Product ID:DAPCOTAC#3300
MSDS Date:01/01/1987
FSC:6850
NIIN:01-169-5796
Kit Part:Y
MSDS Number: BJMJL

D AIRCRAFT PRODUCTS COMPANY

1191 HAWK CIRCLE
ANAHEIM, CA 92807
US

Emergency Phone: 714-632-8444

Info Phone: 714-632-8444

Cage: 58093

D AIRCRAFT PRODUCTS CO

ANAHEIM, CA 92708 US

Telephone: 714-632-8444

Cage: 58093

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 65%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

CONTENT IS 500 GRAMS/LITER.

RTECS: 9999999VO

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:N/K
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF SWALLOWED.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES:IRRITATION.SKIN:CAUSES DRYING OF THE
SKIN.INGESTION:HARMFUL IF SWALLOWED.CAUSES VOMITING,NAUSEA AND
DIARRHEA.INHALATION:CAUSES HEADACHE,DIZZINESS,NAUSEA AND
INCOORDINATION.
Medical Cond Aggravated by Exposure:RESPIRATORY,LIVER,KIDNEY,DERMAL
AILMENTS,ALCOHOL CONSUMPTION PROBLEMS.

First Aid:EYES/SKIN:FLUSH WITH PLENTY OF WATER,MIN 15 MINUTES.GET
MEDICAL ATTENTION.INGESTION:DO NOT INDUCE VOMITING.GIVE A LOT OF
WATER.GET MEDICAL HELP.INHALATION:REMOVE TO FRESH AIR.GET MEDICAL
HELP.

Flash Point Method:TCC
Flash Point:35F,1.67C
Lower Limits:1.2
Upper Limits:7.0
Extinguishing Media:USE FOAM,CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:A STRAIGHT WATER STREAM WOULD SPREAD
HYDROCARBON FIRES.SELF-CONTAINED BREATHING APPARATUS SHOULD BE
USED.
Unusual Fire/Explosion Hazard:A VAPOR ACCUMULATION WOULD FLASH OR
EXPLODE IF IGNITED.HAZARDOUS DECOMPOSITION PRODUCTS:CARBON
MONOXIDE,CARBON DIOXIDE AND SILICONE DIOXIDE.

Spill Release Procedures:WIPE,SCRAPE OR SOAK UP IN AN INERT MATERIAL
AND PUT IN A CONTAINER FOR DISPOSAL.REMOVE ALL SOURCES OF
FLAME.INCREASE THE VENTILATION IN THE AREA.
Neutralizing Agent:N/K

Handling and Storage Precautions:USE GROUND STRAP.STORE UPRIGHT IN
CLOSED CONTAINERS IN COOL,DRY PLACE.
Other Precautions:USE ONLY IN WELL VENTILATED AREA.DO NOT INHALE
VAPORS.

Respiratory Protection:USE NIOSH APPROVED RESPIRATORY PROTECTION IF TLV
IS EXCEEDED.
Ventilation:LOCAL EXHAUST VENTILATION IS SATISFACTORY.MECHANICAL
(GENERAL) IS RECOMENDED.
Protective Gloves:RUBBER
Eye Protection:CHEMICAL SAFETY GOGGLES.
Other Protective Equipment:RUBBER APRON.
Work Hygienic Practices:EXERCISE GOOD INDUSTRIAL HOUSEKEEPING
PRACTICES.
Supplemental Safety and Health
SPECIFIC GRAVITY:0.9-1.0 (WATER=1).ROUTES OF ENTRY:EYES (MFR).

Boiling Pt:B.P. Text:230F,110C
Decomp Temp:Decomp Text:N/K
Vapor Pres:22 MMHG
Vapor Density:3.2,AIR=1
Spec Gravity:SEE SUPP DATA
Evaporation Rate & Reference:>1.0 (BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR,LOW VISCOSITY LIQUID WITH AROMATIC ODOR.

Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS.
Stability Condition to Avoid:KEEP AWAY FROM HEAT,SPARKS AND FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE,CARBON
DIOXIDE,SILICONE DIOXIDE.

Waste Disposal Methods:DISPOSAL MUST BE IAW FEDERAL,STATE,& LOCAL
REGS.COORDINATION W/ SUPPORTING INSTALLATION/MACOM ENVIRONMENTAL
COORDINATION PRIOR TO DISP IS RECOMMENDED TO DETERMINE APPROP DISP
METHOD .DISP OF AS SOLVENT BASED MATERIAL.TOLUENE IS SARA LISTED.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.