Product ID:SPEC,A PORCELAIN AND ENAMEL CLEANER
MSDS Date:12/01/1985
FSC:7930
NIIN:00N010018
MSDS Number: BHTYN

STATE CHEMICAL MANUFACTURING CO.

3100 HAMILTON AVENUE
CLEVELAND, OH 44114

Emergency Phone: 216-861-7114

Info Phone: 216-861-7114

Cage: 53798

STATE CHEMICAL MANUFACTURING CO.

CLEVELAND, OH 44114-3701 US

Telephone: 216-861-7114

Cage: 53798

HYDROGEN CHLORIDE (HYDROCHLORIC ACID) (SARA III)

CAS: 7647-01-0

RTECS: MW4025000

Fraction By Weight: <7%

OSHA PEL C 5 PPM

ACGIH TLV: C 5 PPM; 9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

LD50 LC50 Mixture:N/K
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:DANGER:CONTAINS HYDROCHLORIC ACID.MAY
BE HARMFUL IF SWALLOWED.REPEATED OR PROLONGED EXPOSURE MAY CAUSE
EROSION OF THE TEETH.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:POSS CHEM BURNS.AVOID CONTACT.SKIN:POSS
CHEM BURNS.AVOID CONTACT.REPEATED EXPOSURE MAY CAUSE SKIN
RASH.INGESTION:MAY BE HARMFUL IF SWALLOWED.POSS CHEM
BURNS.INHALATION:DO NOT BREATHE VAPOR OR FUM ES.POSS CHEM
BURNS.REPEATED OR PROLONGED EXPOSURE MAY CAUSE EROSION OF TEETH.
Medical Cond Aggravated by Exposure:N/K

First Aid:EYES:IMMED FLUSH W/ LOTS OF COOL H*2O FOR AT LEAST 15 MIN.GET
PROMPT MED ATTN.DO NOT WEAR CONT LENSES.SKIN:WIPE OFF GENTLY.IMMED
FLOOD W/ H*2O USING SOAP FREELY,THEN COVER W/ MOIST MAGNESIA OR
BAKING SODA.CONT MD IF IRRIT PERSISTS.INGEST:CONT MD IMMED.DRINK 1
TSP OR MORE MILK OF MAGNESIA OR SOAPY H*2O FOLLOWED W/ MILK OR RAW
EGG WHITES.DO NOT INDUCE VOMIT.INHAL:REMOVE TO FRESH AIR. (SEE SUPP
DATA)

Flash Point Method:TCC
Flash Point:NONE
Lower Limits:N/K
Upper Limits:N/K
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION MAY RESULT IN
FORMATION OF HYDROGEN CHLORIDE GAS.

Spill Release Procedures:DIKE SPILL AREA.NEUTRALIZE WITH SODA ASH OR
OTHER WEAK ALKALI.ABSORB LIQUID ON STATE OIL ABSORBENT
COMPOUND,SAND OR VERMICULITE.FLUSH ANY RESIDUES WITH LARGE VOLUMES
OF WATER TO THE DRAIN.
Neutralizing Agent:SODA ASH OR OTHER WEAK ALKALI.

Handling and Storage Precautions:STORE ONLY IN COOL,DRY,WELL VENT
AREA.KEEP CONTR TIGHTLY CLSD WHEN NOT IN USE.WARNING:CONTAINS
HYDROCHLORIC ACID.POSS CHEM BURNS.POSS (SEE SUPP DATA)
Other Precautions:IMMED RINSE CLOTHS,SWABS OR BRUSHES AFTER USE.READ &
FOLLOW ALL LABEL DIRECTIONS & PREC BEFORE USE.INTENDED FOR
INDUSTRIAL USE ONLY.KEEP OUT OF THE REACH OF CHILDREN.

Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .AVOID BREATHING FUMES OR VAPORS OF THIS
PRODUCT.
Ventilation:LOCAL AND GENERAL VENTILATION NECESSARY TO KEEP AIR
CONCENTRATION BELOW TLV .
Protective Gloves:REQUIRED
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:COOL,CLEAN H*2O SOURCE NEAR IN CASE OF
ACCIDENTAL CONT.EMER EYE WASH & DELUGE SHOWER IN CLOSE PROXIMITY TO
AREA OF USE.
Work Hygienic Practices:DO NOT WEAR CONTACT LENSES WHILE WORKING WITH
THIS PRODUCT.
Supplemental Safety and Health
% VOLATILES BY WEIGHT:>90.FIRST AID PROC:IF DIFFICULTY IN BREATHING OR
OTHER IRRITATION PERSISTS,CONTACT MD.HNDLG/STOR PREC:HARMFUL IF
SWALLOWED.DO NOT BREATHE VAP OR FUMES.AVOID DIRECT CONTACT W/ EYE S
OR SKIN.

Boiling Pt:B.P. Text:200-220F
Melt/Freeze Pt:M.P/F.P Text:N/K
Decomp Temp:Decomp Text:N/K
Vapor Pres:N/K
Vapor Density:N/K
Spec Gravity:1.04 (WATER=1)
pH:<2
Evaporation Rate & Reference:N/K
Solubility in Water:COMPLETE
Appearance and Odor:AN OPAQUE PINK EMULSION WITH A MILD PERFUME ODOR.

Stability Indicator/Materials to Avoid:YES
DO NOT MIX WITH ANY OTHER COMPOUND.
Stability Condition to Avoid:AVOID SPLASHING ON NYLON OR COTTON.
Hazardous Decomposition Products:THERMAL DECOMPOSITION OF THIS PRODUCT
MAY RESULT IN FORMATION OF HYDROGEN CHLORIDE GAS.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH
FEDERAL,STATE AND LOCAL REGULATIONS .DO NOT REUSE EMPTY CONTAINERS
FOR ANY PURPOSE.FLUSH THOROUGHLY WITH WATER.CRUSH OR PERFORATE AND
DISCARD OR GIVE TRIPLE-R INSED DRUMS TO A DRUM RECONDITIONER
FORRECYCLING.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.