Product ID:CERA-KOTE
MSDS Date:10/14/1989
FSC:6850
NIIN:00N023042
MSDS Number: BLYGS

MANVILLE SALES CORP

DENVER, CO 80217-5108
US

Emergency Phone: 303-978-4900

Info Phone: 303-978-4900

Preparer: RONALD L. BATTLES

Cage: 75165

SCHULLER INTERNATIONAL INC.

5108 DENVER, CO 80217-5108 US

Telephone: 303-978-4900

Cage: 75165

FIBERS, REFRACTORY CERAMIC; (REFRACTORY CERAMIC FIBER)

RTECS: LK3628000

Fraction By Weight: 30%

OSHA PEL 5 MG/M3 (MFR)

ACGIH TLV: 10 MG/M3 (MFR)

CLAY

CAS: 1327-26-2

Fraction By Weight: 30%

SODIUM SILICATE; (COLLOIDAL SILICA)

CAS: 1344-09-8

Fraction By Weight: 30%

ETHYLENE GLYCOL

CAS: 107-21-1

RTECS: KW2975000

Fraction By Weight: 4%

OSHA PEL 50 PPM, C

ACGIH TLV: 50 PPM, C

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

WATER

CAS: 7732-18-5

RTECS: ZC0110000

Fraction By Weight: 6%

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EXPOS TO DUST SHOULD BE MIN. ANIMAL
INHAL & ARTF IMPLANTATION STUDIES HAVE REPORTED DEVEL OF TUMORS.
BASED ON ANIMAL STUDIES, IARC HAS CLASSIFIED RCF AS POSS CARC FOR
HUMANS (2B). ACUTE:PRODUCT IS A MECHANICAL IRRITANT TO SKIN, EYES
AND UPPER RESPIRATORY SYSTEM. CHRONIC:WHEN PRODUCT IS RAISED TO
TEMP OVER (SUPDAT)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:INHAL:IRRITATION OR SORENESS IN THROAT AND
NOSE. IN EXTREME EXPOSURES SOME CONGESTION MAY OCCUR. SKIN:MAY
CAUSE IRRITATION TO SENSITIVE SKIN. INGEST:NOT HAZARDOUS WHEN
INGESTED. MAY CAUSE TEMPORARY IR RITATION TO GI TRACT. EYES:PRODUCT
IS AMILD ALKALI AND CAN CAUSE SEVERE IRRITATION AND/OR CORNEAL
DAMAGE.
Medical Cond Aggravated by Exposure:AS WITH ANY DUST, PRE-EXISTING
UPPER RESPIRATORY AND LUNG DISEASE MAY BE AGGRAVATED.

First Aid:INHAL:REMOVE TO FRESH AIR. DRINK WATER TO CLEAR THROAT AND
BLOW NOSE TO EVACUATE FIBERS. SKIN:WASH AFFECTED AREAS GENTLY WITH
SOAP AND WARM WATER. INGEST:NOT ACUTELY TOXIC. BUT IF LARGE
QUANTITIES ARE INGESTED, INDUCE VOMITING AND CONSULT MD.
EYES:IMMEDIATELY FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES. IF IRRITATION PERSISTS CONSULT MD.

Flash Point:NON FLAMMABLE
Extinguishing Media:NOT APPLICABLE. MEDIA SUITABLE FOR SURROUNDING FIRE
.
Fire Fighting Procedures:NONE. USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE

Spill Release Procedures:WIPE UP EXCESS. FLUSH AREA WITH WATER AND MOP
UP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP MATERIALS DRY. WARNING:AFTER
SERVICE PROD CONTAINS A CHEM KNOWN TO THE STATE OF CALIFORNIA TO
CAUSE CANCER.
Other Precautions:CONSULT MOST CURRENT RCF HEALTH & SAFETY BULLETIN
AND/OR MANVILLE PUBLICATION HSE-66B HEALTH AND SAFETY ASPECTS OF
REFRACTORY CERAMIC FIBERS FOR MOST CURRENT INFORMATION AVAILABLE
FROM PROD INFORMATIO N CENTER 800-654-3103.

Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR REQUIRED. MSA
COMFO II WITH H FILTER REQUIRED FOR MOST APPLICATIONS.
Ventilation:ADEQUATE VENTILATION TO KEEP DUST LEVEL BELOW PEL/TLV/WEG
(WORK PLACE EXPOSURE GUIDELINE).
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
HLTH HAZ:OVER 1000C. CRISTOBALITE IS FORMED. EXCESSIVE EXPOSURE TO
"AFTER SERVICE" DUSTS MAY CAUSE LUNG DISEASE (SILICOSIS).

HCC:N1
Boiling Pt:B.P. Text:>212F,>100C
Spec Gravity:1.9
Evaporation Rate & Reference:1 (WATER = 1)
Solubility in Water:30
Appearance and Odor:GREY VISCOUS LIQUID WITH NO ODOR.
Percent Volatiles by Volume:20

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS.
Stability Condition to Avoid:NONE IS DESIGNED USE.
Hazardous Decomposition Products:NONE

Waste Disposal Methods:WASTES ARE NOT HAZARDOUS AS DEFINED BY RCRA (40
CFR PART 261). COMPLY WITH FEDERAL, STATE AND LOCAL REGULATIONS.
METHOD OF DISPOSAL-LANDFILL.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.