Product ID:TT-P-11F WHITE TRAFFIC PAINT 500W29
MSDS Date:07/21/1989
FSC:8010
NIIN:00-900-2940
MSDS Number: BHDXS

GRIGGS PAINT

3602 SOUTH 16TH PLACE
PHOENIX, AZ 85040
US

Emergency Phone: 602-243-3293

Info Phone: 602-243-3293

Preparer: ROBERT COMMISSO

Cage: DO312

GRIGGS PAINT

PHOENIX, AZ 85040-1319 US

Telephone: 602-243-3293

Cage: DO312

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 5.97%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

NAPHTHA (PETROLEUM SPIRITS OR BENZIN)

CAS: 8030-30-6

RTECS: SE7555000

Fraction By Weight: <5%

OSHA PEL 100 PPM

XYLENES (O-,M-,P- ISOMERS) (SARA III)

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 0.19%

OSHA PEL 100 PPM/150 STEL

ACGIH TLV: 100 PPM/150STEL;9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

TITANIUM DIOXIDE

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 10 - 15%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9293

CHLORINATED RUBBER RESIN

Fraction By Weight: <5.0%

ACGIH TLV: ISHED

TALC (CONTAINING NO ASBESTOS)

CAS: 14807-96-6

RTECS: WW2710000

Fraction By Weight: 5.0%

OSHA PEL 2 MG/M3 RDUST

ACGIH TLV: 2 MG/M3 RDUST; 9192

METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)

CAS: 71-55-6

RTECS: KJ2975000

Fraction By Weight: 16.01%

OSHA PEL 350 PPM/450 STEL

ACGIH TLV: 350 PPM/450STEL;9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:YES
Effects of Overexposure:INHALATION:MAY CAUSE
DROWSINESS,DIZZINESS,FATIGUE,FOLLOWED BY COMA.SKIN:MAY CAUSE
IRRITATION,DERMATITIS,IF ABSORBED THROUGH SKIN CAN CAUSE MODERATE
IRRITA- TION,DEFATTING,DERMATITIS.EYES:MAY CAUSE
IRRITATION.INGESTION:MAY CAUSE GASTRO-INTESTINAL
DISTURBANCES.ASPIRATION MAY CAUSE
PNEUMONITIS,PULM.EDEMA,HEMORRHAGE.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING
DISEASES IN OR HIS- TORY OF AILMENTS INVOLVING SKIN, CENTRAL
NERVOUS SYSTEM, LIVER AND KIDNEY.

First Aid:EYES: IMMEDIATELY FLUSH WITH LARGE AMOUNTS OF WATER FOR 15
MINUTES. SEEK MEDI-CAL AID. SKIN: WASH THOROUGHLY WITH SOAP AND
WATER. SEEK MEDICAL AID IF IRRI-TATION PERSISTS. INGESTION:
IMMEDIATELY SEEK MEDICAL AID. DO NOT INDUCE VOMIT-ING. DO NOT
ATTEMPT TO GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.

Flash Point Method:TCC
Flash Point:45F/7C
Lower Limits:NA
Upper Limits:1.0
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:APPROVED GAS MASK REQUIRED FOR FIRE FIGHTING
PERSONNEL.WATER MAY BE INEFFECTIVE.WATER MAY BE USED TO COOL
CONTAINERS.IF WATER IS USED,FOG NOZZLES ARE PREFERRED.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, ELECTRICAL EQUIPMENT, SPARKSAND OPEN FLAME. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO HEAT.

Spill Release Procedures:STOP LEAK IF NO RISK INVOLVED. REMOVE ALL
SOURCESOF IGNITION. STAY UPWIND. ABSORB WITH INERT MAT-ERIAL,
FLUSH AREA WITH WATER. VENTILATE AREA FOR AT LEAST 24 HOURS OR
UNTIL AREA HAS BEEN DECLARED SAFE.

Handling and Storage Precautions:KEEP CNTNRS CLOSED AND UPRIGHT TO
PREVENT LEAKAGE.AVOID FLAMES,WELDING,OPEN LIGHTS,ETC.AVOID
BREATH-ING OF VAPOR/SPRAY MIST.AVOID SKIN/EYE CONTACT.
Other Precautions:MAINTAIN GOOD PERSONAL HYGIENE. DO NOT USE IN
CONFINED AREAS, TANK OR PIT, WITHOUT ADEQUATE VENTILATION.

Respiratory Protection:IF VENTILTN DOESN'T MAINTAIN INHALATION
EXPOSURES BELOW TLV(PEL),USE MSHA/NIOSH APPROVED UNITS. USE UNITS
PER CURRENT 29 CFR1918.134 AND FOLLOW MANUFACTURERS INST/WARNINGS.
IF W/IN OSHA PROT, FACTO R, AIR PURIFYING OV/FILTER UNITS ARE OK.
Ventilation:LOCAL AND MECHANICAL EXHAUST
Protective Gloves:RUBBER GLOVES
Eye Protection:SAFETY GLASSES W/SIDE SHIELDS OR GOGGLES
Other Protective Equipment:EYE BATH AND SAFETY SHOWER
Work Hygienic Practices:MAINTAIN GOOD PERSONAL HYGIENE. DO NOT USE IN
CONFINED AREAS WITHOUT ADEQUATE VENTILATION.
Supplemental Safety and Health
NK

Boiling Pt:B.P. Text:170-280F
Vapor Density:>AIR
Spec Gravity:1.7
Viscosity:70-80 KU
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:ESSENTIALLY NIL
Appearance and Odor:WHITE,VISCOUS LIQUID WITH TYPICAL PAINT ODOR
Percent Volatiles by Volume:47

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:FLAMES, SPARKS, SMOKING AND HEAT.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE.

Waste Disposal Methods:USE INERT ABSORBENT MATERIALS ON SPILLS.
DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE AND
LOCALREGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.