Product ID:TONER, SP-50B
MSDS Date:01/31/1990
FSC:6850
NIIN:00N018199
MSDS Number: BLDHB

MINOLTA CORPORATION

101 WILLIAMS DRIVE
RAMSEY, NJ 07446-1217
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 201-825-4000

Cage: 23736

MINOLTA CORPORATION

RAMSEY, NJ 07446 US

Telephone: 201-825-4000

Cage: 23736

STYRENE ACRYLATE COPOLYMER

Fraction By Weight: >80%

COPPER OXIDE

CAS: 1317-38-0

RTECS: GL7900000

Fraction By Weight: 5-10%

ORGANIC PIGMENT

Fraction By Weight: 1-5%

CARBON BLACK

CAS: 1333-86-4

RTECS: FF5800000

Fraction By Weight: 1-5%

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3; 9192

PROPENE POLYMERS; (POLYPROPYLENE)

CAS: 9003-07-4

RTECS: UD1842000

Fraction By Weight: 1-3%

TONER, AS A MIXTURE. LIMITS AS A NUISANCE DUST.

OSHA PEL 15 MG/M3;5 RESP

ACGIH TLV: 10 MG/M3

LD50 LC50 Mixture:LD50(ORAL,RAT) >5.0 G/KG
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: MINIMAL RESPIRATORY TRACT IRRIT
MAY OCCUR AS WITH EXPOS TO LRG AMTS OF ANY NONTOXIC DUST. MAY CAUSE
COUGH & RAISE PHLEGM. CHRONIC: NONE. TONER PRESENTS A LOW HAZ FOR
USUAL OCCUPATIONAL SETTINGS . BASED ON AVAIL DATA, HUMAN EXPOS TO
TONER HAS BEEN SHOWN TO CAUSE MINIMAL RESP TRACT IRRIT AS MAY(SEE
EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: OCCUR W/LRG AMTS OF ANY NON-TOXIC
DUSTS. THE RESULTS OF ONE ANIMAL STUDY WHERE RATS INHALED TONER
THAT WAS TEN TIMES MORE RESPIRABLE THAN COMMERCIALLY AVAIL TONER
WERE OBSERVED TO HAVE NO LU NG CHANGES AT LOW EXPOS (THE MOST
RELEVANT LEVEL TO POTENTIAL HUMAN EXPOS). AT HIGHER LEVS A SLIGHT
DEGREE (SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHAL: WASH NOSTRILS, RINSE MOUTH. INGEST: DILUTE STOMACH
CONTENTS WITH SEVERAL GLASSES OF WATER. EYES: FLUSH WITH WATER FOR
AT LEAST 15 MINUTES. SKIN: WASH WITH SOAP AND WATER.

Extinguishing Media:WATER, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . AVOID INHALATION OF SMOKE.
Unusual Fire/Explosion Hazard:TONER IS A COMBUSTIBLE POWDER. WHEN
DISPERSED IN AIR, IT FORMS EXPLOSIVE MIXTURES.

Spill Release Procedures:IF SPILLED, SWEEP UP OR VACUUM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:NONE
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED IN MINOLTA
EQUIPMENT. IF NECESSARY, NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE
Supplemental Safety and Health
EFTS OF OVEREXP: OF LUNG FIBROSIS WAS OBSERVED DUE TO EXCESSIVE AMTS OF
DUST RETAINED IN THE LUNGS FOR A PROLONGED INTERVAL.

HCC:N1
Spec Gravity:1.2
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK POWDER, FAINT ODOR.

Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION ARE TOXIC.
AVOID BREATHING OF SMOKE.

Waste Disposal Methods:DO NOT INCINERATE. NO SPECIAL TECHNIQUES BEYOND
NORMAL PRACTICE. ENSURE CONFORMITY WITH FEDERAL, STATE AND LOCAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.