Product ID:5024, GG-10 AEROSOL
MSDS Date:04/29/1992
FSC:9150
NIIN:00N032550
MSDS Number: BPNCR

MANTEK DIV OF NCH CORP

IRVING, TX 75015
US

Emergency Phone: 214-438-1381

Info Phone: 214-438-1381

Preparer: M. DICKSON

Cage: GO368

NCH CORP

152170 IRVING, TX 75015-2170 US

Telephone: 972-438-0563

Cage: 20913

ETHANE, 1,1,1-TRICHLORO-; (METHYL CHLOROFORM) (SARA III).

CAS: 71-55-6

RTECS: KJ2975000

OSHA PEL 350 PPM;450 PPM STEL

ACGIH TLV: 350 PPM;450 PPM STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

BENZIN; (BLEND OF MINERAL SPIRITS)

CAS: 8030-30-6

RTECS: DE3030000

PROPANE

CAS: 74-98-6

RTECS: TX2275000

OSHA PEL 1000 PPM

ACGIH TLV: SIMPLE ASPHYXIANT

PROPANE, 2-METHYL-; (ISOBUTANE)

CAS: 75-28-5

RTECS: TZ4300000

LD50 LC50 Mixture:SEE INGREDIENT 1.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL CAN LEAD TO CNS DEPRESS
W/EFTS OF HDCH, DIZZ & NAUS & LOSS OF CONSCIOUSNESS. EYE IRRITANT.
DEFATS SKIN WHICH CAN LEAD TO IRRIT. INGEST MAY RSLT IN VOM. ASPIR
MUST BE AVOIDED TO AVOID PNEU MIT. CHRONIC: MARKED IRRIT OF
SKIN/EYE UPON CHRONIC OVEREXPOS AS WELL AS LIVER/KIDNEY DAM. TARGET
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:ORGANS: LIVER & KIDNEY. PERS W/
EXISTING SKIN, EYE, LIVER OR KIDNEY DISORDERS MAY SEE AN INCR IN
HLTH EFTS UPON CHRONIC OVEREXPOS. CHLOROCARBON MATLS HAVE PRDCED
SENSIT OF MYOCARDIUM TO EPINE PHRINE IN LAB ANIMALS & COULD HAVE
SIMILAR EFT IN HUMANS. ADRENOMIMETICS (E.G. EPINEPHRINE) MAY BE
(SUPP DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHAL:GO TO FRESH AIR & TREAT SYMPTOMATICALLY. SEE MD IF
BRTHG DFCLTY PERSISTS. EYES:FLUSH W/WATER FOR AT LEAST 15 MINS
WHILE HOLDING EYELIDS OPEN. GET MD. SKIN:WASH W/SOAP & WATER.
REMOVE CONTAMD CLT HG/SHOES. DO NOT REUSE UNTIL CLEANED. IF
PERSISTENT IRRIT OCCURS, GET MD. INGEST:DO NOT INDUCE VOM. IF VOM
OCCURS SPONT, KEEP HEAD BELOW HIPS TO PVNT ASPIR OF LIQ INTO LUNGS.
GET MD. NOTE (SUPP DATA)

Flash Point Method:TCC
Flash Point:>200F,>93C
Extinguishing Media:ALCOHOL FOAM, CO2, DRY CHEMICAL & WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESS DEMAND SCBA &
FULL PROTECTIVE EQUIP . EVACUATE HAZARD AREA OF UNPROTECTED
PERSONNEL. COOL FIRE-EXPOSED CONTAINER W/WATER.
Unusual Fire/Explosion Hazard:VAPS ARE HVR THAN AIR & MAY ACCUM IN LOW
AREAS/AREAS INADEQ VENTD. VAPS MAY ALSO TRAVEL ALONG GROUND TO BE
IGNITED AT LOCATIONS DISTANT FROM HNDLG (SUPP DATA)

Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. SINCE IT IS
IN AEROSOL PACKAGE, LARGE SPILL UNLIKELY. PICK UP W/RAGS, ETC &
PLACE INTO LABELED CONTAINERS FOR PROPER DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORAGE TEMP: 32F MINIMUM-120F
MAXIMUM. STORE INDOOR OR OUTDOOR. STORE AT MODERATE TEMPERATURES.
READ ENTIRE LABEL BEFORE USING.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. NO SMOKING IN AREA OF
USE. DO NOT USE IN THE GENERAL VICINITY OF ARC WELDING, OPEN FLAMES
OR HOT SURFACES. HEAT &/OR UV RADIATION MAY CAUSE THE FORMATION OF
HCL &/OR PHO SGENE .

Respiratory Protection:TYPICAL USE DOES NOT REQUIRE RESPIRATORS.
HOWEVER IN EMERGECY SITUATION WHERE EXOSURE EXCEEDS OSHA'S
STANDARDS: NIOSH/MSHA APPROVE 500PPM/SAF/SCBAF.
Ventilation:GENERAL EXHAUST IS ADEQUATE UNDER NORMAL CIRCUMSTANCES.
Protective Gloves:PVA GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:NOT APPLICABLE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ:SITE. THERMAL DECOMPOSITION PRODUCTS MAY INCLUDE HCL &
PHOSGENE . EFTS OF OVEREXP:CONTRAINDICATED EXCEPT FOR
LIFE-SUSTAINING USES IN HUMANS ACUTELY/CHRONICALLY EXPOSED TO
CHLOROCARBONS . FIRST AID PROC:TO MD: GASTRIC LAVAGE IS INDICATED.

Boiling Pt:B.P. Text:105F,41C
Vapor Pres:50
Vapor Density:5.0
Spec Gravity:0.900 (H2O=1)
Evaporation Rate & Reference:5 (BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK, OPAQUE; PETROLEUM ODOR.
Percent Volatiles by Volume:15

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:OPEN FLAMES.
Hazardous Decomposition Products:UPON THERMAL DECOMPOSITION HCL FUMES
MAY BE FORMED AS WELL AS PHOSGENE POSSIBLY.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/ALL FEDERAL, STATE &
LOCAL POLLUTION REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.