Product ID:24C 9M3D
MSDS Date:01/01/1987
FSC:6140
NIIN:00-538-9986
MSDS Number: BJXYQ

CONCORDE BATTERY CORP

2009 SAN BERNARDINO RD
WEST COVINA, CA 91790-1006
US

Emergency Phone: 213-962-4006

Info Phone: 213-962-4006

Cage: 63017

CONCORDE BATTERY CORP

WEST COVINA, CA 91790-1006 US

Telephone: 800-255-3924/818-813-1234

Cage: 63017

LEAD OXIDE

CAS: 1317-36-8

RTECS: OG1750000

Fraction By Weight: 60%

LEAD (SARA III)

CAS: 7439-92-1

RTECS: OF7525000

Fraction By Weight: 38%

OSHA PEL 0.05 MG/M3;1910.1025

ACGIH TLV: 0.15 MG/M3;DUST 9192

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

SULFURIC ACID (SARA III)

CAS: 7664-93-9

RTECS: WS5600000

Fraction By Weight: 2%

OSHA PEL 1 MG/M3

ACGIH TLV: 1 MG/M3; 9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

LD50 LC50 Mixture:ORAL RAT LD50 IS NOT KNOWN
Routes of Entry: Inhalation:NO Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:SEE SUPP. DATA. PRODUCT CONTAINS LEAD
AND SULFURIC ACID. SULFURIC ACID IS A CORROSIVE CAUSING BURNS TO
BODY TISSUES. LEAD IS TOXIC AND SOME LEAD COMPOUNDS ARE LISTED AS
CARCINOGENIC. CONTACT WITH E ITHER IS HIGHLY UNLIKELY TO OCCUR
UNLESSTHE CASE IS BROKEN OR SPILLED, THEN ONLY CONTACT WITH THE
ACID IS LIKELY.
Explanation of Carcinogenicity:LEAD COMPOUNDS ARE LISTED AS
CARCINOGENIC IN ANIMALS AND POSSILBY IN HUMANS.
Effects of Overexposure:CONTACT WITH SULFURIC ACID IS THE MOST LIKELY
EXPOSURE, PRODUCING IRRITATION OR BURNS TO THE BODY TISSUE
CONTACTED.
Medical Cond Aggravated by Exposure:NONE

First Aid:FIRST AID IS GIVEN FOR SULFURIC ACID CONTACT. EYE:FLUSH
W/WATER 15 MIN, HOLD LIDS OPEN. SKIN:WASH WITH SOAP & WATER.
REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE REUSE.
INHALED:REMOVE TO FRESH A IR. INGESTED:DO NOT INDUCE VOMITING.
GIVE 2 LARGE GLASSES OF MILK OR WATER AND GET IMMEDIATE MEDICAL
CARE. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. IF IRRITATION
PERSISTS OR IS SEVERE,SEE A DOCTOR.

Flash Point:NON-FLAMMABLE
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL. USE WATER WITH CARE AS MOLTEN LEAD MAY SPATTER WITH
WATER.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.

Spill Release Procedures:IF ACID IS SPILLED, NEUTRALIZE. PLACE
REMAINDER IN AN ACID RESISTANT CONTAINER FOR RECYCLE OF THE LEAD.
Neutralizing Agent:SODIUM BICARBONATE OR LIME

Handling and Storage Precautions:STORE IN COOL, DRY AREA. PROTECT FROM
PHYSICAL DAMAGE. PROTECT TERMINALS FROM SHORT CIRCUITS.
Other Precautions:READ MANUFACTURERS LITERATURE AND FOLLOW
INSTRUCTIONS. WEAR RUBBER OR PLASTIC APRON, GLOVES, BOOTS,AND FACE
SHIELD WHEN HANDLING ACID.

Respiratory Protection:RESPIRATOR WILL NOT NORMALLY BE NECESSARY. USE
NIOSH/MSHA APPROVED RESPIRATOR FOR ACID DUST/MIST IF EXPOSURE IS
ABOVE THE TLV/PEL. SEE 29 CFR 1910.134 FOR REGULATIONS PERTAINING
TO RESPIRATOR USE.
Ventilation:NOT NORMALLY REQUIRED. USE LOCAL EXHAUST DURING CHARGING
CYCLES TO AVOID AN EXPLOSIVE BUILD UP OF HYDROGEN GAS.
Protective Gloves:NONE (RUBBER IF ACID IS LEAKING)
Eye Protection:SAFETY GLASSES/SPLASH GOGGLES (LIQUID)
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER, NORMAL
WORK CLOTHING. PROTECT WITH IMPERVIOUS APRON AND/OR BOOTS IF ACID
IS LEAKING.
Work Hygienic Practices:USE GOOD INDUSTRIAL HYGIENE PRACTICE. AVOID
ALL CONTACT WITH ACID OR INTERNALS OF THE BATTERY.
Supplemental Safety and Health
BATTERY SUPPLIED DRY AND NON-SPILLABLE. PROTECT PERSONNEL AS THOUGH
ACID WAS LEAKING WHILE FILLING. NOTE THAT INGREDIENT % IS GIVEN FOR
THE DRY CHARGED CONDITION. MSDS RECEIVED FROM NAVY. LABEL WAS R
ECEIVED ON DOD FORM, FILLED OUT POSSIBLYBY NAVY. DLA HAS NOT
PURCHASED THIS NSN FROM CONCORD BATTERY.

HCC:N1
pH:UNKNON
Solubility in Water:APPRECIABLE
Appearance and Odor:STORAGE BATTERY 6.8X10.25X8.9 INCHES WITH TAPER
POSTS ON TOP, NO ODOR
Percent Volatiles by Volume:UNKNON

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:NONE UNDER ANY FORESEEABLE USE

Waste Disposal Methods:DISPOSE I/A/W ALL FEDERAL, STATE AND LOCAL
REGULATIONS. MANUFACTURER SUGGESTS THAT DISPOSAL MAY BE DONE BY
FLUSHING NEUTRALIZED ACID TO DRAIN AND SENDING REMAINDER TO LEAD
RECLAIMER. DO NOT INCINERA TE!!!

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.