Product ID:AEROSOL SPRAY PAINT, 1238 LEMON YELLOW
MSDS Date:03/23/1988
FSC:8010
NIIN:00N023381
MSDS Number: BQBFS

ZYNOLYTE PRODUCTS INC

2320 E DOMINGUEZ ST
CARSON, CA 90749
US

Emergency Phone: 213-513-0700;800-424-9300(CHEMTREC)

Info Phone: 213-513-0700

Cage: 25461

ZYNOLYTE PRODUCTS CO

6244 CARSON, CA 90749 US

Telephone: 310-513-0700

Cage: 25461

INHAL STUDY THERE WAS A SLIGHT EXPRESSION IN THE

RTECS: 9999999ZZ

SKIN RASH, ITCHING & SWELLING. ETHYL

RTECS: 9999999ZZ

ANEMIA W/& INCR IN WHITE BLOOD CELLS;FATTY

RTECS: 9999999ZZ

MAY CAUSE ABNORM LIVER

RTECS: 9999999ZZ

SOME LAB ANIMALS INDICATE THIS CMPD MAY HAVE

RTECS: 9999999ZZ

ACRYLIC POLYMER

CAS: 25608-63-7

CLAY (KAOLIN); (ALUMINUM SILICATE)

CAS: 1332-58-7

RTECS: GF1670500

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 2 MG/M3 TDUST; 9293

SILICON DIOXIDE, AMORPHOUS; (AMORPHOUS SILICA)

CAS: 7631-86-9

OSHA PEL 6 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

10.0 @ 20C

CAS: 64742-95-6

OSHA PEL 25 PPM (MFR)

ACGIH TLV: 25 PPM (MFR)

PIGMENT, BONE RED

CAS: 16013-44-8

DIATOMACEOUS EARTH

CAS: 7631-86-9

OSHA PEL 6 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

METHANE, DICHLORODIFLUORO-; (DICHLORODIFLUOROMETHANE)

CAS: 75-71-8

RTECS: PA8200000

OSHA PEL 1000 PPM

ACGIH TLV: 1000 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

1.7 @

CAS: 108-83-8

RTECS: MJ5775000

OSHA PEL 50 PPM

ACGIH TLV: 25 PPM; 9293

DIPROPYLENE GLYCOL, MONOMETHYL ETHER; (DIPROPYLENE GLYCOL

CAS: 34590-94-8

RTECS: JM1575000

OSHA PEL 100 PPM; 150 STEL, S

ACGIH TLV: 100 PPM; 150 STEL, S

76.0 @ 20C

CAS: 141-78-6

RTECS: AH5425000

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ETHYL ALCOHOL; (ETHANOL (MFR CAS NO 152-51-2))

CAS: 64-17-5

RTECS: KQ6300000

OSHA PEL 1000 PPM

ACGIH TLV: 1000 PPM

BLUE PIGMENT; (PHTHALOCYANINE BLUE PIGMENT)

CAS: 147-14-8

POLYESTER PLASTICIZER

INHAL DOSES IN LAB ANIMALS HAVE SHOWN WT CHANGES

RTECS: 9999999ZZ

HEART & ADRENAL GLAND. IN ADDN LIVER/KIDNEY INJURY

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INGEST:GI DISTRESS. INHAL:OVEREXPOS
MAY CAUSE NOSE/THROAT IRRIT. MAY CAUSE CNS EFTS SUCH AS DIZZ, HDCH,
NAUS, STAG GAIT, CONFUSN & UNCON. RPTS HAVE ASSOC RPTD/PRLNGD
OVEREXPOS TO SOLV W/PERM BRAIN & N ERV SYS DAM. EYE WATERING, HDCH,
NAUS, DIZZ & LOSS OF COORDINATION ARE SIGNS THAT SOLV LEVELS ARE
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:TOO HIGH. EYE:MAY CAUSE IRRIT/BURNING.
SKIN/ACRYLIC POLYMER:RPTD/PRLNGD LIQ CONT MAY CAUSE SKIN IRRIT
W/DISCOMFORT/DERM. AROMATIC HYDROCARBON:RECURRENT OVEREXPOS MAY
RSLT IN LIVER/KIDNEY INJU RY. HAS BEEN TOX TO THE FETUS IN LAB
ANIMALS AT DOSES THAT ARE TOX TO THE MOTHER. DIATOMACEOUS EARTH:
(SUPP DATA)
Medical Cond Aggravated by Exposure:INDIVIDUALS W/PRE-EXISTING DISEASE
OF THE LIVER, CENTRAL NERVOUS SYSTEM, GI TRACT OR REPRODUCTIVE
ORGANS MAY HAVE INCREASED SUSEPTABILITY TO THE TOXICITY OF
EXCESSIVE EXPOSURES.

