Product ID:BATTERY,STORAGE
MSDS Date:01/01/1987
FSC:6140
NIIN:00-406-2634
MSDS Number: BPBMB

CONCORDE BATTERY CORP

2009 SAN BERNARDINO RD
WEST COVINA, CA 91790-1006
US

Emergency Phone: 818-962-4006

Info Phone: 714-989-8522

Cage: 63017

CONCORDE BATTERY CORP

WEST COVINA, CA 91790-1006 US

Telephone: 800-255-3924/818-813-1234

Cage: 63017

LEAD(II)OXIDE., INGRED #1,2 & 3 MAKEUP 60%

CAS: 1317-36-8

RTECS: OG1750000

LEAD(II,III)OXIDE (RED LEAD OXIDE)

CAS: 1314-41-6

RTECS: OG5425000

OSHA PEL 50 UG/M3

ACGIH TLV: 0.15 MG/M3

LEAD PEROXIDE, LEAD(IV)OXIDE

CAS: 1309-60-0

RTECS: OG0700000

LEAD (SARA III)

CAS: 7439-92-1

RTECS: OF7525000

Fraction By Weight: 38%

OSHA PEL 0.05 MG/M3;1910.1025

ACGIH TLV: 0.15 MG/M3;DUST 9192

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

SULFURIC ACID (SARA III)

CAS: 7664-93-9

RTECS: WS5600000

Fraction By Weight: 2.0%

OSHA PEL 1 MG/M3

ACGIH TLV: 1 MG/M3; 9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE- SULFURIC ACID CAUSES SEVERE
IRRITATION & BURNS OF EYES,NOSE & THROAT.INGESTION CAN CAUSE SEVERE
BURNS & VOMITING. CHRONIC- REPEATED CONTACT CAUSES IRRITATION AND
SKIN BURNS. REPEATED EXPOSURE T O MIST MAY CAUSE EROSION OF TEETH,
CHRONIC EYE IRRITATION AND/OR CHRONIC INFLAMMATION OF THE NOSE,
THROAT AND LUNGS.
Explanation of Carcinogenicity:CONTAINS LEAD.
Effects of Overexposure:SULFURIC ACID CAUSES SEVERE IRRITATION & BURNS
OF EYES,NOSE & THROAT.INGESTION CAN CAUSE SEVERE BURNS & VOMITING.
REPEATED CONTACT CAUSES IRRITATION AND SKIN BURNS. REPEATED
EXPOSURE TO MIST MAY CAUSE EROSION OF TEETH, CHRONIC EYE
IRRITATION AND/OR CHRONIC INFLAMMATION OF THE NOSE, THROAT AND
LUNGS.
Medical Cond Aggravated by Exposure:IF BATTERY IS BROKEN OR MATERIAL IS
SPILLED, THEN PERSONS WITH FOLLOWING DISEASES MUST TAKE
PRECAUTIONS: PULMONARY EDEMA, BRONCHITIS, EMPHYSEMA, DENTAL EROSION
AND TRACHEOBRONCHITIS.

First Aid:GET MEDICAL ATTENTION IMMEDIATELY.EYE/SKIN:IMMEDIATELY FLUSH
WITH WATER FOR AT LEAST 15 MINUTES.HOLD EYELIDS OPEN.INHALED:REMOVE
TO FRESH AIR & PROVIDE OXYGEN/CPR IF NEEDED.ORAL:DO NOT INDUCE
VOMITING .IF CONSCIOUS,DRINK LARGE AMOUNT OF WATER/MILK.CALL A
PHYSICIAN IMMEDIATELY.NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON.

Extinguishing Media:WATER FOG, HALOGEN TYPE, DRY CHEMICALS OR CARBON
DIOXIDE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS. WILL GENERATE HYDROGEN
AND SULFURIC ACID MIST ON OVERCHARGE.

Spill Release Procedures:SPILL-DILUTE SPILL CAUTIOUSLY WITH FIVE TO SIX
VOLUMES OF WATER AND GRADUALLY NEUTRALIZE WITH SODIUM BICARBONATE,
SODA ASH OR LIME. WHEN EXPOSURE LEVEL IS NOT KNOWN, WEAR NIOSH
APPROVED SELF- CONTAINE D RESPIRATOR.
Neutralizing Agent:SODIUM BICARBONATE, SODA ASH OR LIME.

Handling and Storage Precautions:STORE AWAY FROM REACTIVE MATERIALS,
OPEN FLAMES AND SOURCES OF IGNITION.
Other Precautions:WATER SOURCE, SODIUM BICARBONATE, SODA ASH, SAND OR
LIME SHOULD BE KEPT IN SAME GENERAL AREA FOR EMERGENCY USE. WASH
HANDS THOROUGHLY AFTER HANDLING LEAD TERMINALS IN ORDER TO AVOID
INGESTION OF LEAD/ LEAD COMPOUNDS.

Respiratory Protection:ACIS GAS RESPIRATOR REQUIRED WHEN PEL IS
EXCEEDED OR EMPLOYEE WITNESSES RESPIRATORY IRRITATION.
Ventilation:WHEN PEL IS EXCEEDED LOCAL EXHAUST IS PREFERRED. USE
ADEQUATE VENTILATION TO MAINTAIN EXPOSURE BELOW PEL.
Protective Gloves:ACID RESISTANT
Eye Protection:CHEMICAL SAFETY GOGGLES/FACE SHIELD
Other Protective Equipment:ACIS-RESISTANT APRONS, BOOTS AND PROTECTIVE
CLOTHING.
Work Hygienic Practices:GOOD PERSONAL HYGIENE AND WORK PRACTICES ARE
MANDATORY.
Supplemental Safety and Health
USING NSN 6140-00-406-2633, SAME MANUFACTURER, FROM HMIS, THIS MSDS WAS
GENERATED.

HCC:C1
Appearance and Odor:LEAD/ACID BATTERY WITH DRY LEAD OXIDE PASTE ON
METALLIC LEAD FRAME.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION DUE TO HYDROGEN GENERATION.
Hazardous Decomposition Products:MAY PRODUCE OXIDES OF SULFUR AND
HYDROGEN GAS.

Waste Disposal Methods:PLACE IN ACID-RESISTANT CONTAINERS. DISPOSAL
MUST BE IN ACCORDANCE WITH APPLICABLE GOVERNMENT REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.