Product ID:ABLEBOND 167-1
MSDS Date:12/28/1988
FSC:8040
NIIN:00F026642
MSDS Number: BQJRY

ABLESTIK LAB SUB OF NATL STARCH/CHEM

20021 SUSANA RD
RANCHO DOMINGUEZ, CA 90221
US

Emergency Phone: 213-764-4600

Info Phone: 213-764-4600

Cage: 21109

ABLESTIK LABS SUB OF NATIONAL STARCH AND CHEMICAL

COMPTON, CA 90221 US

Telephone: 310-764-4600

Cage: 21109

EPICHLOROHYDRIN, CHLOROMETHYLOXIRANE (SUSPECTED HUMAN

CAS: 106-89-8

RTECS: TX4900000

Fraction By Weight: 0.01%

OSHA PEL S, 5 PPM

ACGIH TLV: S, 2 PPM; 9293

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

N-BUTYL GLYCIDYL ETHER

CAS: 2426-08-6

RTECS: TX4200000

Fraction By Weight: 1-2%

OSHA PEL 50 PPM

ACGIH TLV: 25 PPM; 9293

SILVER

CAS: 7440-22-4

RTECS: VW3500000

Fraction By Weight: 65-80%

OSHA PEL 0.01 MG/CUM

ACGIH TLV: 0.1 MG/CUM

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION TO NOSE, THROAT
& RESPIRATORY TRACT. EYES: CAN CAUSE SEVERE IRRITATION. INGESTION:
UNKNOWN, HOWEVER, MODERATE POTENTIAL FOR ORAL TOXICITY IS EXPECTED.
Explanation of Carcinogenicity:SEE INGREDIENTS.
Effects of Overexposure:SKIN: PROLONGED OR REPEATED CONTACT CAN RESULT
IN IRRITATION, DERMATITIS & SENSITIZATION. INHALATION: MAY BE
HARMFUL.

First Aid:SKIN: WASH IMMEDIATELY WITH SOAP & WATER; IF IRRITATION
PERSISTS, SEEK MEDICAL ATTENTION. EYE: FLUSH W/WATER FOR 15 MINS.
INHALATION: REMOVE TO FRESH AIR IMMEDIATELY. INGESTION: SEEK
MEDICAL ATTENTION IMMEDIATELY & SHOW INSERT CARD. OBTAINMEDICAL
ATTENTION IN ALL CASES.

Flash Point Method:SCC
Flash Point:164F
Extinguishing Media:CO2, FOAM, DRY CHEMICAL
Fire Fighting Procedures:WEAR SCBA.
Unusual Fire/Explosion Hazard:BGE MAY BE VAPORIZED & TOXIC GAS MAY BE
RELEASED UPON COMBUSTION. IF PRODUCT ISN'T USED FOR THIN LINE
APPLICATION, VIOLENT CHEMICAL REACTION CAN RESULT.

Spill Release Procedures:WIPE UP WITH SOLVENT SATURATED TOWELING &
COLLECT IN AN APPROPRIATE CONTAINER FOR DISPOSAL.

Handling and Storage Precautions:STORE FROZEN AT -40C AT ALL TIMES
PRIOR TO USE.
Other Precautions:USE W/CAUTION UPON CURING. VENT CURING OVEN TO
OUTDOORS. AVOID INHALATION OF VAPORS OR CONTACT WITH SKIN, EYES OR
CLOTHING.

Respiratory Protection:NIOSH APPROVED TOXIC DUST MASK IF CURED PRODUCT
IS TO BE DRY SANDED OR GROUND.
Ventilation:ADEQUATE/LOCAL EXHAUST WHEN APPROPRIATE TO CONTROL
EXPOSURE.
Protective Gloves:RUBBER
Eye Protection:SAFETY GLASSES W/SIDE SHIELDS
Other Protective Equipment:PROTECTIVE EQUIPMENT TO COVER EXPOSED AREAS.
Work Hygienic Practices:REMOVE AND LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. GOOD HOUSEKEEPING IS REQUIRED.
Supplemental Safety and Health
SILVER ISN'T HAZARDOUS AFTER IT HAS BEEN BLENDED INTO EPOXY RESIN. IF
CURED ADHESIVE IS TO BE DRY SANDED OR GROUND, FOLLOW
RECOMMENDATIONS. WET SANDING IS RECOMMENDED TO ELIMINATE AIRBORNE
SILVER.

Vapor Density:>1
Spec Gravity:4.1
Solubility in Water:INSOLUBLE
Appearance and Odor:SILVER PASTE, MILD DILUENT ODOR.
Percent Volatiles by Volume:<1

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS & STRONG LEWIS OR MINERAL ACIDS.
Stability Condition to Avoid:HEAT PRIOR TO CURE.
Hazardous Decomposition Products:CO, ALDEHYDES, OXIDES OF NITROGEN &
ACIDS.

Waste Disposal Methods:DISPOSE OF IN APPROVED CHEMICAL DISPOSAL AREA OR
IN A MANNER WHICH COMPLIES WITH ALL LOCAL, STATE & FEDERAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.