Product ID:BLACK CONDUCTIVE COATING, 463060014
MSDS Date:04/10/1989
FSC:1615
NIIN:01-087-1397
Kit Part:Y
MSDS Number: BJFRM

AKZO COATINGS INC

434 W MEATS AVE
ORANGE, CA 92665
US

Emergency Phone: 15P.M.)

Info Phone: 213-855-7313 (AFTER HOURS)

Cage: 98502

BOEING HELICOPTERS, DIV OF THE BOEING CO

RIDLEY PARK, PA 19078 US

Telephone: 215-591-3010

Cage: 77272

N-BUTYL ALCOHOL (SARA III)

CAS: 71-36-3

RTECS: EO1400000

Fraction By Weight: 2.5%

OSHA PEL 100 PPM

ACGIH TLV: S, C 50 PPM; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

CARBON BLACK

CAS: 1333-86-4

RTECS: FF5800000

Fraction By Weight: 5-20%

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3; 9192

CYCLOHEXANONE (SARA III)

CAS: 108-94-1

RTECS: GW1050000

Fraction By Weight: <5%

OSHA PEL S, 50 PPM

ACGIH TLV: S, 25 PPM; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

CALCIUM CHROMATE (SARA III)

CAS: 13765-19-0

RTECS: GB2750000

Fraction By Weight: 8.8%

OSHA PEL 0.05 MG CR/M3

ACGIH TLV: 0.001 MG/M3;A2, 9394

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 31.3%

OSHA PEL 200 PPM/300 STEL

ACGIH TLV: 200 PPM/300STEL 9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

METHYL ISOBUTYL KETONE (SARA III)

CAS: 108-10-1

RTECS: SA9275000

Fraction By Weight: 5.9%

OSHA PEL 100 PPM/75 STEL

ACGIH TLV: 50 PPM/75 STEL; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

XYLENES (O-,M-,P- ISOMERS) (SARA III)

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 22.6%

OSHA PEL 100 PPM/150 STEL

ACGIH TLV: 100 PPM/150STEL;9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE IRRIT,CNTCT MAY CAUSE EYE
BURNS/CORNEAL INJURY,SEVERE IRRIT,REDNESS,TEARING,BLURRED
VIS.EXCESSIVE INHAL VAP CAN CAUSE NASAL/RESP
IRRIT,DIZZ,WEAKNESS,FATIGUE,NAUSEA,HDACHE,SHORTNESS OF BRTH,P OSS
UNCON,& ASPHY.MILD SKIN IRRIT,MAY CAUSE BURNS.INGEST:GI
IRRIT,NAUSEA,VOMIT,DIARRHEA,DEPRESS.(SEE SIGNS & SYMPTOMS)
Explanation of Carcinogenicity:INGRED #4:LISTED BY IARC/NTP AS HUMAN
CARCIN.ACGIH RECOM HNDLNG AS POTNTL HUMAN CARCIN.IARC LIST INGRED
#2 AS CARCIN.
Effects of Overexposure:DRY PIGMNT MAY CAUSE NUISANCE DUST,CAN BE IRRIT
TO RESP SYS.VAP & FUMES MAY BE IRRIT TO UPPER RESP TRACT.CAN BE
ABSORBED THROUGH SKIN,ASPIRATION INTO LUNGS CAN CAUSE CHEM PNEUM &
CAN BE FATAL.CHRONIC: EYE DAMAGE.LIVER & KIDNEY DAMAGE.CARDIAC
ABNORMALITIES.ANEMIC CONDITION.
Medical Cond Aggravated by Exposure:NONE EXPECTED.

First Aid:INHAL:MOVE TO FRESH AIR, GIVE ART RESP IF NECESSARY.
SKIN:WASH W/SOAP & WATER. EYE:FLUSH W/WATER AT LEAST 15 MIN, GET
MD. INGEST:DRINK ONE OR TWO GLASSES OF WATER TO DILUTE. DO NOT
INDUCE VOMIT. GET M D OR POISON CONTROL CENTER IMMEDIATELY.TREAT
SYMPTOMATICALLY.

Flash Point Method:TCC
Flash Point:23.0F,-5.0C
Lower Limits:1.0
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICALS
Fire Fighting Procedures:WATER MAY BE INEFCTIVE.WATER SHOULD BE USED TO
COOL CONTRS EXPSD TO FIRE.FIRE FIGHTING PERSONNEL SHOULD WEAR
NIOSH/MSHA APPROVED SCBA AND FULL PROT EQUIPMENT.
Unusual Fire/Explosion Hazard:KEEP CONTRS TIGHTLY
CLSD.ISOLATE/HEAT,SPRKS,ELEC EQUIP & OPEN FLAME.CLOSED CONTRS MAY
EXPLODE WHEN EXPSD TO EXTREME HEAT.DECOMP PROD MAY CAUSE HEALTH
HAZARD.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. AVOID
BREATHING VAPORS. VENTILATE AREA. REMOVE WITH INERT ABSORBENT.
REFER TO PROTECTIVE MEASURES LISTED THROUGHOUT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE CONTRS OUT OF SUN & AWAY FROM
HEAT,SPARKS & OPEN FLAMES. CLOSE CONTRS AFTER EACH USE. CONSULT
NFPA CODE FOR ADDITIONAL STORAGE REQUIREMENTS.
Other Precautions:DO NOT TAKE INTERNALLY.USE APPROVED BONDING &
GROUNDING PROCEDURES.OBSERVE LABEL PRECAUTIONS.KEEP CLOSURES TIGHT
AND CONTR UPRIGHT TO PREVENT LEAKAGE.NEVER USE PRESSURE TO
EMPTY.AVOID BREATHING DUST.D O NOT WELD OR FLAME CUT EMPTY DRUM.

Respiratory Protection:ADEQUATE VENTILATION IS REQUIRED.USE NIOSH/MSHA
APPROVED RESPIRATOR DEVICE.SEE SAFETY EQUIP SUPPLIER FOR EVALUATION
& RECOMMENDATION.IN CONFINED AREAS, USE NIOSH/MSHA APPROVED AIRLINE
RESPIRATOR OR HO OD.
Ventilation:SUFFICIENT TO KEEP VAP CONC BELOW TLV & LEL.FOR BAKING
FINISHES,EXHAUST VAPORS.REMOVE DECOMP PROD FORMED DURING WELDING.
Protective Gloves:REFER TO SAFETY EQUIPMENT SUPPLIER.
Eye Protection:CHEM WORKERS GOGG,FACESHIELD OPTL.
Other Protective Equipment:EYE BATH & SHOWER.CHEM RESISTANT APRON,BOOTS
OR OTHER CLOTHING TO AVOID REPEATED OR FREQUENT SKIN CONTACT.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING OR USING
WASHROOM.
Supplemental Safety and Health
INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING & INHALING THE
CONTENTS MAY BE HARMFUL OR FATAL.REPORTS HAVE ASSOCIATED REPEATED &
PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS W/PERMANENT BRAIN &
NERVOUS SYSTEM DAMAGE.DO NOT HANDLE UNTIL MANUFACTURERS SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD.

Boiling Pt:B.P. Text:175F,79C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:0.986
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:LIQUID, PAINT
Percent Volatiles by Volume:78.8

Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
SMOKE, OXIDES OF NITROGEN.

Waste Disposal Methods:INCINERATE IN AN APPROVED FACILITY, DO NOT
INCINERATE CLOSED CONTAINERS. DISPOSE I/A/W FEDERAL, STATE AND
LOCAL POLLUTION CONTROL REQUIREMENTS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.