Product ID:7065/7640 TONER-SAVIN, 887156
MSDS Date:10/26/1990
FSC:6850
NIIN:00N027137
MSDS Number: BMTFZ

RICOH CORPORATION

5 DEDRICK PLACE
WEST CALDWELL, NJ 07006
US

Emergency Phone: 800-336-6737

Info Phone: 201-882-2000;800-336-6737

Preparer: KRISTINA SAGE

Cage: 54726

RICOH CORPORATION

WEST CALDWELL, NJ 07006-6304 US

Telephone: 800-336-6737

Cage: 54726

STYRENE ACRYLATE COPOLYMER

CAS: 25213-39-2

Fraction By Weight: 13%

CARBON BLACK

CAS: 1333-86-4

RTECS: FF5800000

Fraction By Weight: 11%

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3

DYE

CAS: 84179-66-8

Fraction By Weight: <2%

DYE

CAS: 109125-50-0

Fraction By Weight: <2%

DYE

CAS: 109125-51-1

Fraction By Weight: <2%

STYRENE ACRYLIC RESIN; (STYRENE ACRYLIC POLYMER)

CAS: 26655-10-7

Fraction By Weight: 74%

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYES:MAY CAUSE TEMP EYE
DISCOMFORT. SKIN:MAY CAUSE SLIGHT IRRIT ON PRLNG/RPTD CONT W/SKIN.
MILDLY IRRITATING (PRIMARY IRRIT INDEX 0.1). INHAL:GASP. INGEST:>5
G/KG BODYWEIGHT, PRACTICALLY NON-TOX . CHRONIC:IN XEROX SPONSORED
CHRONIC INHAL STUDY IN RATS USING SPECIAL TEST TONER, THERE WERE NO
LUNG (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:CHANGES @ ALL IN THE LOWEST EXPOS
LEVEL (1MG/M3), MOST RELEVANT LEVEL TO POTNTL HUMAN EXPOS. VERY
SLIGHT DEGREE OF FIBROSIS WAS NOTED IN 25% OF ANIMALS @ MIDDLE
EXPOS LEVEL (4MG/ M3) WHILE SL IGHT DEGREE OF FIBROSIS WAS OBSERVED
@ HIGHEST EXPOS LEVEL (16MG/M3) IN ALL ANIMALS. THESE FINDINGS ARE
(SUPP DATA)

First Aid:EYES: TRY TO REMOVE WITH EYE DROPS OR FLUSH WITH WATER FOR AT
LEAST 15 MIN. IF UNSUCCESSFUL, GET MED ATTN. SKIN: WASH THOROUGHLY
WITH SOAP AND WATER. INHAL: REMOVE FROM EXPOSURE. INGEST: DILUTE
STOMAC H CONTENTS WITH SEVERAL GLASSES OF WATER.

Extinguishing Media:CO2, DRY CHEMICALS, FOAM OR WATER.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:WILL NOT OCCUR.

Spill Release Procedures:IF SPILLED, SWEEP UP USING AN APPRVD TONER
VACUUM CLEANER W/0.5 MICRON FILTER SUCH AS ATRIX AAA TONER VACUUM
(RICOH EDP CODE 342MIU). USE OF VACUUM CLEANER NOT RATED FOR TONER
PARTICULATE COULD BE POT NTL FIRE HAZ &/OR RSLT IN PERS INJURY.
(SUPP DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:CLEANSE SKIN THOROUGHLY AFTER CONTACT,
BEFORE BREAKS AND MEALS, AND @ END OF WORK PERIODS. KEEP OUT OF
REACH OF CHILDREN.
Other Precautions:NONE.

Respiratory Protection:NONE REQUIRED UNDER NORMAL CONDITIONS OF USE.
USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF
CONCERN .
Ventilation:LOCAL EXHAUST:NONE REQUIRED UNDER NORMAL CONDITIONS OF USE.
MECHANICAL(GEN): ADEQUATE VENTILATION.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:NONE REQUIRED UNDER NORMAL CONDITIONS OF
USE.
Work Hygienic Practices:CLEANSE SKIN THOROUGHLY AFTER CONTACT, BEFORE
BREAKS AND MEALS AND AT THE END OF WORK PERIODS.
Supplemental Safety and Health
EFTS OF OVEREXP:ATTRIBUTED TO "LUNG OVERLOAD", GENERIC RESPONSE TO
EXCESS AMT OF ANY DUST RETAINED IN LUNGS FOR PRLNG INTERVAL.
SPECIAL TEST TONER WAS 10 X MORE RESPIRABLE THAN COMMERCIALLY AVAIL
TONE R TO COMPLY W/EPA TEST PROTOCOL & WOULDNOT FUNC PROPERLY IN
XEROGRAPHIC EQUIP. SPILL PROC: REMOVE RESIDUE W/SOAP/H2O.

HCC:V7
Melt/Freeze Pt:M.P/F.P Text:176F,80C
Spec Gravity:0.34
Solubility in Water:NEGLIGIBLE <0.1%
Appearance and Odor:BLACK POWDER WITH SLIGHT PLASTIC ODOR.

Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CO AND OTHER DECOMPOSITION PRODUCTS IN
CASE OF COMBUSTION.

Waste Disposal Methods:USED TONER SHOULD BE DISPOSED OF IN AN
ENVIRONMENTALLY SAFE MANNER & I/A/W GOVT REGS. DO NOT INCINERATE.
DISP REGS VARY FROM LOCALITY TO LOCALITY, THEREFORE, CONSULT YOUR
LOCAL, FEDERAL AND STATE OFFI CE OF EPA TO DETERMINE PROPER METH OF
DISPOSAL.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.