Product ID:METHANOL, 5217
MSDS Date:05/01/1989
FSC:6810
NIIN:00N023128
MSDS Number: BLXCP

J T BAKER INC

222 RED SCHOOL LANE
PHILLIPSBURG, NJ 08865
US

Emergency Phone: 201-859-2151;800-424-9300(CHEMTREC)

Info Phone: 201-859-2151

Preparer: QUALITY ASSURANCE DEPT

Cage: DO803

MALLINCKRODT BAKER, INC.

PHILLIPSBURG, NJ 08865 US

Telephone: 800-582-2537

Cage: 70829

METHANOL; (METHYL ALCOHOL)

CAS: 67-56-1

RTECS: PC1400000

Fraction By Weight: 90-100%

OSHA PEL S,200PPM/250STEL

ACGIH TLV: S,200PPM/250STEL; 93

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

LD50 LC50 Mixture:LD50:(ORAL,RAT) 5628 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHAL: HARMFUL & MAY BE FATAL,
HEADACHE, NAUSEA, VOMITING, DIZZINESS, NARCOSIS, RESPIRATORY
FAILURE, LOW BLOOD PRESSURE, CENTRAL NERVOUS SYSTEM DEPRESSION.
SKIN: IRRITATION, PROLONGED CONTACT MAY CAUS E DERMATITIS. EYE:
IRRITATION, MAY CAUSE TEMPORARY CORNEAL DAMAGE. INGEST: HARMFUL &
MAY BE FATAL, (SEE EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: BLINDNESS, HEADACHE, NAUSEA,
VOMITING, DIZZINESS, GASTROINTESTINAL IRRITATION, CENTRAL NERVOUS
SYSTEM DEPRESSION, HEARING LOSS. CHRONIC: KIDNEY & LIVER DAMAGE.
TARGET ORGANS: EYES, SKIN, CEN TRAL NERVOUS SYSTEM, GI TRACT,
RESPIRATORY SYSTEM, LUNGS.
Medical Cond Aggravated by Exposure:EYE DISORDERS, SKIN DISORDERS,
LIVER OR KIDNEY DISORDERS.

First Aid:INGEST: CALL MD. IF CONSCIOUS, GIVE LG AMTS OF WATER. INDUCE
VOMITING. INHAL: REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTF
RESP. IF BREATHING DIFFICULT, GIVE O*2. SKIN: IMMEDIATELY FLUSH
WITH PLEN TY OF WATER FOR AT LEAST 15 MINUTES WHILE REMOVING
CONTAMINATED CLOTHING AND SHOES. WASH CLOTHING BEFORE RE-USE. EYES:
IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.

Flash Point Method:CC
Flash Point:54.0F,12.2C
Lower Limits:6%
Upper Limits:36%
Extinguishing Media:USE ALCOHOL FOAM, DRY CHEMICAL OR CO*2. (WATER MAY
BE INEFFECTIVE).
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. MOVE CNTNRS FROM FIRE AREA IF CAN BE DONE W/O RISK. USE WATER TO
KEEP FIRE-EXPOSED CNTNRS COOL.
Unusual Fire/Explosion Hazard:VAPS MAY FLOW ALONG SURFS TO DISTANT
IGNIT SOURCES & FLASH BACK. CLOSED CNTNRS EXPOSED TO HEAT MAY
EXPLODE. CONT W/STRONG OXIDIZERS MAY CAUSE FIRE.(SUPP DATA)

Spill Release Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT CLTHG.
SHUT OFF IGNIT SOURCES; NO FLARES, SMOKING/FLAMES IN AREA. STOP
LEAK IF CAN DO SO W/O RISK. USE WATER SPRAY TO REDUCE VAPS. TAKE UP
W/SAND/OTHER NON-COMB UST ABSORB MATL & PLACE INTO CNTNR FOR (SUPP
DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
IN COOL, DRY, WELL-VENTILATED, FLAMMABLE LIQUID STORAGE AREA.
Other Precautions:BOND & GROUND CNTNRS WHEN TRANSFERRING LIQ. FLAMM.
CANNOT BE MADE NON-POISONOUS. KEEP AWAY FROM HEAT, SPARKS, FLAME.
DO NOT GET IN EYES, ON SKIN/CLTHG. AVOID BREATHING VAPORS. USE WITH
ADEQUATE VENTIL ATION.

Respiratory Protection:RESPIRATORY PROTECTION REQUIRED IF AIRBORNE
CONCENTRATION EXCEEDES TLV. AT CONCENTRATIONS ABOVE 200 PPM, A
NIOSH/MSHA APPROVED SCBA IS ADVISED.
Ventilation:USE GENERAL OR LOCAL EXHAUST VENTILATION TO MEET TLV
REQUIREMENTS.
Protective Gloves:RUBBER GLOVES RECOMMENDED.
Eye Protection:CHEM WORK GOG & FULL LENGTH FSHLD.
Other Protective Equipment:UNIFORM AND PROTECTIVE SUIT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
EXPLO HAZ: BURNS WITH CLEAR, ALMOST INVISIBLE FLAME. SPILL PROC: LATER
DISPOSAL. FLUSH AREA WITH WATER. J T BAKER SOLUSORB(R) SOLVENT
ABSORBENT IS RECOMMENDED FOR SPILLS OF THIS PRODUCT.

HCC:F5
Boiling Pt:B.P. Text:149F,65C
Melt/Freeze Pt:M.P/F.P Text:-144F,-98C
Vapor Pres:96 @ 20C
Vapor Density:1.11
Spec Gravity:0.79
Evaporation Rate & Reference:4.6 (BUTYL ACETATE = 1)
Solubility in Water:COMPLETE (100%)
Appearance and Odor:CLEAR, COLORLESS LIQUID, PUNGENT ODOR.
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS, ZINC, ALUMINUM, MAGNESIUM.
Stability Condition to Avoid:HEAT, FLAME, OTHER SOURCES OF IGNITION.
Hazardous Decomposition Products:CO, CO*2, FORMALDEHYDE.

Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE, AND LOCAL ENVIRONMENTAL REGULATIONS. EPA HAZ WASTE
#U154.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.