Product ID:DIMETHYL KETONE; 2-PROPANONE, AX0110
MSDS Date:10/06/1989
FSC:6810
NIIN:00N027144
MSDS Number: BMTGG

EM SCIENCE

480 DEMOCRAT RD
GIBBSTOWN, NJ 08027
US

Emergency Phone: 800-424-9300(CHEMTREC)

Info Phone: 609-354-9200

Cage: DO242

EM SCIENCE

70 GIBBSTOWN, NJ 08927 US

Telephone: 800-424-9300 (CHEMTREC)

Cage: DO242

ACETONE; (DIMETHYL KETONE) (2-PROPANONE) (SARA III)

CAS: 67-64-1

RTECS: AL3150000

OSHA PEL 1000PPM

ACGIH TLV: 750PPM/1000STEL;9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

BENZENE (SARA III)

CAS: 71-43-2

RTECS: CY1400000

Fraction By Weight: <0.002%

OSHA PEL 1 PPM;5 STEL

ACGIH TLV: 10 PPM

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

PROCESS EQUIP OPERATING UNDER ELEVATED PRESS IF

RTECS: 9999999ZZ

FIRE AND EXPLOSION HAZARD.

RTECS: 9999999ZZ

CONDTNS (SEE YOUR SAFETY EQUIPMENT SUPPLIER).

RTECS: 9999999ZZ

TO REDUCE EXPOSURE.

RTECS: 9999999ZZ

EQUIVALENT GLOVES SHOULD BE WORN TO PREVENT SKIN

RTECS: 9999999ZZ

LD50 LC50 Mixture:LD50:(ORAL RAT) 5800MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:HARMFUL IF INHALED OR INGESTED. HIGH
CONCENTRATIONS OR PROLONGED EXPOSURE CAUSES HEADACHE, DIZZINESS,
NAUSEA, IRRITATION OF EYES AND RESPIRATORY TRACT, NARCOSIS AND
EVENTUALLY UNCONSCIOUSNESS. MAY CAU SE DAMAGE TO CNS, LIVER AND
KIDNEYS. PROLONGED OR REPEATED SKIN CONTACT MAY CAUSE IRRITATION.
(EFTS OF OVEREXPOS)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:EYE CONTACT CAUSES IRRIT. ANIMAL
STUDIES SHOW ADVERSE EFS ON FERTILITY WHEN FEMALES WERE EXPOSED
CHRONICALLY DURING PREGNANCY. TESTS ON LAB ANIMALS INDICATE
MATERIAL MAY PRODUCE ADVERSE MUTAG ENIC & REPRODUCTIVE EFFECTS.
CONTAINS ATRACE AMT OF BENZENE WHICH HAS BEEN FOUND TO BE
CARCINOGENIC TO HUMANS .
Medical Cond Aggravated by Exposure:SKIN CONTACT AND PREGNANCY.

First Aid:GET MD ASSISTANCE FOR ALL CASES OF OVEREXPOSURE. SKIN:WASH
THOROUGHLY WITH SOAP AND WATER. EYES:IMMEDIATELY FLUSH THOROUGHLY
WITH WATER FOR AT LEAST 15 MINUTES. INHAL:REMOVE TO FRESH AIR, GIVE
ARTIFIC IAL RESPIRATION IF BREATHING HAS STOPPED. INGEST:IF
CONSCIOUS, DRINK WATER AND INDUCE VOMITING IMMEDIATELY AS DIRECTED
BY MEDICAL PERSONNEL. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON.

Flash Point Method:CC
Flash Point:0F,-18C
Lower Limits:2.6%
Upper Limits:12.8%
Extinguishing Media:DRY CHEMICAL, "ALCOHOL" FOAM, WATER SPRAY, CARBON
DIOXIDE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . USE WATER SPRAY TO COOL EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:VAP CAN TRAVEL DISTANCES TO IGNIT SOURCE
& FLASH BACK. HOT ORG CHEM VAP/MISTS ARE SUSCEPTIBLE TO SUDDEN
SPONTANEOUS COMBUST WHEN MIXED W/AIR. IGNIT (SUPDAT)

Spill Release Procedures:DIKE SPILL; TAKE UP WITH ABSORBENT.
CONTAINERIZE FOR PROPER DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP CONTR CLSD. STORE IN COOL AREA
AWAY FROM IGNIT SOURCES & OXIDIZERS. DO NOT BRTH VAP. DO NOT GET IN
EYES. AVOID PRLNGD/RPTD SKIN CONTACT.
Other Precautions:ELECTRICALLY GROUND ALL EQUIPMENT WHEN HANDLING
PRODUCT. RETAINED RESIDUE MAY MAKE EMPTY CONTAINER HAZARDOUS; USE
CAUTION! DO NOT TAKE INTERNALLY. REMOVE CONTAMINATED CLOTHING AND
WASH BEFORE REUSE.

Respiratory Protection:IF WORKPLACE EXPOS LIM(S) OF PROD/ANY COMPONENT
IS EXCEEDED, A NIOSH/MSHA APPRVD AIR SUPPLIED RESP IS ADVISED IN
ABSENCE OF PROPER ENVIRON CONTROL. OSHA REGS ALSO PERMIT OTHER
NIOSH/MSHA APPRVD RESP ( NEG PRESS TYPE) UNDER SPECIFIED (ING 5)
Ventilation:MATERIAL SHOULD BE HANDLED OR TRANSFERRED IN AN APPROVED
FUME HOOD OR WITH ADEQUATE VENTILATION.
Protective Gloves:BUTYL RUBBER, CPE, POLYURETHANE/ (ING 7)
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:EYE WASH AND SAFETY EQUIPMENT SHOULD BE
READILY AVAILABLE.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
EXPLOS HAZ:MAY OCCUR AT TEMP BELOW PUB AUTOIGNIT/IGNIT TEMP. IGNIT TEMP
DECREASE W/INCREASED VAP VOL & VAP/AIR CONTACT TIME & ARE
INFLUENCED BY PRESS CHANGES. IGNIT MAY OCCUR AT TYPICAL ELEVATED
TEMP PROCESS CONDTNS, ESP IN PROCESS OPERATING UNDER VACUUM IF
SUBJECTED TO SUDDEN INGRESS OF AIR/OUTSIDE (ING 3)

Boiling Pt:B.P. Text:133F,56C
Melt/Freeze Pt:M.P/F.P Text:-137F,-94C
Vapor Pres:184 @ 20C
Vapor Density:2.0
Spec Gravity:0.7905 (H*2O=1)
Evaporation Rate & Reference:14.48 (BU AC = 1)
Solubility in Water:MISCIBLE
Appearance and Odor:COLORLESS LIQUID WITH PUNGENT ODOR.
Percent Volatiles by Volume:99.9+

Stability Indicator/Materials to Avoid:YES
ACIDS, OXIDIZERS, POTASSIUM T-BUTOXIDE, NITRIC AND SULFURIC ACID
MIXTURE, BROMINE AND CHLORINE.
Stability Condition to Avoid:HEAT, CONTACT WITH IGNITION SOURCE.
Hazardous Decomposition Products:CO*X.

Waste Disposal Methods:TO BE PERFORMED IN COMPLIANCE WITH ALL CURRENT
LOCAL, STATE AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.