Product ID:4 1/2 LB CUT ORANGE BULLS EYE SHELLAC SOL
MSDS Date:01/08/1986
FSC:8010
NIIN:00-161-7278
MSDS Number: BHCYL

ZINSSER WILLIAM AND CO

39 BELMONT DR
SOMERSET, NJ 08873-1218
US

Emergency Phone: 201-469-8100

Info Phone: 201-469-8100

Cage: 3M602

ZINSSER WILLIAM AND CO

SOMERSET, NJ 08873-1218 US

Cage: 3M602

ETHYL ALCOHOL (ETHANOL)

CAS: 64-17-5

RTECS: KQ6300000

Fraction By Weight: 40-50%

OSHA PEL 1000 PPM

ACGIH TLV: 1000 PPM; 9192

ISOPROPYL ALCOHOL (SARA III)

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: < 10%

OSHA PEL 400 PPM/500 STEL

ACGIH TLV: 400 PPM/500STEL;9192

METHYL ALCOHOL (METHANOL) (SARA III)

CAS: 67-56-1

RTECS: PC1400000

Fraction By Weight: < 4%

OSHA PEL S,200PPM/250STEL

ACGIH TLV: S,200PPM/250STEL; 93

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:HIGH CONCENTRATION OF VAPOR MAY CAUSE
HEADACHE, DROWSINESS, NAUSEA AND DIZZINESS AS WELL AS IRRITATION OF
THE EYES AND RESPIRATORY TRACT. PROLONGED CONTACT WITH SKIN MAY
CAUSE IRRITATION. INGESTION CAN CAUSE NAUSEA AND VOMITING.
Explanation of Carcinogenicity:NONE OF THE CHEMICALS IN THIS PRODUCT
ARE LISTED AS POTENTIAL CARCINOGENS BY THE IARC, NTP OR OSHA.
Effects of Overexposure:HEADACHES, DIZZINESS, DROWSINESS, NAUSEA,
VOMITING, IRRITATION OF EYES OR RESPIRATORY TRACT.
Medical Cond Aggravated by Exposure:NONE KNOWN.

First Aid:EYES: IRRIGATE WITH COPIOUS AMOUNT OF CLEAN WATER FOR 15
MINUTES. SKIN: WASH SKIN WITH COOL WATER FOR 15 MINUTES.
INHALATION: MOVE TO FRESH AIR; MAINTAIN BREATHING. INGESTION: CALL
POISON CONTROL C ENTER IMMEDIATELY. GET MEDICAL ATTENTION
IMMEDIATELY FOR ANY OF THESE CONDITONS.

Flash Point Method:TCC
Flash Point:54F/12C
Lower Limits:3.3
Extinguishing Media:USE WATER FOG, ALCOHOL FOAM, CARBON DIOXIDE, OR DRY
CHEMICAL.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. PROVIDE
ADEQUATE VENTILATION OR USE RESPIRATORY PROTECTION IN CONDINED
AREA. CLEAN AREA WITH ABSORBENT MATERIAL, SAND OR RAGS.

Handling and Storage Precautions:STORE IN COOL PLACE, AWAY FROM
OXIDIZING AGENTS. USE ONLY WITH ADEQUATE VENTILATION. AVOID
BREATHING VAPOR OR SPRAY MIST& PROLONGED CONTACT WITH SKIN.
Other Precautions:KEEP OUT OF DIRECT SUNLIGHT. KEEP CONTAINER CLOSED.
DRUM SHOULD BE GROUNDED & BONDED WHEN POURING.

Respiratory Protection:IN CONFINED AREAS USE NIOSH/MSHA APPROVED
RESPIRATORY PROTECTION IN ACCORDANCE WITH 29CFR 1910.134.
RESPIRATORY PROTECTION MAY NOT BE REQUIRED IN WELL VENTILATED
AREAS.
Ventilation:EXPLOS-PROOF EXHAUST SYS TO KEEP CONCENTRATE OF VAPORS
BELOW TLV/PEL. EXHAUST VAPORS SHOULD BE VENTED TO NON-EXPLOS AREA
Protective Gloves:NEOPRENE.
Eye Protection:SAFETY GLASSES.
Other Protective Equipment:CLOTHING ADEQUATE TO PROTECT SKIN.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
PPE IS DEPENDENT ON THE CONDITION OF USE. USE PPE SUFFICIENT TO PREVENT
PROLONGED SKIN AND EYE CONTACT AND THE INHALATION OF VAPORS IN
POORLY VENTILATED OR CONFINED AREAS WHERE HIGH CONCENTRATIONS OF
VAPORS ARE LIKELY TO OCCUR.

Stability Indicator/Materials to Avoid:YES
WATER, ACID, OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS, AND OPEN FLAMES.
Hazardous Decomposition Products:CARBON MONOXIDE ON INCOMPLETE
COMBUSTION.
Conditions to Avoid Polymerization:HEAT, SPARKS, OPEN FLAME.

Waste Disposal Methods:DRIED SHELLAC CAN BE DISPOSED ON IN TRASH.
DISPOSE OF SOLUTION AS HAZARDOUS WASTE IN ACCORDANCE WITH LOCAL,
STATE OR FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.