Product ID:209832-03W
MSDS Date:10/02/1988
FSC:8030
NIIN:01-003-4235
Kit Part:Y
MSDS Number: BQWFF

Emergency Phone: 818/ 240-2060

Cage: 05027

Telephone: 818-240-2060]

Cage: 05027

EPOXY RESIN

CAS: 25068-38-6

RTECS: KC2100000

PHENOL FORMALDEHYDE RESIN

CAS: 9003-35-4

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE SKIN OR EYE IRRITATION UPON
CONTACT.
Explanation of Carcinogenicity:NONE OF THE CHEMICALS IN THIS PRODUCT IS
LISTED BY IARC, NTP OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYES: IRRITATION AND SEVERE EYE DAMAGE. SKIN:
SEVERE SKIN IRRITATION. MAY BE A SKIN SENSITIZER. INHALATION:
HEADACHE, NAUSEA, VOMITING AND POSSIBLE DAMAGE TO PERIPHERAL
NERVOUS SYSTEM. INGESTURE: NONE OBSERVED.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF SKIN AND
RESPIRATORY DISORDERS MAY BE AT INCREASED RISK FROM EXPOSURE.

First Aid:EYE: IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR 15 MINUTES.
GET MEDICAL ATTENTION. SKIN: WASH WITH SOAP AND WATER. INHALATION:
REMOVE TO FRESH AIR. INGESTION: GIVE MILK OR WATER TO DRINK,GET
MEDICAL A TTENTION.

Flash Point Method:PMCC
Flash Point:188F,87C
Lower Limits:1.8
Upper Limits:11.5 (MEK)
Extinguishing Media:USE WATER SPRAY, FOAM, CO2, OR DRY CHEMICAL.
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE

Spill Release Procedures:SCOOP INTO CONTAINER. CLEAN UP RESIDUE WITH A
CHLORINATED SOLVENT. NOT A HAZARDOUS WASTE ACCORDING TO EPA
REGULATION. CONSULT STATE REGULATIONS PRIOR TO DISPOSAL OF
SPILLAGE.

Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA AWAY FROM SOURCES OF IGNITION. KEEP CONTAINER CLOSED WHEN NOT
IN USE. PROTECT FROM PHYSICAL DAMAGE.
Other Precautions:NONE.

Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL (TLV), USE NIOSH/MSHA APPROVED RESPIRATOR AS
PER CURRENT 29 CFR 1910.134, INSTRUCTIONS/WARNINGS AND
NIOSH-RESPIRATOR SELECTION.
Ventilation:GENERAL VENTILATION IS USUALLY ADEQUATE.
Protective Gloves:SOLVENT-RESISTANT GLOVES.
Eye Protection:SAFETY GLASSES.
Other Protective Equipment:SAFETY SHOWER AND EYE BATH. INDUSTRIAL TYPE
WORK CLOTHING AND APRON AS REQUIRED TO AVOID PROLONGED OR REPEATED
CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING OR DRINKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NONE.

HCC:N1
Vapor Density:2.42 (MEK)
Spec Gravity:1.40
Solubility in Water:SILGHT
Appearance and Odor:GRAY PASTE
Percent Volatiles by Volume:.2

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS AND STRONG ACIDS.
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION.
Hazardous Decomposition Products:OXIDES OF CARBON,STRONG OXIDIZING
AGENTS.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.