Product ID:TT-P-85E TYPE I WHITE 500W27
MSDS Date:01/01/1987
FSC:8010
NIIN:00-926-2043
MSDS Number: BHDYP

GRIGGS PAINT

3602 SOUTH 16TH PLACE
PHOENIX, AZ 85040
US

Emergency Phone: 602-243-3293

Info Phone: 602-243-3293

Preparer: ROBERT COMMISSO

Cage: DO312

GRIGGS PAINT

PHOENIX, AZ 85040-1319 US

Telephone: 602-243-3293

Cage: DO312

XYLENES (O-,M-,P- ISOMERS) (SARA III)

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 0.23%

OSHA PEL 100 PPM/150 STEL

ACGIH TLV: 100 PPM/150STEL;9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 1.90%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

NAPHTHA (PETROLEUM SPIRITS OR BENZIN)

CAS: 8030-30-6

RTECS: SE7555000

Fraction By Weight: 20%

OSHA PEL 100 PPM

TITANIUM DIOXIDE

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 20 - 25%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9293

TALC (CONTAINING NO ASBESTOS)

CAS: 14807-96-6

RTECS: WW2710000

Fraction By Weight: 5%

OSHA PEL 2 MG/M3 RDUST

ACGIH TLV: 2 MG/M3 RDUST; 9192

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:YES
Health Hazards Acute and Chronic:EYES: IRRI. PROLONGED/REPEATED CONTACT
MAY CAUSE SKIN IRRI. INHAL OF HIGH CONCENOF VAPORS MAY LEAD TO LUNG
CHANGES, NAUSEA, VOMIT, COUGH, PULMONARY IRRI, & CENTRAL NERVOUS
SYSTEM DEPRESSION. INGESTION : GASTROINTESTINAL DISTURBANCES.
ASPIRATION INTO LUNGS MAY CAUSE PNEUMONITIS, PULMONARY EDEMA &
HEMORRAGE
Effects of Overexposure:INHAL: DROWSINESS, DIZZINESS, FATIGUE, FOLLOWED
BY COMA. EYE: IRRI. SKIN: PROLONGED/REPEATED CONTACT, IRRI,
DERMITITS, ABSORBED THROUGH SKIN-MODERATE IRRI, DEFATTING &
DERMITITIS. INGESTION: ASPIRATIO N INTO LUNGS MAY CAUSE
PNEUMONTITIS, PULMONARY, EDEMA & HEMORRAGE, GASTROINTESTINAL
DISTURBANCES
Medical Cond Aggravated by Exposure:INDIVIDUALS W/PRE-EXISTING DISEASES
IN OR HISTORY OF AILMENTS INVOLVING SKIN CENTRAL NERVOUS
SYSTEM,LIVER AND KIDNEY

First Aid:EYE: IMMED FLUSH W/LARGE AMTS OF WTR FOR 15 MIN. SEEK MED
AID. SKIN: WASH THROUGHLY W/SOAP & WTR. SEEK MED AID IF IRRI
PERSISTS. INGESTION: IMMED SEEK MED AID. DO NOT INDUCE VOMITING.
AND DO NOT ATTEM PT TO GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON.

Flash Point Method:TCC
Flash Point:45 F 7 C
Lower Limits:NA
Upper Limits:1.0
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG
Fire Fighting Procedures:APPROVED GAS MASK REQUIRED FOR FIRE FIGHTING
PERSONEL. WTR MAY BE INEFFECTIVE. WTR MAY BE USED TO COOL
CONTAINERS. IF WTR IS USED, FOG NOZZLES ARE PREFERRED
Unusual Fire/Explosion Hazard:KEEP CONTAINER TIGHTLY CLOSED. ISOLATE
FROM HEAT, ELECTRICAL EQUIP, SPARKS, AND OPEN FLAME. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO HEAT.

Spill Release Procedures:STOP LEAK IF NO RISK INVOLVED. REMOVE ALL
SOURCES OF IGNITION. STAY UPWIND. ABSORB W/INERT MATERIAL.FLUSH
AREA W/WATER. VENTILATE AREA FOR AT LEAST 24HOURS OR UNTIL AREA HAS
BEEN DECLARED SAFE

Handling and Storage Precautions:KEEP CONTAINERS CLOSED & UPRIGHT.
AVOID FLAMES, WELDING OPEN LIGHTS, ETC. AVOID BREATHING OF VAPOR
&SPRAY MIST. AVOID SKIN/EYE CONTACT
Other Precautions:MAINTAIN GOOD PERSONAL HYGIENE. DO NOT USE IN
CONFINED AREAS, TANK OR PIT, WITHOUT ADEQUATE VENTILATION

Respiratory Protection:IF VENT DOES NOT MAINTAIN INHAL EXPOSURES BELOW
TLV(PEL), USE MSHA/NIOSH APPROVED UNITS. USE UNITS PER CURRENT 29
CFR1910.134 & FOLLOW MANUFACTURERS' INSTRUCTIONS & WARNINGS. IF
WITHIN OSHA PROTECTION FACTOR, AIR PURIFYING OV/FILTER UNIT OK
Ventilation:LOCAL & MECHANICAL EXHAUST
Protective Gloves:RUBBER GLOVES
Eye Protection:SAFETY GLASSES WITH SIDE SHIELDS/GOGGLES
Other Protective Equipment:EYE BATH AND SAFETY SHOWER
Work Hygienic Practices:MAINTAIN GOOD PERSONAL HYGIENE. DO NOT USE IN
CONFINED AREASWITHOUT ADEQUATE VENTILATION.
Supplemental Safety and Health
NK

Boiling Pt:B.P. Text:230-280 F
Vapor Density:> AIR
Spec Gravity:1.5
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:ESSENTIALLY NIL
Appearance and Odor:WHITE VISCOUS LIQUID WITH TYPICAL PAINT ODOR
Percent Volatiles by Volume:53.7

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:FLAMES, SPARKS, SMOKING AND HEAT
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE

Waste Disposal Methods:USE INERT ABSORBENT MATERIALS ON SPILLS. DISPOSE
OF IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.