORATION

FINDERNE AVENUE
BRIDGEWATER, NJ 08807
US

Emergency Phone: 201-685-5000

Info Phone: 201-685-5000

Cage: 01666

NATIONAL STARCH AND CHEMICAL CORP BONDMASTER DIV

BLOOMFIELD, NJ 07003-3584 US

Cage: 01666

BENTONE (R) 27

CAS: 12691-60-0

Fraction By Weight: >1%

N-BUTYL GLYCIDYL ETHER (BGE)

CAS: 2426-08-6

RTECS: TX4200000

Fraction By Weight: >1%

OSHA PEL 50 PPM

ACGIH TLV: 25 PPM; 9293

EPOXY RESIN

CAS: 25085-99-8

Fraction By Weight: >1%

LD50 LC50 Mixture:ORAL RAT LD50 = 2050 MG/KG (N-BUTYL ETH)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE- IRRITATION WITH SLIGHT
REVERSIBLE DAMAGE UPON DIRECT CONTACT. SKIN- IRRITATION,
SENSITIZATION DERMATITIS. INHALE- IRRITATION TO MUCOUS MEMBRANES,
COUGHING, DYSPNEA AND CNS DEPRESSION. INGE ST- SORE THROAT,
ABDOMINAL PAIN, DIZZINESS. CHRONIC: DUSTS MAY CAUSE SHORTNESS OF
BREATH. CONJUNTIVITIS.
Effects of Overexposure:IRRIATATION AND SLIGHT REVERSIBLE DAMAGE TO THE
EYE. POSSIBLE CONJUNTIVITIS. SENSITIZATION DERMATITIS. IRRITATION
TO UPPER RESPIRATORY TRACT. NUISANCE DUSTS MAY RESULT IN SHORTNESS
OF BREATH. IRRITATI ON TO THE MUCOUS MEMBRANES, COUGHING, DYSPNEA
AND CENTRAL NERVOUS SYSTEM DEPRESSION. DIZZINESS, DULLNESS, SORE
THROAT.

First Aid:INHAL: REMOVE TO FRESH AIR. SKIN: REMOVE WITH ALCOHOL THEN
WASH WITH SOAP & WATER. EYE: FLUSH WITH PLENTY OF WATER FOR 15
MINUTES, CALL MD. CALL MD FOR ANY UNUSUAL EXPOSURE.

Flash Point Method:TOC
Flash Point:220F,104C
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER
FOG.
Fire Fighting Procedures:MOVE CONTAINER FROM FIRE AREA IF POSSIBLE. DO
NOT SCATTER SPILLED MATERIAL WITH HIGH PRESSURE WATER STREAMS. DIKE
FIRE CONTROL WATER FOR LATER DISPOSAL.
Unusual Fire/Explosion Hazard:SLIGHT FIRE HAZARD WHEN EXPOSED TO HEAT
OR FLAME.

Spill Release Procedures:STOP LEAK IF YOU CAN DO IT WITHOUT RISK. TAKE
UP WITH SAND OR OTHER ABSORBENT MATERIAL AND PLACE INTO CLEAN, DRY
CONTAINERS FOR LATER DISPOSAL. KEEP UNNECESSARY PEOPLE AWAY.
ISOLATE HAZARD AREA AND DE NY ENTRY.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE AWAY FROM INCOMPATIBLE
SUBSTANCES.

Respiratory Protection:MFR STATES NOT NORMALLY REQUIRED
Ventilation:SUFFICIENT TO KEEP VAPORS BELOW TLV.
Protective Gloves:RUBBER
Eye Protection:GOGGLES WITH SIDE SHIELDS
Other Protective Equipment:AS NEEDED FOR SKIN CONTACT PREVENTION
Supplemental Safety and Health
NONE

HCC:N1
Spec Gravity:1.2
Solubility in Water:SLIGHTLY SOLUBLE
Appearance and Odor:DEEP RED PASTE WITH AN ETHER-LIKE ODOR.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS AND CAUSTICS. STRONG ACIDS, AMINE COMPOUNDS, BASES, OR
MERCAPTANS.
Stability Condition to Avoid:ABNORMAL TEMPERATURES AND PRESSURES.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY RELEASE
TOXIC AND/OR HAZARDOUS GASES.

Waste Disposal Methods:DISPOSE IAW FEDERAL,STATE & LOCAL CODES.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.