BNNSW - CCC68838000, OLOA 8167FA
- MSDS: BNNSW
- Manufacturer: CHEVRON
- Product Name: CCC68838000, OLOA 8167FA
- National Stock Number: 9150-00N030268
Product Identification
Product ID:CCC68838000, OLOA 8167FA
MSDS Date:11/19/1986
FSC:9150
NIIN:00N030268
MSDS Number: BNNSW
Responsible Party
US
Emergency Phone: 415-233-3737
Info Phone: 415-233-3737
Cage: 0AHD1
Contractor
Telephone: 800-582-3835
Cage: 0AHD1
Ingredients
ZINC AS DIALKYL OR DIARYL DITHIOPHOSPHATE OR MIXTURE OF
CAS: 68649-42-3
Fraction By Weight: 11%
CALCIUM LONGCHAIN ALKYLPHENATE SULFIDE
Fraction By Weight: 12%
MINERAL OIL, PETRO DISTILS HYDROTREATED (SEV) HVY
CAS: 64742-54-7
RTECS: PY8035501
Fraction By Weight: 77%
OSHA PEL 5MG/M3 (OIL MIST)
ACGIH TLV: 5MG/M3;10 STEL(MIST)
DISPERSANT & DETERGENT
LONGCHAIN ALKARYL POLYETHER
Hazards
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE:IRRIT POTENTIAL OF MATL HAS NOT
BEEN DETERMINED, HOWEVER, SINCE IT CONTAINS INGRED WHICH ARE IRRIT
TO EYES, IT MAY CAUSE IRRIT. SKIN:IRRIT POTENTIAL OF MATL HAS NOT
BEEN DETERMINED. HOWEVER, SINCE IT CONTAINS INGRED WHICH ARE IRRIT
TO SKIN, IT MAY CAUSE IRRIT ON PRLNGD/FREQUENTLY RPTD CONT. (EFTS
OF OVEREXPOS)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:INHAL/INGEST:NOT EXPECTED TO BE
ACUTELY TOX. SEV ZINC ALKYL DITHIOPHOSPHATES (ZDDP) HAVE BEEN
REPORTED TO HAVE WEAK MUTAGENIC ACTIVITY IN CULTURED MAMMALIAN
CELLS BUT ONLY AT CONC THAT WERE T OX TO TEST CELLS. TOXICOLOGISTS
AT CHEVRON DO NOT BELIEVE THAT THERE IS ANY MUTAGENIC RISK TO
WORKERS EXPOS TO ZDDP.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
First Aid
First Aid:EYES:FLUSH IMMED W/FRESH H2O FOR @ LST 15 MIN WHILE HOLDING
EYELIDS OPEN. IF IRRIT PERSISTS, SEE MD. SKIN:WASH THORO W/SOAP &
H2O SEE MD IF IRRIT OCCURS. LAUNDER CONTAM CLTHG. INHAL:SINCE MATL
IS NOT EXPECTED TO BE AN ACUTE INHAL PROB, NO FIRST AID PROC ARE
REQ. REMOVE TO FRESH AIR. SUPPORT BRTHG (GIVE O2/ARTF RESP) .
INGEST:GIVE H2O/MILK TO DRINK & CALL FOR MD ADVICE. CONSULT
MD(SUPDAT)
Fire Fighting
Flash Point Method:COC
Flash Point:360F,182C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:DO NOT USE PRESSURE TO EMPTY DRUM OR
EXPLOSION MAY RESULT. DO NOT WELD, HEAT OR DRILL CONTAINERS.
Accidental Release
Spill Release Procedures:STOP SOURCE OF LEAK/RELEASE. CLEAN UP RELEASES
ASAP, OBSERVE PRECS. CONTAIN LIQ TO PVNT FURTHER CONTAM OF SOIL,
SURF WATER/GROUND WATER. CLEAN UP SM SPILLS USING APPROP TECH SUCH
AS SORBENT MATLS/PUMP S. WHERE FEASIBLE & APPROP, REMOVE CONTAM
(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
Handling
Handling and Storage Precautions:READ AND OBSERVE ALL PRECAUTIONS ON
PRODUCT LABEL. DO NOT WELD, HEAT OR DRILL CONTAINERS. REPLACE CAP
OR BUNG.
Other Precautions:EMPTIED CONTAINER STILL CONTAINS HAZARDOUS MATERIAL
WHICH MAY IGNITE WITH EXPLOSIVE VIOLENCE IF HEATED SUFFICIENTLY. DO
NOT USE PRESSURE TO EMPTY DRUM OR EXPLOSION MAY RESULT. AVOID
CONTACT W/SKIN OR CLOTHING.
Exposure Controls
Respiratory Protection:NO SPECIAL RESPIRATORY PROTECTION IS NECESSARY.
WEAR NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF
CONCERN .
Ventilation:NO SPECIAL VENTILATION IS NECESSARY.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:IMPERVIOUS PROTECTIVE CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
HAZ DECOMP PROD:H2S AT TEMP >150F (66C). SPILL PROC:SOIL. FOLLOW
PRESCRIBED PROCS FOR REPORTING TO LARGER RELEASES. FIRST AID
PROC:BEFORE INDUCING VOMIT. IF MED ADVICE CANNOT BE OBTAINED, THEN
TAKE PE RS & PROD CNTNR TO NEAREST MED EMER TREATMENT CENTER/HOSP.
Chemical Properties
HCC:V6
Spec Gravity:0.97 @ 15.6C
Solubility in Water:INSOLUBLE
Appearance and Odor:DARK BROWN LIQUID
Stability
Stability Indicator/Materials to Avoid:YES
MAY REACT WITH STRONG OXIDIZING MATERIALS OR STRONG ACIDS.
Stability Condition to Avoid:TEMPERATURES ABOVE 150F.
Hazardous Decomposition Products:NORMAL COMBUST FORMS CO2, H2O VAP &
MAY PRODUCE SOX; INCOMPLETE COMBUST CAN PRODUCE CO. THERM DECOMP
MAY PROD(SUPDAT)
Disposal
Waste Disposal Methods:PLACE CONTAMINATED MATERIALS IN DISPOSABLE
CONTAINERS AND DISPOSE OF IN A MANNER CONSISTENT WITH APPLICABLE
LOCAL, STATE AND FEDERAL REGULATIONS.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.