Product ID:TECTYL 437
MSDS Date:12/08/1989
FSC:8030
NIIN:00-598-5915
MSDS Number: BJZWD

VALVOLINE INC

LEXINGTON, KY 40512
US

Emergency Phone: 800-274-5263 OR 800-ASHLAND

Info Phone: 606-264-7000

Cage: GO029

VALVOLINE OIL CO

14000 LEXINGTON, KY 40512 US

Telephone: 606-357-7206 / 800-274-5263

Cage: 72527

ORGANIC SALT

CAS: 61789-86-4

Fraction By Weight: 1-5%

HEAVY NAPHTHENIC DISTILLATE

CAS: 64742-52-5

RTECS: PY8035000

Fraction By Weight: 55-70%

OSHA PEL 5 MG/M3

ACGIH TLV: 5 MG/M3

PARAFFIN WAX

CAS: 8002-74-2

RTECS: RV0350000

Fraction By Weight: 25-40%

OSHA PEL 2 MG/M3 (FUME)

ACGIH TLV: 2 MG/M3 (FUME); 9192

Health Hazards Acute and Chronic:EYES: CAN CAUSE MODERATE IRRITATION,
REDNESS, TEARING. SKIN: CAN CAUSE SLIGHT IRRITATION. SWALLOWING:
CAN CAUSE GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING AND
DIARRHEA. IRRITATION OF MOUTH AND ESOP HAGUS. BREATHING: OF MIST
CAN CAUSE IRRITATION OF NASAL AND RESPIRATORY PASSAGES.

First Aid:SKIN: THOROUGHLY WASH EXPOSED AREA WITH SOAP AND WATER.
REMOVE CONTAMINATED CLOTHING. LAUNDER CONTAMINATED CLOTHING BEFORE
RE-USE. EYES: FLUSH WITH LARGE AMOUNTS OF WATER, LIFTING UPPER AND
LOWER LIDS OCCASIONALLY. GET MEDICAL ATTENTION. SWALLOWED: DO NOT
INDUCE VOMITING, KEEP WARM AND QUIET. GET MEDICAL ATTENTION.
BREATHED: REMOVE INDIVIDUAL TO FRESH AIR.

Flash Point:>350F,>177C
Extinguishing Media:REGULAR FOAM OR CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS WITH A
FULL FACEPIECE OPERATED IN THE POSITIVE PRESSURE DEMAND MODE WHEN
FIGHTING FIRES.
Unusual Fire/Explosion Hazard:WATER OR FOAM MAY CAUSE FROTHING WHICH
CAN BE VIOLENT & POSSIBLY ENDANGER THE FIRFIGHTER'S LIFE,
ESPECIALLY IF SPRAYED INTO CONTAINERS OF HOT, BURNING LIQUID.

Spill Release Procedures:PREVENT RUN-OFF TO SEWERS, STREAMS, OTHER
WATER BODIES. IF RUN-OFF OCCURS, NOTIFY PROPER AUTHORITIES THAT
SPILL HAS OCCURED. EXCLUDE PERSONS NOT WEARING PROTECT EQUIP FROM
SPILL AREA UNTIL CLEAN-UP CO MPLETED. SHOVEL INTO CONTAINERS. SWEEP
SPILL AREA.

Handling and Storage Precautions:DO NOT TRANSFER TO UNLABELED
CONTAINER. DO NOT USE CUTTING OR WELDING TORCH ON THIS CONTAINER
(EVEN EMPTY). USE OR STORE ONLY WITH GOOD VENTILATION.

Respiratory Protection:IF EXPOS LIMITS EXCEEDED, NIOSH/MSHA APPROVED
AIR SUPPLIED RESPIRATOR IS ADVISED. OSHA REGS ALSO PERMIT OTHER
NIOSH/MSHA RESPIRATORS (NEGATIVE PRESSURE TYPE) UNDER SPECIFIED
CONDITIONS. IMPLEMENT ENGI NEERING/ADMIN CONTROLS TO REDUCE EXPOS.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOAL EXHAUST)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:WEAR RESISTANT GLOVES SUCH AS: NEOPRENE.
Eye Protection:CHEMICAL SPLASH GOGGLES, SAFETY GLASSES
Other Protective Equipment:TO PREVENT REPEATED OR PROLONGED SKIN
CONTACT, WEAR IMPERVIOUS CLOTHING AND BOOTS.
Work Hygienic Practices:USE GOOD HYGIENIC PRACTICES.
Supplemental Safety and Health
AVOID CONTACT WITH EYES AND PROLONGED OR REPEATED CONTACT WITH SKIN.
CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN EMPTIED. SINCE
EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES, ALL HAZARD PRECAUTIONS
GIVEN MUST BE OBSERVED. BEFORE USE, REVIEW MATERIAL SAFETY DATA
SHEET FOR MORE DETAILED INFORMATION.

HCC:N1
Vapor Pres:<0.01 MMHG
Vapor Density:> THAN AIR
Spec Gravity:.909 @ 60.00 F
Evaporation Rate & Reference:SLOWER THAN ETHER

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:MAY FORM TOXIC MATERIALS: CARBON
DIOXIDE AND CARBON MONOXIDE, ZINC OXIDE, CALCIUM OXIDE, ETC.

Waste Disposal Methods:SMALL SPILL: DESTROY BY INCINERATION IN
ACCORDANCE WITH APPLICABLE REGULATIONS. LARGE SPILL: DESTROY BY
LIQUID INCINERATION. CONTAMINATED ABSORBENT MAY BE DEPOSITED IN A
LANDFILL IN ACCORDANCE WITH LO CAL, STATE AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.