Product ID:ROCK DRILL OIL VISTAC ISO 32, CPS232500
MSDS Date:12/15/1990
FSC:9150
NIIN:00N035894
MSDS Number: BQLLM

CHEVRON

RICHMOND, CA 94804
US

Emergency Phone: 800-457-2022;800-424-9300(CHEMTREC)

Info Phone: 800-582-3835

Cage: 0AHD1

CHEVRON ENVIRONMENTAL HEALTH CENTER INC

4054 RICHMOND, CA 94804 US

Telephone: 800-582-3835

Cage: 0AHD1

ADDITIVES

Fraction By Weight: 4%

PARAFFIN WAXES AND HYDROCARBON WAXES, CHLORINATED;

CAS: 63449-39-8

RTECS: RV0450000

Fraction By Weight: 6%

GIVE WATER/MILK TO DRINK &

RTECS: 9999999ZZ

INDUCING VOMIT. IF MED ADVICE CANNOT BE OBTAINED,

RTECS: 9999999ZZ

TREATMENT CENTER OR HOSPITAL.

RTECS: 9999999ZZ

WATER/GROUND WATER.CLEAN UP SMALL SPILLS USING

RTECS: 9999999ZZ

WHERE FEASIBLE & APPROP, REMOVE CONTAM SOIL. FOLLOW

RTECS: 9999999ZZ

TO LARGER RELEASES.

RTECS: 9999999ZZ

OIL; (CHEVRON ROCK DRILL OIL VISTAC ISO 32) (CONSISTING OF

CAS: 64742-98-6

Fraction By Weight: 100%

LUBRICATING BASE OIL (MAY BE A MIX OF ANY OF THE

64742-01-4, 64742-52-5, 64742-53-6, 64742-54-7,

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE:IRRIT POTENTIAL IF SUBSTANCE HAS
NOT BEEN DETERMINED. HOWEVER, IT MAY BE SLIGHTLY IRRIT & COULD
CAUSE PRLNGD (DAYS) IMPAIRMENT OF VISION. DEGREE OF INJURY WILL
DEPEND ON AMT OF MATL THAT GETS INTO EYES & SPEED & THOROUGHNESS
OF FIRST AID TREATMENT. SIGNS & SYMPS MAY INCL PAIN, TEARS,
SWELLING, (EFTS OF OVEREXPOS)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:REDNESS & BLURRED VISION. HAZ
EVALUATION IS BASED ON KNOWN TOX OF INGRED IN SUBSTANCE.
SKIN:PRLNGD/FREQUENTLY RPTD CONT MAY CAUSE SKIN TO BECOME
CRACKED/DRY FROM DEFATTING ACTION OF MATL. HAZ EVALUATION IS BASED
ON KNOWN IRRIT POTENTIAL OF INGRED IN SUBSTANCE. INHAL:BRTHG VAP
MAY BE IRRIT TO RESP (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYES:FLUSH IMMED W/FRESH WATER FOR AT LEAST 15 MIN WHILE
HOLDING EYELIDS OPEN. REMOVE CONTACT LENSES IF WORN. IF IRRIT
PERSISTS, SEE A MD. SKIN:REMOVE CONTAM CLTHG. WASH SKIN THORO
W/SOAP & WATER. SEE MD IF ANY SIGNS/SYMPS DESCRIBED OCCUR.DISCARD
CONTAM NON-WATERPROOF SHOES & BOOTS. WASH CONTAM CLTHG. INHAL:IF
RESP DISCOMFORT/IRRIT OCCURS, MOVE TO FRESH AIR. SEE MD IF
DISCOMFORT/IRRIT (ING 6)

Flash Point Method:COC
Flash Point:324F,162C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM AND WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:DO NOT WELD, HEAT/DRILL CONTR. RESIDUE
MAY IGNITE W/EXPLOS VIOLENCE IF HEATED SUFFICIENTLY. DO NOT USE
PRESSURE TO EMPTY OR EXPLOS MAY RESULT.

Spill Release Procedures:MATL IS NOT EXPECTED TO PRESENT ANY ENVIRON
PROBLEMS OTHER THAN THOSE ASSOC W/OIL SPILL. STOP SOURCE OF
LEAK/RELEASE. CLEAN UP RELEASES AS SOON AS POSS, OBSERVING
PRECAUTIONS IN PROT EQUIP. CONTAIN LI Q TO PREV FURTHER CONTAM OF
SOIL, SURF (ING 9)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:PRODUCT CONTAINS PETROLUEM BASE OIL WHICH MAY BE
REFINED BY VARIOUS PROCESSES INCLUDING SEVERE SOLVENT EXTRACTION,
SEVERE HYDROCRACKING OR SEVERE HYDROTREATING.

Respiratory Protection:NO SPECIAL REPIRATORY PROTECTION IS NORMALLY
REQUIRED. HOWEVER, IF OPERATING CONDITIONS CREATE AIRBORNE
CONCENTRATIONS WHICH EXCEED RECOMMENDED EXPOSURE STANDARDS, USE OF
AN NIOSH/MSHA APPROVED RESPIR ATOR IS REQUIRED.
Ventilation:USE THIS MATERIAL ONLY IN WELL VENTILATED AREAS.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:SKIN CONTACT CAN BE MINIMIZED BY WEARING
PROTECTIVE CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
DECOMP PROD:CAN PRODUCE CARBON MONOXIDE. COMBUSTION MAY PRODUCE TOXIC
COMPOUNDS OF CHLORINE. EFTS OF OVEREXPOS:TRACT. INGEST:SYSTEMIC
TOX OF SUB HAS NOT BEEN DETERMINED. HOWEVER, IT SHOULD BE PRACTIC
ALLY NON-TOXIC TO INTERNAL ORGANS IF INGESTED.

HCC:V6
Spec Gravity:0.92
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR AMBER LIQUID

Stability Indicator/Materials to Avoid:YES
MAY REACT WITH STRONG OXIDIZING AGENTS, SUCH AS CHLORATES, NITRATES,
PEROXIDES, ETC.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NORM COMBUST FORMS CARBON DIOXIDE &
WATER VAP & MAY PRODUCE OXIDES OF SULFUR & PHOSPHORUS. IMCOMPLETE
COMBUST (SUPDAT)

Waste Disposal Methods:PLACE CONTAM MATL IN DISP CONTRS & DISP OF IN A
MANNER CONSISTENT W/APPLIC LOC, STATE & FED REGS. CONSULT LOC,
STATE & FED ENVIRON/HLTH AUTHORITIES FOR APPRVD DISP OF THIS MATL.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.