Product ID:EXTINGUISHER,FIRE,VAPORIZING LIQUID
MSDS Date:07/12/1989
FSC:4210
NIIN:01-092-3263
MSDS Number: BHBXQ

MFR. UNKNOWN/ DEFENSE CONSTRUCTION S.CTR. PROCURED

COLUMBUS, OH 43216-5000
US

Info Phone: 614-238-3131

Preparer: DGSC-SLM DOD-HMIS

Cage: MO879

MFR. UNKNOWN/ DEFENSE CONSTRUCTION S.CTR. PROCURED

3990 COLUMBUS, OH 43216-5000 US

Telephone: 614-238-3131

Cage: MO879

BROMOCHLORODIFLUOROMETHANE (AS EXTINGUISHING AGENT)

CAS: 353-59-3

RTECS: PA5270000

OSHA PEL NONE ESTABLISHED

ACGIH TLV: NONE ESTABLISHED

NITROGEN

CAS: 7727-37-9

RTECS: QW9700000

ACGIH TLV: ASPHYXIANT; 9192

LD50 LC50 Mixture:LC50(RAT): 20 PH/15M
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: ASPHYXIANT, 'CNS' & PULMONARY
EFFECTS. SKIN IRRITANT CHRONIC: NONE KNOWN.
Effects of Overexposure:INHAL:DIZZINESS, DISORIENTATION, IMPAIRED
COORDINATION, NARCOSIS, NAUSEA, OR VOMITING, LIGHT-HEADEDNESS,
GIDDINESS, BREATH SHORTNESS. CARDIAC ARRHYTHMIA W/ UNCONSCIOUSNESS
OR EVEN DEATH IH HI-CONC W/L ONG EXPOSURE; SKIN/EYES: CONTACT
W/LIQUID CAN CAUSE FROSTBITE, OR SKIN IRRITATION.
Medical Cond Aggravated by Exposure:CARDIAC PROBLEMS. (PRODUCT IS AN
ASPHYIANT & CAN INDUCE CARDIAC MUSCLE SENSITIZATION TO CIRCULATING
EPINEPHRINE-LIKE COMPOUNDS.)

First Aid:INHAL: REMOVE TO FRESH AIR-GET MED. ATTN. & GIVE O*2/CPR AS
REQUIRED FOR SITUATION & HAND; DONOT GIVE EPINEPHRINE OR SIMILIAR
DRUGS AS CATECOLAMINES INCREASE RISK OF ELICITING CARDIAC
DYSRYTHMIAS. EYE S/SKIN: FLUSH W/WATER - TREAT FOR FROSTBITE
W/MEDICAL ATTN. ; INGEST: NOT LIKELY TO OCCUR.

Flash Point:NONE
Extinguishing Media:MATERIAL IS A FIRE EXTINGUISHANT & IS
NON-FLAMMABLE. USE MEDIA APPROPRIATE FOR SURROUNDING FIRE,
Fire Fighting Procedures:USE 'SCBA' WHEN FIGHTING FIRES WHERE CHEMICALS
ARE INVOLVED. 'SCBA MAY BE NEEDED IF HALON-1211 CONTAINER RUPTURES
OR REALEASE MATERIAL IN HEAT OF FIRE.
Unusual Fire/Explosion Hazard:IN HEAT OF FIRE HALON-1211 CONTAINER
EXPOSED TO INTENSE HEAT OF FIRE MAY RUPTURE & MATERIAL COMPOSITION
MAY OCCUR.

Spill Release Procedures:EVACIUATE AREA OF UNNEEDED PERSONNEL,
VENTILATE AREA ESPECIALLY LOW PLACES WHERE HEAVEY VAPORS MIGHT
COLLECT.COOL OR REMOVE HOT METAL SURFACE OR SOURCES OF
NON-EXTINGUISHED FLAMES.

Handling and Storage Precautions:STORE & HANDLE AS A LIQUIFIED
COMPRESSED GAS IN 'DOT' APPROVED PRESSURE VESSELS AWAY FROM
HI-TEMPERATURES.
Other Precautions:AVOID UNNECESSARY EXPOSURE TO HALON 1211 ! ABOVE
4%(17 LBS/1000 CU FT AIR & >1 MIN:DIZZINESS,IMPAIRED COORDINATION &
REDUCED MENTAL ALERTNESS); ABOVE 5% CONC(22 LBS/1000 CU FT OF
AIR),USE AIR-SUPPLIED RESPIRATORS.

Respiratory Protection:NOT NORMALLY NECESSARY IF PROPER ENGINEERING
CONTRO+S ARE IN PLACE. IF PEL/TLV ARE EXCEEDED, USE POSITIVE
PRESSURE AIR SUPPLIED RESPIRATOR. REVIEW 29CFR1910.134
INSTRUCTION/WARNING AS WELL AS NIOSH-RE SPIRATOR DECISION LOGIC
PUB87.108.
Ventilation:PROVIDE SUFFICIENT GENERAL/LOCAL EXHAUST VENTILATION IN
PATTERN/VOLUME TO CONTROL INHALATION EXPOSURE BELOW PEL/TLV.
Protective Gloves:LINED BUTYL OR AS REQUIRED FOR TASK.
Eye Protection:CHEMICAL SPLASH TYPE OR AS REQ. FOR TASK
Other Protective Equipment:AS REQUIRED TO MINIMIZE EXPOSURE & MAXIMIZE
INDIVIDUAL INDIVIDUAL PROTECTION.
Work Hygienic Practices:OBSERVE PROCEDURES SET FORTH BY SAFETY/IH
PERSONNEL FOR USE OF THIS MATERIAL/FOR TASK AT HAND.
Supplemental Safety and Health
SMALL CONC( 5%) OF HALON EXTINGUISH FLAMES BY CHEMICALLY INTERRUPTING
COBUSTION-NOT BY REPLACING O*2. HOWEVER, VAPORIZATION OF EXCESSIVE
AMTS. CAN DEPLETE OR REPLACE OR REPLACE O*2 NEEDED FOR BREATHIN G;
GERNRIC 'MSDS' ON NSN IDENTIFIED BY "DCSC" NSN, THE GENERIC WILL BE
REMV.

HCC:G3
Boiling Pt:B.P. Text:26F/-3.3X
Melt/Freeze Pt:M.P/F.P Text:-257F/-161C
Decomp Temp:Decomp Text:N/LK
Vapor Pres:1897 @ 70F
Vapor Density:5.7
Spec Gravity:1.83
Evaporation Rate & Reference:RAPID; REFERENCE UNK.
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS LIQUIFIED GAS(SEE BOILING PT) W/SLIGHT
ETHEREAL ODOR.
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
ACTIVE METALS (EG, ALKALINE EARTH & ALKALINE EARTH METALS POWDERED AL,
ZN, BE, ETC.) & METAL HYDRIDES.
Stability Condition to Avoid:FLAMES HOT SURFACES >900F CAN CAUSE
DECOMPOSITION OF MATERIAL.
Hazardous Decomposition Products:AT HI-TEMPS(>900F) : HF, HBR, FREE BR,
POSSIBLE CARBONYL HALIDES, & OXIDES OF BROMING, FLUORINE, OR
CARBON.

Waste Disposal Methods:COMPLY W/ALL FEDERAL,STATE, & LOCAL REGULATIONS.
RECLAIM MATERIAL IN A SUITABLE VAPOR RECOVERY SYSTEM/EQUIPMENT.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.