First Aid:INGEST:CALL A MD IMMEDIATELY & HAVE NAME OF INGREDIENTS
AVAILABLE. DO NOT INDUCE VOMITING. INHAL:REMOVE TO FRESH AIR. IF
NOT BREATHING, GIVE ARTIFICIAL RESPIRATION, PREFERABLY MOUTH TO
MOUTH. IF BREAT HING DIFFICULTY PERSISTS, OR OCCURS LATER, CONSULT
A MD. EYE:IMMEDIATELY FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS.
CALL A MD. SKIN:WASH W/SOAP & WATER. IF IRRITATION OCCURS, CONTACT
A MD.

Flash Point Method:CC
Flash Point:<20F,<-7C
Extinguishing Media:FOAM, CARBON DIOXIDE & DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL PROT
EQUIP . WATER MAY BE INEFT. WATER FROM FOG NOZZLES MAY BE USED TO
COOL CLSD CONTRS TO PREVENT PRESSURE BUILDUP.
Unusual Fire/Explosion Hazard:CONTENTS UNDER PRESSURE. KEEP AT ROOM
TEMP AS EXPOSURE TO SUNLIGHT OR OTHER HEAT MAY CAUSE CANS TO BURST,
PROPELLING CONTENTS ACROSS AREA.

Spill Release Procedures:VENTILATE AREA. REMOVE SOURCES OF IGNITION.
PREVENT SKIN CONTACT & BREATHING OF VAPOR. CONFINE & REMOVE W/INERT
ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DO NOT STORE ABOVE 120F. KEEP AWAY
FROM HEAT, SPARKS & FLAME. DO NOT EXPOSE TO DIRECT SUNLIGHT TO
AVOID BURSTING. OBSERVE LABEL PRECAUTIONS.
Other Precautions:DO NOT SAND, FLAME CUT, BRAZE OR WELD DRY COATING
W/OUT NIOSH/MSHA APPROVED RESPIRATOR OR APPROPRIATE VENTILATION. DO
NOT PUNCTURE. DO NOT SPRAY NEAR FIRE OR OPEN FLAME.

Respiratory Protection:DO NOT BREATHE VAPORS/MIST. WEAR AN APPROPRIATE,
PROPERLY FITTED NIOSH/MSHA APPRVD RESPIRATOR DURING & AFTER
APPLICATN UNLESS AIR MONITORING DEMONSTRATES VAPOR/MIST LEVELS ARE
BELOW APPLIC LIMITS. FOL LOW RESP MFRS DIRECTIONS FOR RESP USE.
Ventilation:PROVIDE SUFFICIENT VENTILATION IN VOLUME & PATTERN TO KEEP
CONTAMINANTS BELOW APPLICABLE OSHA REQUIREMENTS.
Protective Gloves:NEOPRENE GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:COVERALLS RECOMMENDED.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE EATING
& SMOKING.
Supplemental Safety and Health
SOL IN H*2O:MOD-APPRECIABLE, DEPENDING ON COLOR. EFTS OF
OVEREXP:RPTD/PRLNGD OVEREXPOS MAY LEAD TO CHRONIC LUNG DISEASE.
DICHLORODIFLUOROMETHANE:MAY CAUSE TEMPORARY ALTERATION OF THE
HEARTS ELEC ACTIV ITY, RSLTG IN IRREG &/OR RAPID HEAT BEAT, OR
INADEQ CIRCULATION. DIISOBUTYL KETONE:EXTREMELY HIGH ORAL & (INGRED
14)

HCC:V3
Boiling Pt:B.P. Text:0F,-18C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:0.738
Evaporation Rate & Reference:FASTER THAN ETHER
Solubility in Water:(SEE SUPP DATA)
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:92

Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Stability Condition to Avoid:DO NOT STORE ABOVE 120F.
Hazardous Decomposition Products:CO, CO*2, SMOKE & OXIDES OF HEAVY
METALS.

Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. INCINERATE ABSORBED MATERIAL IN ACCORDANCE
W/FEDERAL, STATE & LOCAL REQUIREMENTS. DO NOT INCINERATE IN CLOSED
CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.