BHCJM - AROMATIC NAPHTHA, TYPE I, GRADE A, TTN 97C

  • MSDS: BHCJM
  • Manufacturer: SOLVENTS AND CHEMICALS INC
  • Product Name: AROMATIC NAPHTHA, TYPE I, GRADE A, TTN 97C
  • National Stock Number: 6810-00-223-9073
Product Identification

Product ID:AROMATIC NAPHTHA, TYPE I, GRADE A, TTN 97C
MSDS Date:01/01/1988
FSC:6810
NIIN:00-223-9073
MSDS Number: BHCJM

Responsible Party
SOLVENTS AND CHEMICALS, INC.
4704 SHANK ROAD
PEARLAND, TX 77588-0490
US

Emergency Phone: 713-485-5377

Info Phone: 713-485-5377

Cage: 4W432

Contractor
SOLVENTS AND CHEMICALS, INC.
PEARLAND, TX 77588-0490 US

Telephone: 281-485-5377

Cage: 4W432

Ingredients

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS


NAPHTA (PETROLEUM SPIRITS OR BENZIN)

CAS: 8030-30-6

RTECS: VL8047000

OSHA PEL 100 PPM

Hazards

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:YES
Health Hazards Acute and Chronic:ACUTE: INHALATION OF VAPORS MAY BE
NARCOTIC OR ANESTHETIC. INGESTION OF LIQUID WILL CAUSE
GASTROINTESTINAL DISTRESS, IRRITATION, AND POSSIBLY NAUSEA. LIQUID
OR VAPORS MAY BE IRRITATING TO SKIN AND EYE S. CHRONIC: CANCER
SUSPECT AGENT, CONTAINS TOLUENE. KIDNEY AND LIVER DAMAGE POSSIBLE.
Explanation of Carcinogenicity:OSHA TABLE Z2
Effects of Overexposure:IRRITATION OF RESPIRATORY TRACT, NERVOUS SYSTEM
DEPRESSION, HEADACHES, DIZZINESS, STAGGERING GAIT, CONFUSION,
UNCONSCIOUSNESS, COMA. SKIN IRRITATION DEVELOPS SLOWLY AFTER
CONTACT, EYEE IRRITATION DEVE LOPS IMMEDIATELY UPON CONTACT.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF SKIN AND
RESPIRATORY DISORDERS MAY BE AT INCREASED RISK FROM EXPOSURE.

First Aid

First Aid:SKIN- WASH WITH SOAPY WATER. RINSE THOROUGHLY. SEE DR. IF
IRRITATION PERSISTS. EYE- FLUSH WITH LOTS OF CLEAN WATER FOR AT
LEAST 15 MINUTES. CONSULT A PHYSICIAN. INHALE- REMOVE TO FRESH AIR.
GIVE MOUTH TO MOUTH IF PERSON HAS STOPPED BREATHING. GET MEDICAL
ATTENTION. INGEST- DO NOT INDUCE VOMITING UNLESS DIRECTED TO BY
DR.. GUARD AGAINST ASPIRATION INTO LUNGS.

Fire Fighting

Flash Point:=6.7C, 44.F
Lower Limits:1
Upper Limits:8
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER
FOG/SPRAY.
Fire Fighting Procedures:DANGER! EXTREMELY FLAMMABLE. KEEP PEOPLE OUT
OF THE AREA. DO NOT ENTER THE FIRE AREA W/OUT FULL BUNKER
EQUI.INCLUDING NIOSH APPROVED SCBA. COOL CONTAINERS FIRST
Unusual Fire/Explosion Hazard:CONTAINERS MAY RUPTURE FROM INTERNAL
PRESSURE IF CONFINED TO FIRE AREA. COOL WITH WATER. GET
NON-ESSENTIAL PEOPLE OUT OF THE AREA.

Accidental Release

Spill Release Procedures:ABSORB SMALL SPILLS WITH VERMICULITE,
CLAY-BASED ABSORBENTS, ETC. LARGE SPILLS- STOP THE FLOW OF THE
LIQUID AT THE SOURCE. DIKE TO PREVENT FURTHER SPREAD AND TRANSFER
THE LIQUID AND ANY SPILL CLEAN-UP DEBRIS TO PROPER CONTAINERS.
Neutralizing Agent:NONE APPLICABLE FOR THIS MATERIAL

Handling

Handling and Storage Precautions:STORE IN COOL, DRY, WELL VENTILATED
AREA. PROTECT FROM PHYSICAL DAMAGE, HEAT AND IGNITION SOURCES. KEEP
CONTAINERS CLOSED.
Other Precautions:AVOID SKIN AND EYE CONTACT. AVOID INHALATION OF HIGH
CONCENTRATIONS OF VAPOR. REMOVE CONTAMINATED CLOTHING. WASH BEFORE
REUSE. DO NOT TAKE INTERNALLY. MARK STORAGE AREA AS FLAMMABLE
LIQUID STORAGE ARE A.

Exposure Controls

Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL (TLV), USE NIOSH/MSHA APPROVED RESPIRATOR AS
PER CURRENT 29 CFR 1910.134, INSTRUCTIONS/WARNINGS AND
NIOSH-RESPIRATOR SELECTION.
Ventilation:MECHANICAL (GENERAL) VENTILATION IS REQUIRED. LOCAL EXHAUST
MAY BE REQUIRED IF WORK AREA IS NOT VENTED.
Protective Gloves:SOLVENT RESISTANT
Eye Protection:CHEMICAL SAFETY GOGGLES
Other Protective Equipment:SAFETY SHOWER AND EYE BATH. OTHER EQUIPMENT
AS REQUIRED TO MINIMIZE EXPOSURE FROM PROLONGED OR REPEATED
CONTACT.
Work Hygienic Practices:WASH THROUGHLY AFTER HANDLING AND BEFORE
EATING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
DISPOSE OF CONTAMINATED SHOES, DO NOT REUSE.

Chemical Properties

HCC:F2
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:=115.6C, 240.F
Vapor Pres:35
Vapor Density:4.0
Spec Gravity:0.83
Evaporation Rate & Reference:1.5 (BUTYL ACETATE=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR SOLUTION WITH AROMATIC SOLVENT ODOR

Stability

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE

Disposal

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS. PRODUCT CONTAINS
FLAMMABLE OR COMBUSTIBLE SOLVENTS. INCINERATION OR SOLVENT
RECLAMATION MAY BE CONSIDERED AS POSSIBLE WASTE HANDLING METHODS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.