Product ID:CUT WRITE/ORANGE BULLS EYE SHELLAC SOLUTION
MSDS Date:01/08/1987
FSC:8010
NIIN:01-070-4549
MSDS Number: BHFDJ

WILLIAM ZINSSER & CO., INC.

39 BELMONT DRIVE
SOMERSET, NJ 08873
US

Emergency Phone: 201-469-8100

Info Phone: 201-469-8100

Cage: FO649

ZINSSER WILLIAM AND CO

SOMERSET, NJ 08873-1218 US

Telephone: (201) 469-8100

Cage: 3M602

ETHYL ALCOHOL

CAS: 64-17-5

Fraction By Weight: 50-60%

OSHA PEL 1000 PPM

ACGIH TLV: 1000 PPM

ISOPROPYL ALCOHOL (SARA III)

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: <10%

OSHA PEL 400 PPM/500 STEL

ACGIH TLV: 400 PPM/500STEL;9192

METHYL ALCOHOL (METHANOL) (SARA III)

CAS: 67-56-1

RTECS: PC1400000

Fraction By Weight: <4%

OSHA PEL S,200PPM/250STEL

ACGIH TLV: S,200PPM/250STEL; 93

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Effects of Overexposure:EFFECTS HIGH CONCENTRATION OF VAPOR MAY CAUSE
HEADACHE, DROWSINESS, NAUSEA & DI-ZZINESS AS WELL AS IRRITATION OF
THE EYES & RESPIRATORY TRACT. PROLONGED CONTACTWITH SKIN MAY CAUSE
IRRITTION. INGESTION CAN CAUSE NAUSEA AND VOMITING

First Aid:EYES: IRRIGATE WITH COPIOUS AMOUNT OF CLEAN WATER FOR 15 MIN.
OBTAIN MED. ATTN SKIN: WASH SKIN WITH COOL WATER. INHALATION: MOVE
SUBJECT TO FRESH AIR; MAITAIN BREATHING; OBTAIN MED. ATTN.
IMMEDIATELY AND INGESTION: CALL PHYSICIAN OR POISONCONTORL CENTER
IMMEDIATELY.

Flash Point:54 F 12.22 C
Upper Limits:3.3
Extinguishing Media:ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG, SAND

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. PROVIDE
ADEQUATE VENTILATION OR USE RESPIRATORY PROTECTION IN CON- FINED
AREA. CLEAN AREA WITH ABSORBENT MATERIAL, SAND OR RAGS.

Handling and Storage Precautions:IN COOL PLACE AWAY FROM HIGH HEAT,
OPEN FAMES, SPARKS & OXIDIXING AGENTS. USE ONLY WITH ADEQUATE
VENTILATION. AVOID LONG PROLONG BREATHING/SKIN CONTAC
Other Precautions:DO NOT TAKE INTERNALLY. KEEP OUT OF DIRECT SUNLIGHT.
KEEP CONTAINER CLOSED. DRUMSHOULD BE GROUNDED AND BONDED WHEN
POURING

Respiratory Protection:NONE REQUIRED IN VENTILATED AREAS. CONFINED
AREAS WHERE HIGH VAPOR CONCENTRAT- IONS ARE EXPECTED, USE
NIOSH/MSHA APPROVED RESPIRATORY PROTECTION IN ACCORDANCE WITH 29CFR
1910.134
Ventilation:EXPLOSION PROOF EXHAUST SYSTEM SUITABLE TO MAINTAIN CONCEN-
TRATION OF VAPORS. SHOULD BE VENTILATED TO NONEXPLOSIVE AREA
Protective Gloves:FOR PROLONGED CONTACT
Eye Protection:SAFETY GLASSES
Other Protective Equipment:CLOTHING ADEQUATE TO PROTECT SKIN
Work Hygienic Practices:WASH HANDS AFTER USING
Supplemental Safety and Health
NK

Boiling Pt:B.P. Text:173 F
Vapor Density:> THAN AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:BEIGE OR ORANGE LIQUID WITH ALCOHOL ODOR
Percent Volatiles by Volume:77

Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, CONDITIONS TO AVOID: HEAT, SPARKS, OPEN FLAME
Hazardous Decomposition Products:CARBON MONOXIDE ON INCOMPLETE
COMBUSTION

Waste Disposal Methods:DRIED SHELLAC CAN BE DISPOSED OF IN TRASH.
DISPOSEOF SOLUTION IN ACCORDANCE WITH LOCAL, STATE AND/ORFEDERAL
REGULATIONS

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.