Product ID:SHELL JP-4
MSDS Date:02/22/1988
FSC:9130
NIIN:00-256-8617
MSDS Number: BNWJB

SHELL OIL COMPANY

ONE SHELL PLAZA
HOUSTON, TX 77210
US

Emergency Phone: (713)473-9461,CHEMTREC 800-424-9300

Info Phone: (713)241-4819

Cage: 54527

SHELL OIL COMPANY

2463 HOUSTON, TX 77210 US

Telephone: 800-231-6950

Cage: 54527

HYDROTREATED HEAVY NAPHTHA

CAS: 64742-48-9

Fraction By Weight: 88-95%

NAPHTHA, LIGHT

CAS: 64741-46-4

Fraction By Weight: 5-12%

ADDITIVES

Fraction By Weight: <0.5%

BENZENE (SARA III)

CAS: 71-43-2

RTECS: CY1400000

Fraction By Weight: <2.5%

OSHA PEL 1PPM/5STEL;1910.1028

ACGIH TLV: 10 PPM; A2; 9192

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:EYE/SKIN/INHALATION:IRRITATION,
DEFATTING OF SKIN. INGESTION:HARMFUL OR FATAL. ASPIRATION INTO THE
LUNGS CAN CAUSE CHEMICAL PNEUMONITIS AND DEATH. CHRONIC-CAUSES
LIVER, KIDNEYS AND CENTRAL NERVOUS SYS TEM DAMAGE.
Explanation of Carcinogenicity:THIS MATERIAL CONTAINS BENZENE, A KNOWN
CARCINOGEN.
Effects of Overexposure:EYE:IRRITATION. SKIN:DRYING AND DEFATTING.
INHALATION:HEADACHE, NAUSEA, LOSS OF APPETITE, WEAKNESS, LOSS OF
COORDINATION, CONFUSION, DROWSINESS, UNCONSCIOUSNESS AND DEATH MAY
OCCUR. INGESTION:G/I IRRI TATION, PAIN IN THE UPPER ABDOMEN, NAUSEA
AND VOMITING.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF SKIN AND
RESPIRATORY DISORDERS MAY BE AT INCREASED RISK FROM EXPOSURE.

First Aid:EYE:IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR 15 MINUTES.
GET MEDICAL ATTENTION. SKIN:REMOVE CONTAMINATED CLOTHING AND WASH
WITH SOAP AND WATER. INHALATION: REMOVE TO FRESH AIR. RESUSCITATE
OR GIVE O XYGEN AS NEEDED-THEN GET MEDICAL HELP. INGESTION:GIVE
MILK OR WATER BUT DO NOT INDUCE VOMITING. GET MEDICAL ATTENTION AT
ONCE.

Flash Point Method:PMCC
Flash Point:-10F,-23C
Lower Limits:1.3
Upper Limits:8.0
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM AND WATER FOG.
Fire Fighting Procedures:USE FULL FIRE FIGHTING GEAR WITH SCBA. THIS
MATERIAL EVAPORATES QUICKLY EVEN AT VERY LOW TEMPERATURES AND IS AN
EXTREME FIRE HAZARD. COOL NEARBY CONTAINERS.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR ACCUMULATING
IN LOW AREAS AND TRAVELING ALONG THE GROUND AWAY FROM THE HANDLING
SITE, AND CAN FLASH BACK.

Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT, ELIMINATE SOURCES
OF IGNITION, AND VENTILATE AREA AS REQUIRED. ABSORB SMALL SPILL
WITH INERT MATERIAL OR DIKE TO RETAIN LARGE SPILL. RECOVER BY
PUMPING. PLACE WASTE IN DOT A PPROVED CONTAINER FOR DISPOSAL.
Neutralizing Agent:NONE

Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA AWAY FROM SOURCES OF IGNITION OR OXIDIZERS. KEEP CONTAINER
CLOSED WHEN NOT IN USE. PROTECT FROM DAMAGE.
Other Precautions:"EMPTY" CONTAINERS MAY CONTAIN RESIDUE AND/OR FUMES
WHICH ARE EXPLOSIVE. DO NOT CUT,DRILL, WELD ETC. ON CONTAINERS.

Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL (TLV), USE NIOSH APPROVED RESPIRATOR AS PER
CURRENT 29 CFR 1910.134, INSTRUCTIONS/WARNINGS AND NIOSH-RESPIRATOR
SELECTION.
Ventilation:MECHANICAL (GENERAL) VENTILATION IS USUALLY ADEQUATE.
Protective Gloves:RUBBER OR HYDROCARBON RESISTANT GLOVES
Eye Protection:SAFETY GLASSES/CHEMICAL SPLASH GOGGLES
Other Protective Equipment:SAFETY SHOWER AND EYE BATH. INDUSTRIAL TYPE
WORK CLOTHING AND APRON AS REQUIRED TO AVOID PROLONGED OR REPEATED
CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING OR DRINKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
DO NO PRESSURIZE "EMPTY" DRUMS.

HCC:F2
Boiling Pt:B.P. Text:>100F,>38C
Vapor Pres:14-21 PSI
Vapor Density:3.5
Spec Gravity:0.78
Viscosity:4 CST @-34.4C
Solubility in Water:NGLIGIBLE
Appearance and Odor:CLEAR AND BRIGHT LIQUID, HYDROCARBON ODOR.
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS SUCH AS NITRATES, CHLORATES, PERCHLORATES,
HYPOCHLORITES.
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS AND OPEN FLAMES.
Hazardous Decomposition Products:CARBON DIOXIDE AND CARBON MONOXIDE

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL REGULATIONS. UNUSED OR SPILL CLEAN-UP
MATERIAL WILL LIKELY BE A HAZARDOUS WASTE (CODE D001).

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.